Tl* the contact owns a 2005 harley davidson xb (n/a). The contact was driving approximately 45 MPH when the vehicle stalled without warning. The vehicle was towed to the dealer but the failure was not diagnosed. The contact later inspected the vehicle and discovered that there was a failure within the fuel pump and the wires had blown the fuses. The vehicle was not repaired. The approximate failure mileage was 10,000.
The worst 2005 Harley-Davidson XL problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Fuel system1
- Locks1
- Suspension1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Fuel system1
- Locks1
- Suspension1
Recalls 1
Fuel system, gasoline: storage: tank assembly
- What is wrong
- On certain motorcycles, a condition occurs that could allow pressure to build up in the fuel tank. On fuel injected vehicles, this condition could cause fuel to spray out unexpectedly when the fuel cap is removed. On carbureted vehicles, excessive fuel could be transferred to the carburetor, which would eventually allow fuel to drip from the air cleaner.
- Risk
- These situations could cause serious personal injury or create a fire hazard for persons or property on or near the motorcycle.
- Remedy
- Dealers will test each canister for blockage, then replace as necessary. The recall began november 4, 2004. Owners should contact harley-davidson at 1‑414‑343‑4056.
Recall number 04V465000 · Recall details
What 2005 Harley-Davidson XL owners say
Most recent owner complaints, unedited.
I recently purchased a motorcycle trailer from kendon industries, 3711 e. La palma ave, anaheim, ca 92806. The trailer was specifically designed for a long bike (chopper style). The first time I used the trailer, I was traveling on the freeway and noticed that the tie downs for the bike and come loose and the bike very nearly came loose from the trailer into heavy freeway traffic. Kendon trailers have a front wheel mounting unit that operates in a way that as you move the motorcycle forward into the mounting unit the mounting unit rocks forward secuting the front wheel against the front of the trailer. The trailer also has four tie down points (two at the front and two at the rear). The major problem with the trailer is the fact that the front tie down points are behind the stearing head of the motorcycle. As a result, when the trailer hits a bump, the action of the trailer is to pull the bike backwards (away from the front securing unit). This is what happened to me. While traveling on the freeway I must have hit a bumb which caused the motorcycle to pull out of the front unit. This also increased the slack in the tie downs which allowed the bike to flop from side to side and almost caused the bike to exit the trailer (which has no sides or rear security).
Dt: 2005 harley davidson wide glide. The front forks were so weak that they sagged when the consumer was not braking. The consumer stated the springs were too weak in the forks. The consumer found other complaints about the same problem. He tried to get the after market springs, but they were on back order. The consumer noticed this a week agoon september 29, 2005. *ak updated 03/09/06
Compare the 2005 Harley-Davidson XL
Other model years
Questions about the 2005 Harley-Davidson XL
Is the 2005 Harley-Davidson XL reliable?
Owners have filed 3 complaints about the 2005 Harley-Davidson XL, close to a typical XL model year.
What is the most common problem with the 2005 Harley-Davidson XL?
Fuel and propulsion system, with 1 complaint. Next is locks (1).
How many recalls does the 2005 Harley-Davidson XL have?
1 recall, covering fuel system, gasoline.
Was there a recall on the 2005 Harley-Davidson XL fuel system?
Yes, 1 recall: 04V465000. Check your VIN to see if your car still needs the free repair.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2005 Harley-Davidson XL?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history