2020 Honda Odyssey: engine knocking or ticking

Filed Sep 22, 2026 · Engine · 50,000 miles · TX

The contact owns a 2020 Honda Odyssey. The contact stated that while driving 45 MPH, the contact heard a knocking sound coming from the engine, and the vehicle went into LIMP Mode with the low oil warning light illuminated. The contact became aware of a burning odor coming from under the hood, and the vehicle needed to be towed. The vehicle was towed to the dealer, where it was diagnosed and determined that the connecting rod bearings had failed and the engine needed to be replaced. The vehicle was not repaired. The failure mileage was approximately 50,000.

Filed Sep 15, 2026 · Fuel system · FL

On September 14, 2026, my 2020 Honda Odyssey experienced a sudden, severe low-pressure fuel pump failure while idling/parked. The engine began running extremely rough, surging repeatedly between 300 RPM and 1,000 RPM, knocking, and stalling. I was parked at the time, preventing a severe accident. Upon trying to restart, the vehicle turned over multiple times and would only catch when depressing the accelerator pedal, accompanied by cylinder knocking and an engine thermal spike. The vehicle was towed to an independent repair facility (Tuffy Auto Service). The diagnostic scan confirmed DTC P0087 (Fuel Rail/System Pressure - Too Low). A mechanical gauge test showed the low-side fuel pressure dropped to 10 PSI (far below the standard operating pressure of 50–60 PSI). The shop verified that the in-tank low-pressure fuel pump assembly failed internally and requires complete replacement. This failure, symptom pattern, diagnostic code (P0087), and component match the exact defect profile in the federal safety agency Recall 23V‑858 (Denso Low-Pressure Fuel Pump Impeller Failure). However, when checking my VIN, American Honda claims this specific vehicle is excluded from the recall range. American Honda Consumer Relations subsequently refused goodwill assistance due to non-dealer service history and vehicle resale status. This creates a severe safety hazard. A vehicle experiencing a sudden drop to 10 PSI fuel pressure while driving in traffic will lose motive power, stall unexpectedly, and disable power steering and braking assist. I am submitting this report because American Honda has failed to include all affected production batches in Recall 23V‑858. I request the federal safety agency expand Recall 23V‑858 to include out-of-range 2020 Honda Odyssey VINs exhibiting identical low-side fuel pump failures.

Filed Aug 3, 2026 · Engine · MD

Vehicle: 2020 Honda Odyssey VIN: [XXX] Mileage at time of failure: 155413 Component: Engine — Connecting Rod BearingsDescription: My 2020 Honda Odyssey experienced a failure of the connecting rod bearings on 7/30/26, resulting in loud knocking noise. The failure was diagnosed by Luis Asturias at Jim Coleman Honda in Clarksville, MD. This vehicle falls within the scope of the federal safety agency's open Preliminary Evaluation PE25008, which covers 2018-2020 Honda Odyssey vehicles with the 3.5L J35 V6 engine for this exact failure mode. My dealer declined to cover the repair cost under warranty because no recall has yet been issued. I am filing this complaint to document my experience as part of the ongoing federal investigation. Repair cost estimate: $4573.00. The vehicle is not driveable without this repair.Thank you for your prompt attention,[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 30, 2026 · Engine · 85,000 miles · CA

The contact owns a 2020 Honda Odyssey. The contact stated that the vehicle made an abnormal ticking sound while depressing the accelerator pedal, and the engine made a loud sound. There was no warning light illuminated. Upon investigation, the contact related the failure to the federal safety agency Action Number: PE25008 (Engine). The vehicle was taken to the local dealer, where it was diagnosed and there were metal shavings found in the engine oil. The dealer determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and confirmed that there was no recall or warranty coverage for the repair. The failure mileage was approximately 85,000.

Filed Nov 21, 2025 · Engine · VA

My wife started hearing a knocking sound while driving, coming from under the hood. I opened the hood while the engine was idling and could tell the sound was coming from inside the engine. Checked the oil level and it was in the operating range and looked clean. I had just changed the oil and filter 08/2025. After that we immediately drove it to the Honda dealer where we purchased the vehicle and the service manager heard the noise, checked for recalls, but could only find the recall for the 2019 Honda Odyssey [XXX] The service manager called in one of his mechanics to listen to the noise in the service manager bay and he said, "Sounds like a bad rod bearing". They then took the vehicle to inspect it further in the mechanic's garage, but as they were pulling it into the bay the engine complete seized up. The vehicle only has 68k miles on it, but now its beyond the warranty period. I was also told by the dealer when I purchased it, that it and the 2019 are identical, so why was the recall issued for the 2019 Odyssey, but not the 2020 model? I'm reading lots of similar reports of this same exact issue with the 2020 model from Honda forums and on youtube posts. This engine problem is clearly larger than the initial recall that was issued in 2024. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Nov 10, 2025 · Engine · FL

Connecting rod bearing failure at 105,000 miles, even with full recommended and documented service history.

Filed Sep 23, 2025 · Engine · 130,000 miles · TX

The contact owns a 2020 Honda Odyssey. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to coast to the shoulder of the roadway, where the vehicle failed to restart. No warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the connecting rod bearings, resulting in damages to the engine, causing the engine to seize. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to the federal safety agency Campaign Number: 23V751000 (Engine and Engine Cooling), but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 130,000.

Filed Jan 7, 2025 · Driver assistance, Engine · OH

Several engine failures, starting one month after purchase in September 2020. multiple system failures (all on video) leading to very poor acceleration and operation. No compression in engine and only able to go 20 mph. White-Allen Honda made four attempts to solve the matter over the course of two years. The dealer has had the car a total of 120 days. Then end of December 2024 then engine began making a knocking sound and I was told it needed at new engine, to the tune of $10,000.00. Then I see a recall for a similar issue but only up to 2019 Odysseys. Please help find resolution for this.

Filed Nov 13, 2024 · Engine · 3,000 miles · PA

The contact owns a 2020 Honda Odyssey. The contact stated that there was an abnormal knocking sound coming from the engine. The vehicle was taken to a local dealer where it was diagnosed. The contact was informed that the knocking sound coming from the engine became louder to take the vehicle back for inspection. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 3,000.

Filed Jan 16, 2024 · Engine, Transmission · MD

 I have a concerning noise from my car's engine that I’ve already brought in for diagnosis. Knocking/ticking/rattling noise on stand-still acceleration at relatively low speeds/under light load. Does not duplicate when revving in park, only under light load. Sound present with HVAC on or off. Does not make noise when cold or after long trips. Honda seems to be aware of this issue and has remedied it through work involving the crankshaft bearings and possibly other components as it relates to their service bulletin 23-097. The problem is that my vehicle falls outside of the stated range of production years as mine is a 2020 model year, but the likelihood seems quite high that the engine in my vehicle is suffering from this exact problem. The service department refuses to help me and the corporate line I've contacted through email me simply refers me to the service department. I just spent $38,000 on this vehicle with 30,000 miles and I have no other recourse at this point to remedy this.