2020 GMC Terrain: brake failure

Filed Sep 23, 2026 · Brakes, Engine · NC

While driving my 2020 GMC Terrain, I experienced a sudden loss of normal braking assistance. I had been traveling on the highway and exited onto a main road. As I approached a red traffic light at approximately 50 mph and attempted to brake, the vehicle would not stop normally. I was unable to stop for the red light and went through the intersection before I was able to safely get the vehicle off the roadway. Fortunately, there was no vehicle directly in front of me and I was able to make it through the intersection before any other cars, so no collision occurred. The vehicle was subsequently inspected and diagnosed by a GMC dealership. A diagnostic scan performed after the incident showed code P0556 for the brake booster pressure sensor circuit range/performance. The GMC dealership later diagnosed problems involving the vacuum pump, exhaust camshaft, and timing components and recommended replacement of the vacuum pump, exhaust camshaft, timing components, and related parts.” The sudden loss of braking assistance created a serious safety hazard and could have resulted in a collision, serious injury, or death. The vehicle is currently available for inspection.

Filed Jul 23, 2026 · Brakes, Engine · NH

Vacuum pump failure causing sudden and unexpected hard brake pedal and loss of braking coming off the highway. Ended up catastrophic engine failure. This is the SECOND incident with this vehicle of the exact same problem. GMC refuses to address this issue and continues to risk the lives of their customers.

Filed Jun 8, 2026 · Brakes, Engine · AZ

On June 7, 2026, I was driving my 2020 GMC Terrain. I was going at about 40MPH along a very busy main road. While slowing for a red light the Check Engine Light turned on and the car displayed a notice about reduced engine power. Seconds later, the brake pedal became stuck and would not press down all the way and I lost braking ability. The car rattled/shook violently, made a grinding noise, and then the engine shut off and the car stopped abruptly, narrowly avoiding hitting the car in front of us. I turned on the hazard lights. I was not able to get the car to start again, nor was I able to get the car to shift into any other gear including neutral. We were nearly hit by other vehicles multiple times while attempting to get the car to move again, and to get myself and my child safely out of the road. Myself and multiple bystanders attempted to engage the transmission interlock override multiple time. We were eventually able to engage it and push the car to the side of the road. This failure created an extremely unsafe situation for all involved as this road is very busy and there were numerous near-collisions both with my disabled vehicle, and with other drivers serving out of the way and into other lanes at the last second. As time went on and the battery drained, most of the car's exterior lights turned off and other drivers had a hard time seeing my car. I used a strobe flashlight to alert other drivers but this required that I had to stand in the road near the vehicle. Police were called immediately when I found that we could not move the car out of the road, but they did not arrive. Ultimately the vehicle was stuck and inoperable in a travel lane for over two hours. The car was then towed to a nearby repair shop. The mechanic evaluation stated that the brake vacuum pump had failed resulting in loss of braking ability and expensive damage to the engine and other components. The manufacturer is aware of this issue. See: Thieme, et al. v. General Motors LLC.

Filed Jun 8, 2026 · Brakes · VA

The brake vacuum pump had a catastrophic failure which resulted in the immediate loss of all brakes in the vehicle. I had the vehicle repaired only to find that GM has issued numerous repair bulletins to dealers and mechanics. This appears to be an issue known to them. As the vehicle was repaired, the parts are no longer available for inspection. This was a danger to me and others around me because I was traveling 60mph down hill with no means to slow or stop. I narrowly avoided an accident. There were no warning lamps before the incident. A warning lamp did come on after the loss of brakes but only after I attempted to brake.

Filed Jun 8, 2026 · Brakes, Engine · AL

During my daily commute to work on the interstate the service break assist message came on my dash and when attempting to break the pedal was very hard, to the point where I had to push extremely hard and quickly realized I had to brake much much soon than normal to prevent hitting other vehicles. Sudden loss of brakes put me and other drivers at risk due to my near inability to slow down or stop and the sudden and unexpected nature of the event.

Filed Jun 6, 2026 · Brakes, Engine · NH

I am a [XXX] resident. While commuting to work in [XXX], my GMC Terrain experienced a sudden, catastrophic failure of the brake vacuum pump while traveling at highway speeds. When I attempted to slow down for the exit, the brake pedal instantly became extremely stiff and nearly impossible to depress. I realized I had suffered an absolute loss of power braking assist. To avoid a high-speed collision with heavy highway traffic, I was forced to deliberately steer onto the roadside rumble strips, relying on tire friction to slow the vehicle down. This severe near-miss left me terrified and distraught. Because the shoulder was narrow, my disabled vehicle was left partially protruding into the active roadway. Passing cars sped by so close that my vehicle was violently rocking, creating an incredibly unsafe situation. I was forced to call the State Police for emergency assistance. They dispatched a trooper and a tow truck to remove me and the vehicle safely from the highway. The vehicle was towed to a mechanic in Massachusetts. The mechanic discovered that the vacuum pump had internally exploded. This explosion sent catastrophic metal shards and debris directly into the engines oil galleys and oiling system. While the vehicle has 121,776 miles, this is not a normal wear-and-tear component failure. The brake vacuum pump suffered a catastrophic internal mechanical explosion at highway speeds, completely eliminating my ability to stop the vehicle. A mechanical component failure should never cause an immediate, life-threatening loss of brake control, regardless of mileage. This is a known, systemic engineering defect that is currently the subject of active federal class-action litigation (XXX v. General Motors LLC). This defect did not just cause an immediate life-threatening braking failure, it completely contaminated the oiling system, destroyed the entire engine, and rendered the vehicle a total loss requiring a full engine replacement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552

