2024 GMC Yukon: engine knocking or ticking

Filed Oct 13, 2026 · Engine · PA

2024 GMC Yukon, L87 6.2L V8 VIN: [XXX] This complaint concerns the L87 6.2L engine and the federal safety agency Engineering Analysis EA26005 regarding engine failure following the remedy for Recall 25V‑274. My vehicle underwent the GM recall inspection, including the Pico test, and passed the inspection. The engine was therefore not replaced. Since completion of that inspection, I have continued to obtain abnormal used-oil-analysis results showing excessive and increasing engine wear metals. At the most recent oil change, I cut open the engine oil filter and found visible metallic swarf/debris embedded in the filter media. I have retained the oil filter media and have photographs documenting the metallic debris. I also have the previous oil-analysis reports documenting the wear-metal trend. The engine has now developed a loud knocking noise. Because of the knocking noise, documented abnormal wear metals, and visible metallic debris in the oil filter, I no longer consider the vehicle safe to operate due to the possibility of sudden engine failure and loss of propulsion. The significant concern is that this vehicle passed GM's Recall 25V‑274 screening procedure but appears to be developing the same type of internal engine deterioration that the recall was intended to identify and prevent. I am requesting that the federal safety agency associate this complaint with Engineering Analysis EA26005 and review this case as a possible post-remedy failure of the Recall 25V‑274 inspection procedure. Supporting evidence available includes: • Used-oil-analysis reports showing excessive and increasing wear metals • Photographs of metallic debris/swarf in the oil filter media • Retained oil filter and filter media • Dealer repair and recall records • Mileage and oil-change records • Current loud engine knocking noise The vehicle is presently not being driven because of the potential for engine seizure or sudden loss of propulsion. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Aug 28, 2026 · Engine · TX

Driving about 75 mph car shuttered and motor quit running had to pull off of the highway and get towed to dealership. Motor had to be replaced due to 1,2,6,7 rod bearings spun on the crankshaft. 34367 miles

Filed Aug 23, 2026 · Engine · TX

The engine began knocking on startup and on acceleration. The vehicle would sometimes have difficulty accelerating. Upon taking it to the dealership, they were able to duplicate the issue. Upon inspection by the dealership, 2 rod bearings had spun and caused crankshaft damage. The manufacturer approved a full engine replacement under the warranty. There were no warnings lights, messages, or any other symptoms of the problem prior to the first incident.

Filed Jul 20, 2026 · Engine, Fuel system · NY

I am reporting a serious safety defect and unreasonable delay in addressing it under safety recall N252494000 (L87 Engine – Loss of Propulsion). My GMC Yukon has an illuminated check engine light and is now also overheating. According to GM’s own customer service r, this can lead to knocking, unusual engine noises, hesitation, high RPMs, abnormal shifting, reduced propulsion, and sudden loss of propulsion while driving, increasing the risk of a crash. I have contacted multiple dealerships for urgent repair: Cappllino GMC Keller Chevrolet Joe Basil All three have advised me that they do not have enough technicians to get my vehicle in for repair. Each has urged me to continue driving the vehicle despite the active check engine light and recall, and all have refused to provide a loaner vehicle. I have also contacted GMC Corporate directly for intervention. Instead of providing a loaner or expediting repairs, they have only offered post-repair rental reimbursement (up to $44/day after a repair order is opened). This leaves me with no safe transportation option. I have been told I can “drop off” the vehicle, but I have no alternative way to get home or to work. GMC and its dealerships are putting my safety (and the safety of other road users) at serious risk by directing me to continue operating a recalled, overheating vehicle with an active check engine light while refusing to provide any loaner or timely repair. My vehicle has 34,700 miles and is nearing the end of its warranty coverage, which raises additional concerns about potential delay tactics. Please review: The L87 engine defect and related check engine/overheating issues in GMC Yukons. GMC’s handling of this recall, including widespread failure to provide loaners and instructions to customers to keep driving defective vehicles. I authorize the release of my contact information to GMC to assist with the investigation. Attachments I can provide: Screenshots of communications with GMC

Filed Jan 19, 2026 · Engine · OR

Driving down the inter state lost power and RPM raised, oil light came on and said to shut off. We checked the oil it was fine. Got back on the road then a knocking started and the vehicle shut off. I tried to start again and it wouldn’tand hour or so later it started and was knocking bad, I turned it back off. called tow truck driver to have it towed to the dealership.

