2016 Honda Pilot: engine stalls while driving

Filed Oct 22, 2026 · Engine · CA

The engine has developed a severe internal engine knocking/rattling noise while running. This symptom matches the defective crankshaft and connecting rod bearing failures detailed under the federal safety agency Campaign 23V751000, presenting a severe risk of sudden stalling and complete engine failure under load.

Filed Oct 22, 2026 · Engine · MN

I am writing to report a severe internal engine defect on my 2016 Honda Pilot that poses a sudden stalling and safety hazard, identical to the failures covered under the federal safety agency Recall Campaign Number 23V‑751. My vehicle is currently experiencing a distinct metallic rattling/knocking noise coming from the lower engine block. This noise is highly noticeable under acceleration and high-load conditions right before the transmission shifts gears at higher RPMs. Upon performing an inspection of the engine oil system, the drained engine oil revealed a heavy concentration of microscopic metallic "glitter" and shimmering copper/silver shavings suspended in the fluid. This confirms acute, active connecting rod bearing degradation and crankshaft journal wear. Despite displaying the exact textbook symptoms, failures, and manufacturing characteristics of the defect outlined in Recall 23V‑751 (improperly ground crankshaft journals from the factory), my specific VIN is currently excluded from the recall scope. I am submitting this complaint to formally document that my vehicle is a clear positive match for this manufacturing defect. I request that my VIN be added to the active recall scope or included in the federal safety agency’s ongoing investigation regarding Honda’s under-inclusive recall volume, as this failure introduces an immediate risk of catastrophic engine seizure and sudden loss of motive power at highway speeds.

Filed Oct 4, 2026 · Fuel system · KY

We have a 2016 Honda pilot. The front fuel rail assembly which included the fuel rail pressure sensor & the high pressure fuel pump had to be replaced in our vehicle and it is currently going to the mechanic shop for the low pressure pump to now be replaced as well. There have been multiple complaints regarding the fuel pump on 2016 Honda pilot and while there was a recall for the pressure one, our VIN wasn’t not on that list. This issue started somewhere between 165-170k miles. This causes sputtering when starting and stalling.

Filed Sep 25, 2026 · Fuel system · 251,000 miles · TX

The contact owns a 2016 Honda Pilot. While driving at an undisclosed speed, the vehicle stalled with several unknown warning lights illuminated. The vehicle was able to continue driving but at a reduced power. The contact stated that the failure had occurred while the fuel level was near half a tank. However, after refueling the vehicle, the failure was corrected. The vehicle was taken to an independent mechanic, who associated the failure with the federal safety agency Campaign Number: 23V858000 (Fuel System, Gasoline); however, the VIN was not included in the recall. The manufacturer was notified of the issue by phone. The failure mileage was approximately 251,000.

Filed Sep 3, 2026 · Fuel system · 100,901 miles · TX

The contact owns a 2016 Honda Pilot. The contact stated that while driving 20 MPH, the vehicle stalled with the check engine and ABS warning lights illuminated on the instrument panel. The vehicle was taken to an independent mechanic and an OBDII scan retrieved DTC: P0087 (Fuel Rail/System Pressure - Too Low) and U0401-68 (Engine Control Module). The vehicle was then taken to a dealer, and it was confirmed that the low and high-pressure fuel pumps needed to be replaced. The contact stated that the VIN was not included the federal safety agency Campaign Number: 23V858000 (Fuel System, Gasoline). The manufacturer was notified of the failure, and the contact was informed of Technical Service Bulletin: 24-010, which might cover the repair of the vehicle. The contact was later informed that the vehicle was not covered under the TSB. The vehicle was repaired out-of-pocket. The failure mileage was 100,901.

Filed Aug 23, 2026 · Engine · SC

My 2016 Honda Pilot Elite has developed a loud, heavy metallic knocking sound coming from the engine block that increases in speed with engine RPMs. Despite strict regular maintenance and oil changes, the engine noise is getting progressively worse, creating an immediate risk of catastrophic engine failure, stalling, or seizing while driving on the highway. While this vehicle matches the exact failure symptoms of the federal safety agency Recall 23V751 for connecting rod bearing failure, my specific VIN is currently excluded from the recall scope. I am reporting this as part of the ongoing investigation into underreported V6 engine batches.

Filed Aug 21, 2026 · Fuel system · 198,000 miles · NC

The contact owns a 2016 Honda Pilot. The contact stated that while driving on a cross-country trip, the vehicle stalled on four separate occasions. The contact stated that on one occasion the vehicle was towed to a local mechanic who was unable to determine the cause of the failure. On several occasions, the vehicle restarted after approximately 45 minutes. The local dealer and manufacturer were notified of the failures, but no assistance was provided. The contact was informed that the VIN was not included in the federal safety agency Campaign Number: 23V858000 (FUEL SYSTEM, GASOLINE). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 198,000.

Filed Aug 19, 2026 · Fuel system · TX

The vehicle sputtered and stalled on the highway. I was able to restart after a few minutes and then it stalled again. I was able to get it to a repair shop after stalling about 3 times on the way. The diagnostic code was for the high pressure fuel pump. This was replaced. Four weeks later the same problem occurred. This time I stalled on a major freeway. I was able to restart and get it off the freeway. It stalled so frequently that I had to call a tow. The vehicle is throwing the same diagnostic code but the shop suspects the low pressure fuel pump may be the source of the issue.

