Tl*the contact owns a 2005 harley davidson buell blast motorcycle (na). While driving over 55 MPH, the main fused continued to blow and the vehicle stalled several times. The dealer could not duplicate the failures. The dealer stated that the contact could only trade in the vehicle for blue book value. The VIN was unknown. The current and failure mileages were less than 1,500.
The worst 2005 Harley-Davidson Dyna problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Electrical1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Electrical1
Recalls 2
Fuel system, gasoline: carburetor system
- What is wrong
- Certain motorcycles may have been produced with defective fuel shut-off valves. The functionality of the 'on' position and the 'reserve' position of the valve may have been reversed.
- Risk
- If the bike were operating with the valve in the 'on' position, the bike could run out of fuel, the expected fuel reserve will not be available. This could lead to the driver running out of gas without warning, increasing the risk of a crash.
- Remedy
- Dealers will inspect the fuel valve and replace it, if necessary. The recall began february 7, 2005. Owners should contact harley-davidson at 1‑414‑342‑4080.
Recall number 04V607000 · Recall details
Fuel system, gasoline: storage: tank assembly
- What is wrong
- On certain motorcycles, a condition occurs that could allow pressure to build up in the fuel tank. On fuel injected vehicles, this condition could cause fuel to spray out unexpectedly when the fuel cap is removed. On carbureted vehicles, excessive fuel could be transferred to the carburetor, which would eventually allow fuel to drip from the air cleaner.
- Risk
- These situations could cause serious personal injury or create a fire hazard for persons or property on or near the motorcycle.
- Remedy
- Dealers will test each canister for blockage, then replace as necessary. The recall began november 4, 2004. Owners should contact harley-davidson at 1‑414‑343‑4056.
Recall number 04V465000 · Recall details
What 2005 Harley-Davidson Dyna owners say
Most recent owner complaints, unedited.
Compare the 2005 Harley-Davidson Dyna
Other model years
Questions about the 2005 Harley-Davidson Dyna
Is the 2005 Harley-Davidson Dyna reliable?
Owners have filed 1 complaint about the 2005 Harley-Davidson Dyna, close to a typical Dyna model year.
What is the most common problem with the 2005 Harley-Davidson Dyna?
Electrical system, with 1 complaint.
How many recalls does the 2005 Harley-Davidson Dyna have?
2 recalls, covering fuel system, gasoline.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2005 Harley-Davidson Dyna?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history