The contact owns a 2016 Honda Pilot. The contact stated that while his wife was driving approximately 60 MPH, the vehicle violently shook, vibrated, decelerated, and stalled. The vehicle was later restarted and driven to the local Auto Zone to be diagnosed. The diagnostic test revealed failures with the ECM and ECU, and the camshaft sensor failure. The vehicle was not repaired. The local dealer was notified of the failure, but no assistance was offered. The manufacturer was not yet notified of the failure. The failure mileage was 109,000.
2016 Honda Pilot engine complaints
Page 8 of 29: complaints 191 to 220 of 828, newest first, as owners wrote them.
The vehicle has started displaying numerous codes/error messages on the display. Vehicle jerks while attempting to accelerate and loses power. Dealership diagnosed the problem as a camshaft, stating the camshaft, timing belt, camshaft thrust cover, and spark plugs would all need to be replaced. They also said this may have caused damage to the converter, which will not be known until other repairs are made. This is apparently a common and widespread issue with these Hondas despite no recall being issued.
The engine on my 2016 Honda Pilot needs to be replaced. It started to have a rattle, and my local mechanic diagnosed it as an issue with the connecting rod bearing. Honda issued a recall for this type of failure mode for Honda Pilots built in May and June of 2016, but mine was built in September of 2016. Honda says the recall does not cover my vehicle, even though the failure mode is similar. I performed all standard maintenance on this vehicle, yet it failed well short of its expected life.
The contact owns a 2016 Honda Pilot. The contact stated while driving 65 MPH, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. There was an abnormal knocking sound coming from the vehicle with the check engine warning light illuminated. The vehicle was driven to a nearby parking lot. The vehicle was then towed to the dealer and was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact referenced an unknown recall; however, the VIN was not under recall. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was unknown. The VIN was not available.
The contact owns a 2016 Honda Pilot. The contact stated while driving 68 MPH on the interstate, the vehicle unexpectedly decelerated. There was an abnormal odor detected. The contact was able to take the exit ramp. The engine light illuminated, and the vehicle became inoperable. The contact stated that the failure was related to the federal safety agency Action Number: RQ24013 (Engine). The vehicle was towed to the residence. The vehicle was then towed to the local dealer, where it was jumpstarted, and the contact was informed about an engine replacement. The vehicle was diagnosed with a split crank shaft. The vehicle was not repaired. The manufacturer was contacted and confirmed that no additional assistance would be provided. The manufacturer was no longer returning phone calls. The failure mileage was approximately 237,000.
The contact owns a 2016 Honda Pilot. The contact stated that while at a complete stop in a drive thru, the vehicle started shuddering and stalled. Several unknown warning lights were illuminated. The contact stated that the vehicle was able to restart 40 minutes later after several attempts; however, the failure recurred. The vehicle was towed to an independent mechanic, where it was diagnosed that the engine had failed and needed to be replaced. The vehicle was not repaired. The contact stated that while driving to the residence at 55 MPH, the failure recurred. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 159,440.
I am writing to formally report a serious and dangerous mechanical failure that occurred while I was driving my 2016 Honda Pilot, which was later diagnosed by a certified Bell Honda dealership as a rod bearing failure. On July 25 2025, I was driving on the freeway at approximately 65 mph when, without warning, the vehicle began to shake violently, and I lost power and control of the car. The engine began making a loud knocking sound, and the vehicle decelerated rapidly, creating a hazardous situation in the middle of high-speed traffic. I narrowly avoided a collision while attempting to safely maneuver the car to the shoulder of the road. After the vehicle was towed to my home and to Bell Honda Dealership when they open, their inspection confirmed that the engine had suffered a rod bearing failure, which ultimately led to catastrophic engine damage. I was informed that the entire engine would need to be replaced at significant cost. This vehicle has been regularly maintained, including a recent [60K/other] mile service. It has never missed scheduled maintenance, and I have always followed Honda’s service recommendations. Despite this, I was told my VIN is not included in any current recall, even though this type of failure is a well-documented issue for 2016 Honda Pilots and is currently under the federal safety agency investigation. Honda of America has since denied my goodwill repair request, citing the age of the vehicle — despite the clear evidence that this was not due to owner neglect, but due to a manufacturing defect that poses a major safety risk. I am requesting that this incident be reviewed carefully, as it represents not just a financial burden, but a life-threatening mechanical failure. I am pursuing further action, including reporting this to the federal safety agency, filing through BBB Auto Line, and seeking legal counsel if necessary. Please contact me if you need additional documentation, including the dealership’s diagnosis, repair estimates, maintenance records.
