2018 Honda Pilot: engine stalls while driving

Filed Aug 29, 2026 · Fuel system · FL

High Pressure Fuel Pump fails after implementing recall listed below. See recall information: December 18, 2023 the federal safety agency CAMPAIGN NUMBER: 23V858000 Fuel Pump May Fail Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash. the federal safety agency ID Number: 23V858000 Manufacturer Honda (American Honda Motor Co.) Components FUEL SYSTEM, GASOLINE Potential Number of Units Affected: 2490460

Filed Jun 26, 2026 · Engine · AL

Engine failure , has been confirmed by a shop. It is available for inspection upon request. No previous problems or warning lights. Stalled and put myself and my children at risk of serious injury.

Filed Mar 25, 2026 · Fuel system · 82,000 miles · AZ

The contact owns a 2018 Honda Pilot. The contact stated that while driving 80 MPH, the vehicle decelerated and stalled while depressing the accelerator pedal. Several unknown warning lights were illuminated. Neither an independent mechanic nor a dealer was contacted. The contact was able to pull over to the right side of the road, depressed the brake pedal, and turned off and restarted the vehicle after several seconds, and the vehicle operated as intended. A dealer was contacted. The vehicle was not taken to a dealer or an independent mechanic. The vehicle was not repaired. The contact associated the failure with the federal safety agency Campaign Number: 23V858000 (FUEL SYSTEM, GASOLINE); however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was 82,000.

Filed Mar 16, 2026 · Fuel system · MA

What component or system failed or malfunctioned, and is it available for inspection upon request? The vehicle’s high-pressure fuel pump failed approximately one year after the low-pressure fuel pump was replaced under a manufacturer recall. The low-pressure pump had been identified as defective and replaced accordingly. Because the low-pressure pump is responsible for supplying fuel to the high-pressure pump, it is reasonable to believe the defective component may have placed abnormal stress on the high-pressure fuel pump prior to its replacement, potentially leading to premature failure. The failed high-pressure fuel pump is still in the vehicle. How was your safety or the safety of others put at risk? Failure of the high-pressure fuel pump can result in a sudden loss of fuel pressure to the engine, causing hesitation, loss of power, or engine stalling while the vehicle is in operation. This created a significant safety hazard, particularly as it occurred during highway driving, where sudden loss of propulsion occurred. Has the problem been reproduced or confirmed by a dealer or independent service center? The issue was diagnosed and confirmed by a service center as a failed high-pressure fuel pump. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle was inspected by my personal mechanic who indicated fuel pump issues and noted recall then a Honda dealer during diagnosis but recall was for previously replaced low pressure pump and not the High pressure pump the issue has yet to be repaired. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Prior to the failure, the vehicle began experiencing noticeable fuel system performance issues, including reduced engine performance loss of MPG and drivability concerns. No lamps

Filed Mar 4, 2026 · Acceleration, Electrical · 102,000 miles · MI

The contact owns a 2018 Honda Pilot. The contact stated while driving 35 MPH, several unknown warning lights illuminated. The vehicle failed to accelerate, and the RPM became elevated. The vehicle lost motive power and stalled. The vehicle was towed to the local dealer, where a partial diagnosis was performed, and it was determined that there was a catastrophic failure in cylinder #3. The dealer informed the contact that the failure was associated with the federal safety agency Campaign Number: 23V751000 (Engine and Engine Cooling). The vehicle was not repaired. The manufacturer was contacted, a case was opened, but no additional assistance was provided. The failure mileage was approximately 102,000.

Filed Oct 15, 2025 · Engine · 180,000 miles · WI

The contact owns a 2018 Honda Pilot. The contact stated that when the vehicle was cold-started, there was an abnormal knocking sound coming from the engine compartment. The knocking sound was constant. The contact stated that the vehicle nearly stalled recently, and the check engine warning light was flashing. The vehicle was no longer able to accelerate above 35 MPH. The contact had taken the vehicle to an independent mechanic, who diagnosed that the connecting rods needed to be replaced, and the engine was inspected for internal damage. The contact stated that the independent mechanic checked the oil and observed that the oil was black and the oil level was low. The contact recently had an oil change prior to taking the vehicle to the independent mechanic. The vehicle was not repaired. The contact researched online and related the failure to the federal safety agency Campaign Number: 23V751000 (Engine and Engine Cooling). The contact called a local dealer and was informed that the VIN was not included in the recall. The manufacturer was not informed of the failure. The failure mileage was approximately 180,000.

