Vehicle hops into curves, across yellow line. Steering problems occur. Dealer contacted, and attempted to remedy problem. States normal conditions. Problem still exists. Provide further information.
The worst 1999 Freightliner FLD problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Steering1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Steering1
Recalls 8
Suspension: front: hub
- What is wrong
- On certain trucks equipped with truck hub units manufactured by skf exclusively for use on arvinmeritor's ff98x series non-drive steer axles, the hub unit bearings can wear prematurely.
- Risk
- Seizure of the bearings can cause wheel separation or wheel end fire.
- Remedy
- Dealers will replace both front hubs. Owner notification is expected to begin on or before september 20, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1‑800‑547‑0712.
Recall number 03V112000 · Recall details
Steering: linkages: tie rod assembly
- What is wrong
- Vehicle description: heavy duty trucks equipped with trw tie rod ends on certain meritor axles. The tie rod and drag link ball stud ends contain bearings that are below the specified case depth and/or hardness.
- Risk
- This can lead to premature wear with possible separation of the ball stud from the socket, increasing the risk of loss of control of the vehicle.
- Remedy
- Dealers will remove and replace all affected tie rods and drag links with different designed ends. Owner notification began november 8, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1‑800‑547‑0712.
Recall number 01V140007 · Recall details
Steering: linkages: tie rod assembly
- What is wrong
- Vehicle description: trucks, school bus and motor home chassis, and transit buses equipped with tie rod assemblies manufactured by trw. The suspect tie rods contain 24-dl model ball sockets. Certain of the tie rod ball-socket bearings have a below-specification case depth and/or hardness, which can lead to premature wear of the socket.
- Risk
- If this condition occurs, the driver can lose partial control of the right front wheel, possibly resulting in a crash.
- Remedy
- Dealers will replace the defective ball sockets and/or drag links. Owner notification began may 22, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1‑800‑547‑0712 or trw customer service at 1‑866‑280‑3287.
Recall number 01V044002 · Recall details
Service brakes, air: antilock
- What is wrong
- Vehicle description: heavy duty trucks and school bus chassis built with bendix air ABS with an ec-17 1030r electronic control unit (ecu), there have been reports of unwanted ABS activation at low speeds caused by 1) chafed ABS wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of erratic sensor signal.
- Risk
- This condition could cause the ABS ecu to exhaust the air at the air brake modulators for one or more of the wheels. This could result in extended braking distances and a possible crash.
- Remedy
- Dealers will replace the ABS ecu.
Recall number 00V232002 · Recall details
Suspension: rear: springs: air suspension system
- What is wrong
- Vehicle description: heavy duty trucks built with dual leaf spring type air ride suspensions and vehicles built with single leaf spring type air ride suspensions. Rear suspension springs can fracture through the center bolt hole after vehicle assembly.
- Risk
- If undetected, the rear end of the spring could separate from the vehicle causing a hazardous road debris situation.
- Remedy
- For vehicles equipped with single leaf springs, dealers will remove and replace all springs. For vehicles equipped with dual leaf springs, dealers will inspect for cracked springs and replace if cracked.
Recall number 00V081000 · Recall details
Suspension: front: hub
- What is wrong
- Vehicle description: heavy duty trucks. The outboard bearing on the steering axle hubs can fail due to water intrusion through a hubcap vent.
- Risk
- This condition can result in a separation of the wheel.
- Remedy
- Dealers will remove the hubcap and inspect for water intrusion and corrosion. The hub and bearing assembly will be replaced if there is evidence of corrosion. A non-vented hubcap will be installed.
Recall number 99V295000 · Recall details
Electrical system: ignition: module
- What is wrong
- Vehicle description: heavy duty trucks equipped with caterpillar engines and eaton autoshift transmissions. The engines can stall because of software problems.
- Risk
- Increased steering effort can occur.
- Remedy
- Caterpillar is conducting the owner notification and remedy of this recall. Dealers will update these engines with software changes.
Recall number 99V181002 · Recall details
Suspension: rear
- What is wrong
- Vehicle description: trucks equipped with tuftrac suspensions. The rear suspension axle clamps can fracture, allowing the rear axle to shift.
- Risk
- This condition could cause a loss of vehicle control, increasing the risk of a crash.
- Remedy
- Dealers will install new upper and lower axle clamps.
Recall number 99V172000 · Recall details
Technical service bulletins for the 1999 Freightliner FLD 2
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
What 1999 Freightliner FLD owners say
Most recent owner complaints, unedited.
Compare the 1999 Freightliner FLD
Other model years
Questions about the 1999 Freightliner FLD
Is the 1999 Freightliner FLD reliable?
Owners have filed 1 complaint about the 1999 Freightliner FLD, close to a typical FLD model year.
What is the most common problem with the 1999 Freightliner FLD?
Steering, with 1 complaint.
How many recalls does the 1999 Freightliner FLD have?
8 recalls, covering suspension, steering and service brakes, air.
Was there a recall on the 1999 Freightliner FLD steering?
Yes, 2 recalls: 01V140007, 01V044002. Check your VIN to see if your car still needs the free repair.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1999 Freightliner FLD?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history