The fuel injection system routinely fails or misfires. Not only does this cause an issue with said system but it also triggers a host of other dashboard alerts. The alerts display all wheel drive problem, emission system problem, power steering problem, hill start problem, vehicle stability assist problem. This is a safety issue because the amount of alerts especially unrelated alerts is obfuscating any actual problems and making it difficult to diagnose the real issue. Investigation shows many other drivers having the same issues with this model only going away when the fuel injection system is replaced. It's also safety issue because if the fuel injection is failing then the car may shut off at a danger to the driver and the public. Given that it is known and chronic it should be a recall
For the past three years or more the car does randomly turns of the engine often at a red light stop and sometimes requires multiple push on the start button to start the motor running. we have complained to the local Honda dealer of this issue several times through the years. they run all the tests needed and that the car has no problem. the can has been unreliable to drive in fact it is scary to drive.
Engine seized, mechanic mentioned potential connecting rod bearing failure. Was on freeway when car started to malfunction. Car was immediately taken to trusted mechanic and issue was found. Towed to additional mechanic following that. Honda dealership/service center was called regarding recalls on other 2016 Honda pilots engine seizures and no response yet, want to have car inspected by them if possible.
In my 2016 Honda pilot a lot of buttons are popping up on the screen with no information about how to fix it. My car is having trouble accelerating and is hesitating when needing to accelerate. I was unable to speed up while driving to get to 45 mph Because it would not speed up. All the buttons that are coming up on my car or not correct it’s showing trailer issues and I’ve never once trailed anything with my car. It seems like it’s having extra trouble when the air condition is on as well. I’m unable to figure out what is wrong with my car because all the buttons are not coming up correct when they plug it in for a diagnostic. I have had the alternator replaced and that did not change anything.
2016 Honda Pilot was taken to Utah Moto Shop for routine maintenance and to diagnose engine noise after Honda replaced fuel injectors Nov 2024. Noise started right after injectors were replaced but customer was told that noise was normal. Utah Moto Shop found rod knock and diagnosed issues with connecting rod bearings. The shop contacted Honda in regards to the federal safety agency Campaign Number: 23V751000 and the related connecting rod bearing recall by Honda. Utah Moto Shop was told the VIN did not qualify. The vehicle has been deemed unsafe to drive due to the likelihood of engine failure at any time. The vehicle remains unrepaired and undriveable at 147,996 Miles.
The contact owns a 2016 Honda Pilot. The contact stated while driving 50 MPH, there was an abnormal rattling and vibration in the engine. There were no warning lights illuminated. The contact stated that the failure was related to the federal safety agency Action Number: RQ24013. The contact stated that the failure was like the failure documented in the federal safety agency Campaign Number: 23V751000 (Engine and Engine Cooling). The vehicle was taken to the local dealer, where it was diagnosed that there was scorching on rod bearing 1,2,3,4, and 6 rod bearings were damaged, and the crankshaft was damaged. The mechanic recommended that the engine be replaced. The vehicle was not repaired. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 150,000.
While traveling at highway speed a rod knock suddenly developed inside the engine. Engine lost power which could have led to crash or injury. Had vehicle towed to the nearest Honda dealer (Fox Honda in Grand Rapids, MI) and they reported broken pieces internal to the engine coming out when draining the oil. There is an existing Honda service bulletin 24-001 that covers this issue on some 2016 Pilots but we were told by the dealer that our VIN does not fall within the range. I have seen reports online of other owners of 2016 Pilots being affected by this and being told the same thing.
Car had a low oil light and started a knocking noise on 6/6. Stopped vehicle and had it towed to dealership on 6/7 report came back with a connecting rod problem. No further inspection after that. Was made aware that there is a current recall on my vehicle specs but not my specific vin number.