Filed Jul 22, 2026 · Fuel system · NY

I am filing a safety and defect complaint regarding my 2016 Honda Pilot (3.5L V6 Engine). In Dec 2025, the "EMISSION SYSTEM PROBLEM" warning light ocationally illuminated on the dashboard. On 5/26/26.while driving, the vehicle suddenly began to shake violently and experienced a severe loss of acceleration—when I stepped on the gas pedal, the vehicle hesitated and would not speed up (loss of motive power). In June I let a certified Honda dealership scanned the vehicle and pulled diagnostic trouble codes P0430, P219A, and P219B, confirming that the fuel injectors have failed. This is a well-documented manufacturing defect explicitly detailed in Honda’s Technical Service Bulletin TSB 20-100. The defect causes uneven fuel delivery and cylinder misfires, which poses a severe driving hazard, including sudden engine stalling, loss of motive power while driving, and acceleration hesitation in traffic. Although American Honda previously extended the warranty for this specific injector defect to 10 years or 150,000 miles, my vehicle was DENIED coverage by American Honda corporate customer relations solely because it has just passed the 10-year mark (the vehicle was purchased on November 30, 2015), despite having only 140,000 miles (well under the mileage limit).This is a critical safety and environmental hazard inherent to Honda's manufacturing design. An expiration of time does not make a known manufacturing flaw any less dangerous on public roads. I request the federal safety agency to investigate this persistent issue and upgrade the current warranty extension to a mandatory safety recall so that affected consumers are not left driving hazardous vehicles or forced to pay thousands of dollars out-of-pocket for an acknowledged factory defect.

Filed Jul 8, 2026 · Engine, Fuel system · NJ

My 2016 Honda Pilot Touring repeatedly stalls and shuts off while driving, including at lower speeds in traffic. When it happens, the engine and all electrical power shut off; the vehicle then has to be jump-started, and it will sometimes only restart after sitting for an hour or more. This is a serious safety hazard because the vehicle can lose power unexpectedly while in motion, creating a risk of a crash and of being stranded in a travel lane. The failed component is the fuel delivery system (fuel pump / fuel system pressure). The condition has been diagnosed repeatedly with trouble code P0087 (Fuel Rail/System Pressure — Too Low). It was first documented on July 18, 2025 at 144,303 miles by an independent service center, which diagnosed a failing fuel pump. On March 13, 2026 a Honda dealer again retrieved code P0087 and diagnosed a failing fuel pump. In April 2026, a second Honda dealer could not reproduce the code, replaced the fuel injectors instead, and the stalling returned within about 670 miles. In May 2026 that same dealer documented the problem as a "reoccurring issue" and now recommends replacing the in-tank fuel pump. The warning symptom prior to failure was the check-engine/malfunction-indicator lamp, which set code P0087; the stalling followed. The problem has been confirmed and reproduced by both an independent service center and a Honda dealer, and the vehicle is still owned and available for inspection upon request. No crash, fire, or injury has occurred. This stalling/loss-of-power failure mode is the same one described in the federal safety agency recall 23V‑858, in which the in-tank fuel pump can fail and cause the engine to stall while driving. This vehicle is exhibiting exactly that failure mode but is not currently included in that recall population. I am reporting it so the agency is aware, and I request that this vehicle be considered for inclusion in recall 23V‑858.

Filed Jun 29, 2026 · Acceleration, Engine · IN

The 3.5L V6 engine in this vehicle suffered a sudden, catastrophic internal mechanical failure due to premature connecting rod bearing wear. The engine stalling occurred abruptly while actively driving, which created an immediate safety risk as the vehicle lost propulsion, power steering assistance, and power braking assistance. This forced a dangerous emergency maneuver to navigate through moving traffic to get to the side of the road. Prior to the engine failure, there were no persistent dashboard warning lights or clear messages indicating an imminent mechanical failure. The first distinct symptom was a brief, sudden metallic knocking sound from the engine bay immediately before the vehicle lost all power and stalled. An authorized dealership has since inspected the vehicle and dropped the oil pan, physically confirming a massive accumulation of metal shavings and bearing debris inside the block. The dealership verified that the complete destruction of the engine block is identical in nature, symptom, and cause to the manufacturing defects described in the federal safety agency Recall Campaign 23V‑751. However, this vehicle's specific VIN was excluded from that original recall parameter. This catastrophic failure directly corresponds to the ongoing Office of Defects Investigation Probe PE25008 regarding extensive V6 engine rod bearing failures. The failed engine block remains fully intact at the service center and is available for regulatory inspection upon request.

Filed Jun 10, 2026 · Engine · AL

What component or system failed or malfunctioned, and is it available for inspection upon request? The engine stalls out and shuts the car down. How was your safety or the safety of others put at risk? While driving down the road, if the engine shuts off, myself, passengers, and other vehicles could cause a fatal crash. Has the problem been reproduced or confirmed by a dealer or independent service center? Not yet Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? I have brought this in several times to try and fix this issue. The fuel pump has been replaced and the auto idle recall has been take care of. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? The check engine light comes on occasionally when it happens; sometimes when it does not. Other details: Several times now my car has randomly shut off especially when driving down the road. I wasn't sure what happened, but I finally figured out a way to replicate it. Basically if you drive it after about an hour of non-stop driving / engine being turned on, the engine overheats causing the car to stall out and eventually turn off. I timed this at 10:15AM to 11:25AM and my suspicions were correct. At 11:25AM, the car stalled and shut off while I was parked in my driveway.