Filed Oct 1, 2025 · Engine · VA

While driving on the interstate, I felt the engine "slip". Immediately afterwards, I heard a load knocking noise from under the hood, the check engine light came on, and the vehicle lost power. I was able to pull off the interstate. Called a towing company and got the vehicle towed to a GMC dealer. The dealership diagnosed the vehicle and noted a critical issue with the engine and transmission. Dealership recommends engine replacement. Vehicle is less than a year old with 15,400 miles on the odometer. This particular vehicle is not impacted by the GMC recall on their engine, however is has the same engine failure.

Filed Jul 21, 2025 · Engine · 21,116 miles · AL

The contact owns a 2024 GMC Yukon. The contact stated while starting the vehicle, there was a loud knocking sound coming from the engine compartment. There was no warning light illuminated. The contact received notification of the federal safety agency Campaign Number: 25V274000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The vehicle was taken to the dealer but was not diagnosed or repaired. The dealer informed the contact that authorization was needed from the manufacturer to complete the inspection of the vehicle. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and a case was opened. The approximate failure mileage was 21,116. VIN tool confirms parts not available.

Filed Apr 17, 2025 · Engine · TX

On March 21, 2025 my 2024 GMC Yukon Denali's engine died while driving 80 miles an hour down the highway with my family. We were able to coast to the shoulder. The vehicle would not restart. We called a tow truck. When the tow truck arrived the vehicle started but we decided to take the vehicle to closest GMC dealer. They ran diagnostics on the lights that were showing on the dash and nothing was reported. They had no recommendations. We were 3 hours from home returning from Spring Break so we decided to keep traveling. We made it about 120 miles and again the engine died while traveling 70+ miles on the highway. We were able to safely coast to the shoulder. We called a tow truck and the Yukon was towed to the local GMC dealership. The next week it was reported to me that the Yukon would need a new engine. The 1, 3, 5 rod bearing had spun and the 3rd trust bearing had spun. Since there were no rental cars in the city available we rented a U-Haul truck and drove 2 hours home. Almost one month later we are awaiting the new engine to be delivered.

Filed Apr 8, 2025 · Engine · FL

Sent vehicle into dealership for a knocking noise turns out the lifters. They drove the vehicle 1 mile only to have the engine seize. I have been without a vehicle for 6 weeks with no engine available

Filed Apr 3, 2025 · Engine · TN

While driving down the interstate the vehicle lost power without warning and gave a command to "press start to resume" tried to do that but nothing happened. Eventually we were able to get over to the shoulder of the interstate which was super busy in Atlanta. Once we stopped, we shut off the vehicle and it started back up, and we proceeded to get back on the interstate, when the same thing happened. We stopped again, waiting a few minutes and were able to get back on the interstate and complete out trip without any issues. 3 days later while driving on the interstate again, the vehicle had a weird winding noise coming from it. Once I was able to get off the instate the engine was knocking very loudly and had no power. Got the vehicle to our home and had it towed to the dealership the next day. Dealership gave the diagnoses that a new engine, radiator and engine coolant lines needed to be replaced. The vehicle had 2,248 miles on it and was purchase 2.5 weeks prior. No eta on when we will have a new engine and our vehicle back.

Filed Mar 20, 2025 · Engine · OH

On March 3, 2025, my 2024 GMC Yukon had a rattle/knock. The engine quit running and would not restart. The Yukon had to be towed to the dealership for diagnosis and repair. The dealer indicated that the engine required replacement due to metal shavings and bearing damage. The Yukon had 6450 miles when the failure occurred. The engine was replaced. This vehicle was purchased new in September 2024. This failure occurred while on the road at a traffic light and the Yukon could not be moved out of the traffic lane. Sheriff notified to provide scene safety while waiting for tow vehicle and during loading onto tow vehicle. No traffic accident occurred. There were no warning lamps on the dash or warnings on my phone app immediately prior to the failure.