Honda Technician upon inspection found code p0175 fuel system too rich, preformed af test found bank 2 failed on all injectors, injectors need to be replaced. But the honda dealer is NOT willing to replace the fuel injector based on "SERVICE BULLETIN 20-100, & 20-11 Warranty Extension". The service bulletin ask for replacement of the fuel injectors and/or a software update.
In many instances (perhaps 30 in the five years) while driving on the highway I will depress the accelerator to pass a vehicle but instead of accelerating the engine revs drop and the speedometer goes blank. This is very dangerous as you are expecting to accelerate - especially when changing lanes to pass someone - but instead of accelerating the car starts to slow down for a few seconds and then, after the revs drop, they pick up again. I have a video of this but I can't upload it below. Please let me know where to send it. The first time I brought it to a Honda dealer they said they had to remap the "software". The second time they had no idea why it was happening or how to fix it. I would like to get this fixed but am flummoxed.
The contact owns a 2016 Honda Pilot. The contact stated that while his wife was driving 70 MPH, the vehicle stalled. The check engine warning light and the low oil pressure warning light were illuminated. The contact's wife pulled over to the side of the road. The vehicle was able to restart. The vehicle was then towed to Dennis Automotive Care, where it was diagnosed and determined that the engine had seized and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not under recall or warranty coverage. The manufacturer referred the contact to a dealer for additional diagnostic testing. The dealer was not contacted. The contact related the failure to the federal safety agency Action Number: RQ24013 (Engine). The failure mileage was approximately 134,000.
UPON INSPECTION FOUND KNOCKING NOISE FROM LOW END ROD KNOCK. INTERNAL FAILURE OF ROD CAUSING NOISE FROM SPUN BEARING- Honda told me that the VIN was not included in the previous recall despite being manufactured in the same month and year of the recall causing me to pay out of pocket to replace the short block of the engine at 85,000 miles
Engine seems to have failed. Having it towed to get a final diagnosis but it seems seized/blown.
According to the Honda dealership of Winchester, West Virginia, an engine rod came through back of block and into oil plan, causing oil to leak on exhaust, which then caused the car to catch on fire. My daughter was driving and her safety was at risk. There were no warning signs about this prior to the incident. We had just driven the car from Nashville to West Virginia with no problems. I was told that there was a recall for this for 2016 Honda Pilots, but that my VIN was not included. This has cost me $215.31 in car rental fees, $169.38 in Uber fees, $1661.35 in auto transport and towing fees, $165.99 inspection from Honda. I'm still waiting on final costs for a new engine; I was quoted $12K from Honda; trying to find a cheaper alternative.
I was driving in the interstate today. Car started knocking really hard and shuts off. Dealership replaced fuel injectors. 2 weeks later car started knocking. Dealership said I need a new engine as they found metal shavings in the oil.
The engine failed/died while being driven on the highway by my son, nearly causing a life threatening accident. I brought the car to our trusted Honda mechanic (certified mechanics specializing in Hondas/Acuras) and was told the problem was a rod bearing issue, there was a recall (23V‑751) and to take the vehicle to a dealership. I paid to have the car towed to Honda of Annapolis and was told the engine failed because of rod bearing issue and that my VIN was not included in the recall. I requested the dealer provide a goodwill repair as the engine failed to the same reason listed in the recall and was denied. I filed a complaint with corporate (claim 15247280) which was denied because my VIN was not included in the original recall of only 249k vehicles. I then paid for it to be towed back to my home. It remains unsafe and inoperable.
While driving vehicle lost power and started smoking; and would not restart. Towed to honda, they stated engine siezed and connecting rod was protruding out of the side of engine. Took to another shop and they confirmed rod bearings failed and caused connecting rod to break causing it to go through the engine. When attempted to restart car check engine light was on. Heads to the engine were good. Had to replace engine at 157k with all service being done at honda on time or early with all maintenance being done on time. Vehicle lost power on highway in far left lane, very dangerous.
