Fire inside dash of vehicle. Fire was caused by a defective module that already has a safety recall. The mfg. Will not replace parts/repair vehicle. They state vehicle had recall done already. Replacement parts are not available as the recall updates supercedes these parts with an upgrade kit (the recall).
The worst 2003 Gem Nev problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Electrical1
- Suspension1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Electrical1
- Suspension1
Recalls 1
Electrical system
- What is wrong
- On certain 2 and 4 passenger, short and long bed low speed vehicles, the 12 volt output from the auxiliary card circuit board (a dc voltage to dc voltage converter) may become inoperative and result in loss of headlamp, tail lamp and turn signal lamp functions.
- Risk
- A loss of headlamps could impair a driver's visibility, increasing the risk of a crash. If there is a loss of tail lamp or turn signal lamp function, a following driver may not know when the brakes have been applied or that the vehicle in front is turning, a rear-end crash could occur without prior warning.
- Remedy
- Dealers will replace the auxiliary cards, install a splash/spray protection, and adjust the dash seal free of charge. The recall began on september 11, 2006. Owners may contact global electric at 888‑871‑4367.
Recall number 06V222000 · Recall details
See all 1 recalls for the 2003 Gem Nev
Defect investigations
Pedestrian alert sounds
the federal safety agency received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, the federal safety agency opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified the federal safety agency he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by the federal safety agency regarding the subject matter of the petition.
DP22005
Technical service bulletins for the 2003 Gem Nev 4
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard...
- Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to...
- Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision...
- Gem: installation of the riv nut as a replacement to the rubber well nut for the framed canvas door...
What 2003 Gem Nev owners say
Most recent owner complaints, unedited.
Tl*the contact owns a 2003 chrysler electric gem. While driving at 10 MPH the contact heard a loud clinking noise coming from the front of the vehicle. The faster the vehicle accelerated the louder the noise became . The contact called global electric motor company, and they suggested that the failure may be the front axle. The necessary parts for the repair were on back order. The current mileage was 7,346, and failure mileage was unknown.*ak the consumer stated that the dealer set up appointment and came to repair the vehicle. Update 05/04/07
Compare the 2003 Gem Nev
Other model years
Questions about the 2003 Gem Nev
Is the 2003 Gem Nev reliable?
Owners have filed 2 complaints about the 2003 Gem Nev, close to a typical Nev model year.
What is the most common problem with the 2003 Gem Nev?
Electrical system, with 1 complaint. Next is suspension (1).
How many recalls does the 2003 Gem Nev have?
1 recall, covering electrical system.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2003 Gem Nev?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history