2012 Hyundai Santa Fe: engine stalls while driving

Filed Jun 22, 2026 · Engine · NM

On June 16, 2025, I dropped my 2012 Hyundai Santa Fe GLS (VIN: [XXX]) off at Larry H. Miller Southwest in Albuquerque, NM for the federal safety agency safety recall #20V746000 (Theta II engine connecting rod bearing failure). It has now been over one week with zero communication from the dealership regarding the status of my vehicle. When I attempted to follow up by phone I was unable to reach anyone in the service department. Upon calling Hyundai corporate customer service I was informed that the dealership had a name discrepancy in my paperwork and my owner profile was not linked to my VIN in their system. The recall work has not begun. I was given a corporate case number but was told to call back the following day to check in rather than receiving a callback. The burden of all follow up has been entirely on me. This is my only vehicle. I have been without transportation for over a week affecting my ability to get to work. No loaner or rental vehicle has been offered or provided. My vehicle was brought in specifically for a federal safety recall involving a known engine defect that can cause fire or engine stall. The dealer’s handling of this recall has been completely unacceptable and I am requesting the federal safety agency intervention to ensure compliance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 27, 2025 · Electrical, Engine · FL

In November 2024, my car engine failed. I came out of a store, turned key, all the dash lights lit up, and loud clanging but unable to drive. Car towed several times and told by 2-3 places the engine was “out” and there was a Hyundai recall aon 2012 Santa Fe. A Hyundai dealer had my vehicle, contacted Hyundai and was told it “wasn’t in recall.” Had to pay repair entirely myself on disability income. The vehicle subsequent to this had electrical problems and the car shut off while driving countless times, even highway doing 65-70. Paid for alternator twice and new battery, two battery jump boxes, and car continues to have severe electrical issues and highly unsafe to drive. I am broke and facing losing the car altogether and suffered lack of housing for 2 months and inability to pay my bills. All invoices are not included with this complaint.

Filed Jan 8, 2025 · Engine · GA

My engine stalls while driving. Now engine is knocking real loud. Then stall again. My safety and others drivers safety because my engine stalls could cause a crash, wreck. Mechanic listened to engine, said engine is knocking and stalling, this is a safety issue. Vehicle has not been inspected by manufacturer, or others. No warning lights, symptoms, Monday December 30, 2024.

Filed May 3, 2024 · Engine, Lights · TX

I have complained about this previously to recall, and it's doing it again. My engine shut off while driving its happened on the Fred harrman bridge twice now. All the dashboard lights come on and the engine shuts off I had to put it in neutral and restart it. It very dangerous and scarey experience. Also one of my passerger head light doesn't come on sometimes and the back driver side tail light. I can get out and hit it then it will come on. I have been pulled over by the police for it once before I told them it works just hit it. He did told me to get that fixed and gave me a warning. I can't afford to eletbeledtrical done little alone an engine please help. Call should have the first report as well.

Filed May 1, 2023 · Engine · 73,000 miles · NJ

The contact owns a 2012 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the check engine and oil warning lights were illuminated before the vehicle stalled. The contact stated that upon inspecting the vehicle, the oil displayed full. The contact then stated that the vehicle was towed to an independent mechanic where it was diagnosed that no oil pressure was detected, and the contact was informed by the technician of the federal safety agency Campaign Number: 20V746000 (Engine) which was associated with the failure. The vehicle was not repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 73,000.

Filed Apr 5, 2023 · Engine, Fuel system · CA

After driving for a short time, the engine stalls while driving. We have taken the car to 4 different mechanics, including the Hyundai dealer and the issue has not been fixed. The car stalls every time it is driven.

Filed Mar 22, 2023 · Engine · 199,000 miles · GA

The contact owns a 2012 Hyundai Santa Fe. The contact stated while driving approximately 30 MPH, she heard an abnormal popping sound coming from the engine compartment. The contact stated that the vehicle stalled and failed to restart. The contact was unaware of a warning light being illuminated. The vehicle was taken to an independent mechanic who diagnosed the vehicle and determined that the engine had seized and needed to be replaced. The mechanic advised the contact that there had been a recall for the year, make and model of vehicle however, the VIN was not included. The mechanic related the failure to the federal safety agency Campaign Number: 20V746000 (Engine). The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 199,000.