I was on my way to work and was in a neighborhood going 25 mph and came to a stop. My engine cut off and would not restart. I bought the car with somewhere around 120,000 miles in 2021.. it is the end of May 2015 and the car has a little less than 152,000 on it. I kept up with required oil changes and I have been told that the engine is siezed. As well as the torque converter being stuck... sounds like the SAME ISSUES listed in the recall
Check engine light on emissions system problem and transmission system problem, there is loss power of engine light, after 2 gear transmission feel like it jerks I don't have save to drive my car, i would like to request a recall to be inspected and repair by warranty of Honda because my car is defective by manufacturer Code are: P0420 (rear bank catalyst system efficiency below threshold [bank 1]) P0430 (front bank catalyst system efficiency below threshold [bank 2]) P0300-P0306 (misfire) P219A (air-fuel ratio variation of cylinder [bank 1, rear bank]) P219B (air-fuel ratio variation of cylinder [bank 2, front bank])
I had just left my house and, approximately five minutes or 1.2 miles into my drive, the engine suddenly stopped in the middle of the road, leaving me stranded and in a dangerous situation. I had the vehicle towed to a Honda dealership, where I was informed that the engine had failed. However, I was given no explanation as to why this happened—only the option to replace the engine at my own expense.
the federal safety agency 1200 New Jersey Avenue, SE Washington, D.C. 20590 Subject: Report of Engine Stalling and Rattling Noise in 2016 Honda Pilot (VIN: [XXX] ) I am writing to formally report an issue with my 2016 Honda Pilot that appears to be similar to the problem described in Honda's recall 23V‑751, but my vehicle is not included in the recall. Vehicle Information: - Year: 2016 - Make: Honda - Model: Pilot - VIN: [XXX] Incident Description: On the night of [XXX], at approximately [XXX], while traveling on a side road, my vehicle experienced a sudden engine stall accompanied by a loud rattling noise. With little power and momentum, I was able to pull into a gas station. Fortunately, no injuries were sustained during this incident. Service History: The vehicle was towed to Gunn Honda in San Antonio, TX. No repairs have been made to date. Owner Contact Information: - Name: [XXX] - Address: [XXX] - Phone: [XXX] Given the similarity of this issue to the one described in recall 23V‑751, I am concerned that my vehicle may have the same defect. I request that the federal safety agency investigate this matter and consider including my vehicle in the recall to ensure that it is repaired promptly and safely. Thank you for your attention to this important safety concern. I look forward to your response. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
1. The engine system failed, specifically due to a connecting rod bearing failure caused by improper machining of the crankshaft journals. This led to internal metal-on-metal contact and abnormal wear. The engine is still installed in the vehicle and is available for inspection upon request. 2. The engine failure caused jerking during acceleration, hesitation, and intermittent stalling, particularly when attempting to merge onto highways or accelerate from a stop. This significantly increased the risk of losing power while driving, which could have led to rear-end collisions or sudden stalls in traffic, putting both my safety and the safety of others at risk. 3. Yes. The problem was initially identified by an independent, authorized mechanical shop, which suggested that the failure resembled a known engine-related recall affecting other Honda Pilots. The issue was then formally confirmed by a certified Honda dealership (Honda Superstore of Lisle) on April 19, 2025, which diagnosed connecting rod bearing failure and recommended a full engine replacement. 4. Yes. An authorized third-party mechanical shop, which initially suspected the issue was linked to a known Honda recall. A certified Honda dealership, which confirmed the diagnosis and recommended engine replacement. The vehicle has not been inspected by police or insurance representatives. 5. There were no warning lamps or dashboard messages. However, physical symptoms began appearing around April 1, 2025, and included: Loud ticking and knocking noises on engine startup. Jerking and hesitation during acceleration. Occasional stalling and reduced power while driving. These symptoms worsened over time, prompting me to stop driving the vehicle due to safety concerns.
December 2017 I was driving my 2016 Honda pilot back from Florida and the car immediately reduce speed to about 25 to 35 mph. I had my OBD2 in the car so I reset the code and the car start driving fine and every time I will leave the gas station it will do the same thing dealership took the car said it was a throttle position sensor fixed it and the car broke down two days after getting it. I was told it was corrected for sure this time. However I'm saying a recall on Honda engines 2016 but my engine is not included. In 2024 I took the vehicle in for service and they said there was a recall for the ignition switch however since they fixed the ignition switch I have issues at times starting the car. I've also had to pay to get the electronic steering fixed.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Honda Pilot?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history