2018 Honda Pilot fuel system problems

Filed Aug 29, 2026 · Fuel system · FL

High Pressure Fuel Pump fails after implementing recall listed below. See recall information: December 18, 2023 the federal safety agency CAMPAIGN NUMBER: 23V858000 Fuel Pump May Fail Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash. the federal safety agency ID Number: 23V858000 Manufacturer Honda (American Honda Motor Co.) Components FUEL SYSTEM, GASOLINE Potential Number of Units Affected: 2490460

Filed Jun 30, 2026 · Electrical, Engine · KY

Honda pilot would not restart after auto ideal engine stop. This issue caused all the warnings lights to come on with blinking engine light! Honda dealer was not able to resolve the issue and ended up paying $1500 even though it was a part of their service bulletin 23-009.

Filed Jun 4, 2026 · Fuel system · TX

While driving down a freeway, my car shuddered and my engine suddenly lost power and was put into limp mode. Mechanic determined it was the high pressure fuel pump that failed. This vehicle was part of the recall for the low pressure fuel pump that was completed. It also had to have fuel injectors replaced under Honda’s extended warranty over faulty injectors.

Filed May 28, 2026 · Fuel system · CA

Safety recall on 2018 Honda pilot fuel pump Honda dealership refuse to repair unless other repairs where done due to engine light on . I ask advisor who was helping me [XXX] to give me clarification on the reason his respond was i am just doing my job no other dealer will be able to help you Technician doesn’t want to proceed with repair due to engine light on , unless you do other repairs rough estimate amount $1851.64 I politely denied those services walk out contact another Honda dealer on May 28 2026 , I spoke to advisor Jennifer Cruz explain the situation set up an appointment for safety recall on fuel pump @ location 9055 Washington blvd , Culver City , Ca 90232 [XXX] Repairs will be done by 3pm on May 29 2026 , Jennifer Cruz was really helpful and apologized for my bad experience with previous Honda dealership INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Mar 25, 2026 · Fuel system · 82,000 miles · AZ

The contact owns a 2018 Honda Pilot. The contact stated that while driving 80 MPH, the vehicle decelerated and stalled while depressing the accelerator pedal. Several unknown warning lights were illuminated. Neither an independent mechanic nor a dealer was contacted. The contact was able to pull over to the right side of the road, depressed the brake pedal, and turned off and restarted the vehicle after several seconds, and the vehicle operated as intended. A dealer was contacted. The vehicle was not taken to a dealer or an independent mechanic. The vehicle was not repaired. The contact associated the failure with the federal safety agency Campaign Number: 23V858000 (FUEL SYSTEM, GASOLINE); however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was 82,000.

Filed Mar 16, 2026 · Fuel system · MA

What component or system failed or malfunctioned, and is it available for inspection upon request? The vehicle’s high-pressure fuel pump failed approximately one year after the low-pressure fuel pump was replaced under a manufacturer recall. The low-pressure pump had been identified as defective and replaced accordingly. Because the low-pressure pump is responsible for supplying fuel to the high-pressure pump, it is reasonable to believe the defective component may have placed abnormal stress on the high-pressure fuel pump prior to its replacement, potentially leading to premature failure. The failed high-pressure fuel pump is still in the vehicle. How was your safety or the safety of others put at risk? Failure of the high-pressure fuel pump can result in a sudden loss of fuel pressure to the engine, causing hesitation, loss of power, or engine stalling while the vehicle is in operation. This created a significant safety hazard, particularly as it occurred during highway driving, where sudden loss of propulsion occurred. Has the problem been reproduced or confirmed by a dealer or independent service center? The issue was diagnosed and confirmed by a service center as a failed high-pressure fuel pump. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle was inspected by my personal mechanic who indicated fuel pump issues and noted recall then a Honda dealer during diagnosis but recall was for previously replaced low pressure pump and not the High pressure pump the issue has yet to be repaired. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Prior to the failure, the vehicle began experiencing noticeable fuel system performance issues, including reduced engine performance loss of MPG and drivability concerns. No lamps

Filed Sep 22, 2025 · Fuel system, Transmission · CA

Driving to work on the freeway, all of a sudden acceleration stopped. Pulled over as warning lights came on due to transmission. Additionally, the check engine light appears randomly due to emission and also the “AWD” light comes on. Within a few days or even weeks it turns off. This has been on and off since we purchased the vehicle from CarMax.

Filed Sep 17, 2025 · Fuel system · NY

[XXX] an Error Code "Emissions System Problem" came up. We brought to personal mechanic error code P0430 came up when they attached the code reader to the underside of the dashboard. Our mechanic told us we had to bring to Honda. Brought to Millenium Honda in NY, no code was in "system", they told us about recalls and fixed the recalls. We took the car on vacation and the light came on again while driving from NY to SC. Brought to Honda dealership to have looked at, code was off. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 12, 2025 · Fuel system · CA

My Honda Pilot 2018 is a modified vehicle with wheelchair ramp. It is in the recall list for Honda. Recall: swelling of fuel pump motor impeller, fuel pump may seize/stop working. Defective impeller may cause fuel pump inoperative, which could prevent engine from functioning. May cause a loss of motive power/stall while driving, increasing risk of crash or injury creating a safety hazard. -Replace the fuel pump motor. I contact the Honda dealer in San Jose, CA, but they were unable to perform Fuel Pump replacement due vehicle being modified. Tell me to find a dealer that specialize in accessible vehicle to removed cover on floor to access fuel pump then bring fuel pump to Honda for them to replace. DMV requires to perform recall to renew vehicle registration. I do not know which dealer I need to perform this recall.

Filed Aug 14, 2025 · Fuel system · SC

The car is Less than 80,000 miles and all 6 fuel injectors are faulty and need replacing. As well as the fuel pump. Other Hondas have been recalled for the same issue but this make and model has not.