Filed Feb 4, 2023 · Driver assistance, Engine · MA

Driving on highway and car engine light came on then car engine kicked down like it was going to stall then drove normally then kicked down again . Kept kicking down , drove it home and shut it off. The car starts but is knocking and the engine light comes on and blinks constantly .

Filed Jan 17, 2023 · Engine · 160,000 miles · MT

The contact owns a 2012 Hyundai Santa Fe. The contact stated that after the federal safety agency Campaign Number: 20V746000 (Engine) was completed and driving at approximately 70 mph, there was a loud abnormal noise under the vehicle and the steering wheel began to shake. In addition, the dashboard was hot to the touch. The contact merged into the shoulder of the road and the vehicle suddenly stalled without warning. The vehicle was towed to the dealer who diagnosed that the rod bearing fractured and detached causing a hole in the engine. The engine and rod bearing needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 160,000.

Filed Sep 7, 2022 · Engine · FL

Engine stalled, shutting down both power steering and power brakes, restarted, stalled again and then never started again, while driving 70 mph on a major extremely busy thoroughfare (SR202 in Jacksonville, Fla.) in 05/13. Had vehicle towed to regular mechanic 05/16 who said engine blown, but under recall. Then towed to Jenkins Hyundai 05/19. They inspected vehicle, confirmed engine replacement based on TSB 21-01-022H testing (they gave me a copy) for recall 198. Jenkins then contacted me, replacement was denied approval by [XXX] PA#[XXX], because it listed as "scrap", that 198 is only a "recall campaign, not a safety issue", engine would cost $12,000,00. I found the 198 SAFETY notice online and took it to them, they said they couldn't do anything, I would need to contact Hyundai corp. Contacted Hyundai 06/01, assigned case number [XXX]. [XXX] from HMAusa (833‑462‑8722 x [XXX]) emailed asking for info, I returned email same day (06/01). [XXX] then emailed 06/07 and I responded both via phone and email same day. Jenkins Hyundai has since called asking what I intended to do. I called [XXX] and she confirmed vehicle listed as "scrap", but that Hyundai does safety recalls on rebuilt title vehicles to talk to dealer again. I uploaded to HMAusa photos of my insurance, registration, tags and even photos of my car at [XXX], copied also to [XXX] (the prior approval email for dealers) on 06/15. Told [XXX] "[XXX] confirmed safety work on rebuilt title vehicles", but they are waiting on HMA approval. It has now been 4 months and nothing. I emailed Center for Auto Safety 08/18 and they confirmed repair is required by federal law even on salvage title. I emailed [XXX] 08/19 about noncompliance and again on 08/24, uploaded to HMAusa. New HMA #20221366, received 08/30 [XXX] "response in 48 hours". the federal safety agency #[XXX], spoke with [XXX]. As of 09/07 still nothing. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Filed Jun 6, 2022 · Engine · 205,000 miles · OR

The contact owns a 2012 Hyundai Santa Fe. The contact stated that he received notification of the federal safety agency Campaign Number: 20V746000 (Engine) and the vehicle was taken to the dealer for the recall repair. The dealer inspected the vehicle and informed the contact that they did not have the proper equipment to complete the inspection of the vehicle as instructed by the manufacturer. The contact stated while driving 60 MPH, he heard abnormal sounds coming from the vehicle. There was no warning light illuminated. The contact stated that the failure recurred increasingly while driving and occasionally the vehicle would stall. The vehicle was towed to the residence of the contact’s niece. The vehicle was then towed to the local dealer where the failure was diagnosed as a fractured connecting rod and camshaft bearing failure. The dealer sent a diagnostic report to the manufacturer; however, the manufacturer declined to cover the repair under the federal safety agency Campaign Number: 20V746000 (Engine). The vehicle was not repaired. The failure mileage was approximately 205,000.

Filed May 20, 2022 · Engine · NY

The contact owns a 2012 Hyundai Santa Fe. The contact stated that while his daughter was driving, the vehicle stalled without warning. The contact jumped started the vehicle however, the vehicle stalled again. The vehicle was towed to an independent mechanic where he informed the contact that the engine had seized. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.