Filed May 26, 2026 · Brakes, Engine · AL

I am submitting this complaint regarding a serious and dangerous brake failure involving my 2020 GMC Terrain SLT with approximately 150,000 miles. While driving, the vehicle suddenly experienced a vacuum pump failure that caused a severe loss of braking ability with no warning beforehand. The brake pedal became extremely hard, and the vehicle would barely stop. This created a very dangerous situation and could have easily resulted in a serious accident. Thankfully, I was not driving at a high speed when the failure occurred, and there were no vehicles directly in front of me at the time. However, only minutes earlier I had been traveling approximately 65–70 mph on the highway. If this brake failure had occurred while driving at highway speeds or in heavy traffic, I truly believe it could have caused a major crash resulting in serious injury or death. What concerns me most is that there was no warning before the brakes failed. No warning lights and no issues with my brakes. The sudden loss of braking power was extremely frightening and created an immediate safety hazard. After researching this issue, I discovered that other GMC and GM vehicle owners have reported similar vacuum pump failures and brake assist problems. I believe this is a significant safety issue that should be investigated further. Drivers should not experience sudden brake failure without warning, especially on a vehicle that otherwise appeared to be operating normally beforehand. I am very thankful no one was injured in my situation, but I am concerned that another driver may not be as fortunate. My vehicle had to be towed to a nearby shop and they suspected it was the vacuum pump failure and the car started smoking badly. so I had it towed to the GMC dealership and they called me today to confirm that was the problem and it also caused damage to the camshaft. This is a known issue with the terrain and there is currently a class action lawsuit.

Filed Dec 3, 2025 · Brakes · CA

While driving my brakes failed. I was unable to stop my car, my brake pedal became very stiff and I could not stop my car. There were no warning signs or lights on indicating there were any issues with my car prior to this happening. I had to have my car towed to the dealer. The current estimate is for a vacuum pump failure resulting in camshaft damage. Both need to be replaced. I see other GMC cars were recalled for what appears to be a similar issue. I am lucky no one was injured as this could have very easily resulted in a fatal event. I have never heard of such a thing happening before and am beyond belief that this has occurred. This is the third repair I've had done this year. I have also replaced a booter pipe and valve gasket due to leaking oil. The amount of repairs required in such a short a time seems excessive.

Filed Nov 30, 2025 · Brakes · MI

While driving on a main road at around 45mph the vacuum pump that supplies brake fluid to the brakes failed. The car was unable to be stopped and had it not been late in the night I could have crashed into other vehicles on the road or hit someone walking. There was not indication prior to the malfunction and was very sudden. This issue has been observed by the dealer as well as multiple other individuals with the same problem for this make and model of car as well as others by the same manufacturer for similar years of manufacturing. This part has also been shown to break into the engine causing complete engine failure due to lack of a shear pin on the vacuum pump.

Filed Nov 8, 2025 · Brakes · MI

I filed a complaint with the federal safety agency on November 3, 2025, about my brake system. Here is another one adding more information. I had to have another brake system part replaced. This time it was the brake booster. Cost $1441.63 (covered by extended warranty actual cost to me $100.00.) So far, I have had the booster sensor replaced twice, the vacuum pump and now the brake booster. I asked the mechanic how many parts related to this system were left to replace? This vehicle has 66,000 miles on parts for the braking system started needed to be replaced at 37,000 miles. The total cost for parts, labor is about $500. That does not include the loss of use for this vehicle which is about 15 days. Taking days off of work about 6 days. This has been a problem for GMC Terrains since 2015; there is still a problem with 2020 model year. Please do something before there is a loss of life due to brake failure.

Filed Sep 15, 2025 · Brakes · NY

While driving my 2020 GMC Terrain (VIN: [XXX] ) with approximately 110,501 miles, I experienced a sudden and complete loss of brake assist. After about 2 hours of highway driving, I exited and the brake pedal became extremely hard to press, making it very difficult to stop. No warning lights or messages appeared before the failure. The dealer diagnosed the cause as the brake booster vacuum pipe exploding internally, which immediately eliminated vacuum to the booster. This created a serious safety hazard and nearly caused a crash. I have since had the part replaced, but the fact that this component can fail without warning at highway speed is alarming. GM has issued TSB 21-NA-107 describing this exact failure mode, which indicates it is a known issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 9, 2025 · Brakes, Engine · MN

Driving down busy highway and suddenly had no brakes!!! No lights came on dashboard as a warning. Found out it was a braking pump that broke and shot metal pieces into the engine. Now im facing a new engine for a 2020 terrain!!