Filed Sep 12, 2025 · Fuel system · CA

My Honda Pilot 2018 is a modified vehicle with wheelchair ramp. It is in the recall list for Honda. Recall: swelling of fuel pump motor impeller, fuel pump may seize/stop working. Defective impeller may cause fuel pump inoperative, which could prevent engine from functioning. May cause a loss of motive power/stall while driving, increasing risk of crash or injury creating a safety hazard. -Replace the fuel pump motor. I contact the Honda dealer in San Jose, CA, but they were unable to perform Fuel Pump replacement due vehicle being modified. Tell me to find a dealer that specialize in accessible vehicle to removed cover on floor to access fuel pump then bring fuel pump to Honda for them to replace. DMV requires to perform recall to renew vehicle registration. I do not know which dealer I need to perform this recall.

Filed Jan 1, 2025 · Electrical, Transmission · CA

There is an auto start/stop feature on my 2018 Honda Pilot. I’ve owned it new since July 2018. My wife and I have experienced the same issue both together and separately. The auto stop feature will engage with the break depressed, but the auto start function will not always engage when the break is released. This has left us stranded in the middle of intersections in the middle of left turns with oncoming traffic driving around us, stalled on the freeway with cars whizzing by us at 70+ MPH blocking the fast lane, blocking congested one lane roads with no recourse for drivers behinds to get around us, etc. This feature stops the engine but periodically does not allow it to turn back on. With the engine stopped by this feature, but not shifted to park/ neutral, pressing the ignition start/ stop button does nothing. Shifting to park, and pressing the ignition start/stop button significantly delays removing the road hazard now created by the vehicle’s now dangerous location. To further complicate the matter, the engine starting has, on many occasions, taken multiple minutes to start, endangering myself, my wife, my four children, and other family / friends on too many occasions to count. My local dealership recommended replacing the vehicles battery, even though I had no other battery related problems. I did, in fact, follow that recommendation, only to have the same problem persist. I have encouraged my wife to disengage this feature proceeding forward, but the feature automatically resets itself everyone the ignition is started. This becomes problematic if the feature is forgotten to be turned off or, due to placement of the features button, the feature is inadvertently re-engaged.

Filed Dec 16, 2024 · Engine, Fuel system · 58,000 miles · NC

The contact owns a 2018 Honda Pilot. The contact received notification of the federal safety agency Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the vehicle was experiencing engine hesitation while driving at various speeds. The vehicle was taken to the dealer, where the transmission fluid and the coolant were flushed. The contact was charged a service fee; however, the failure recurred while driving. The contact stated while driving 65 MPH on the third lane of an interstate with her children in the car seats in the rear seats, the vehicle made an abnormal clunking sound. The vehicle decelerated to 35 MPH abruptly, causing the driver's and passengers' seat belts to retract. The contact immediately depressed the accelerator pedal, but the vehicle failed to exceed 40 MPH, nearly causing a crash. The contact activated the hazard lights and drove to her husband's shop. The contact's husband cleared the diagnostic trouble codes, and the vehicle accelerated as needed while driving; however, the vehicle shuddered, made abnormal sounds, the engine had a misfire, and the vehicle stalled while driving. The check engine warning light was illuminated, and the message "Emission System Problem" was displayed. The local dealer was contacted, and the contact was in the process of taking the vehicle to the dealer. The vehicle was not yet diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the failure. The failure mileage was approximately 58,000. Parts distribution disconnect.

Filed Dec 3, 2024 · Fuel system · 55,000 miles · FL

The contact owns a 2018 Honda Pilot. The contact received notification of the federal safety agency Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that while the vehicle was parked, the vehicle stalled. No warning light was illuminated. The failure occurred on several occasions. The vehicle was taken back to the residence. A dealer was contacted; however, the vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 55,000. Parts distribution disconnect.

Filed Nov 28, 2024 · PA

My auto idle start/stop has been causing my engine to stall out when I come to a complete stop. I believe it started about a little more than a year ago. It doesn’t happen all the time and never happens when I remember to turn it off. I had it at the dealership multiple times mentioning about this problem and was dismissed every time. They told me they found nothing wrong and all codes were fine and nothing was popping up. Finally, someone tested my battery and found it wasn’t operating fully. I replaced the battery after be reassured this should fix the problem. It was fine for less than a year, maybe 6 months and then it started happening again back in mid/late July. This is a major safety concern and after reading online that many others are experiencing the same issue is causing me an even greater concern.

Filed Nov 5, 2024 · Fuel system · 87,000 miles · VA

The contact owns a 2018 Honda Pilot. The contact received notification of the federal safety agency Campaign Number: 23V858000(Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated while driving at an undisclosed speed, the vehicle made an abnormal ticking sound and stalled. There was no warning light illuminated. The vehicle was able to restart; however, the failure recurred. An unknown dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 87,000. Parts distribution disconnect.