Hyundai Santa Fe screen failure problems

Filed May 29, 2026 · Electrical, Seats · IA · 1 injury

My 2024 Hyundai Santa Fe (VIN: [XXX] ) is suffering from a severe, systemic vehicle-wide electrical network failure. The main digital instrument cluster screen has suffered four separate total blackouts (XXX), completely eliminating all driver visibility of the speedometer, odometer, safety malfunction telltales, and critical warning alerts while operating the vehicle at highway speeds. The vehicle has also experienced continuous battery collapses, recurring navigation freezes, and malfunctioning proximity key fobs/electronic door locks that fail to secure or unlock the vehicle.Most severely, on XXX, a defective, short-circuiting heated seat element experienced an uncontrolled thermal spike and caused physical thermal burn injuries to the right side of my body during an out-of-state trip. Photographic evidence of the physical body burns has been preserved. The authorized dealership was presented with this defect during an extended 38-day shop visit immediately following the incident but was completely unable to diagnose, or repair this severe electrical safety hazard. The vehicle remains unsafe to occupy. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 22, 2026 · Driver assistance, Electrical · ID

The vehicle has two display panels, molded into a single frame. There is an infotainment panel on the right that handles music, maps, and phone interaction. There is an instrument panel on the left. The infotainment panel has not issues. The instrument panel blanks out for 3 - 5 seconds every few minutes, and then reappears. Occasionally the words "No SIgnal" in big red letters will appear. Occasionally the gear selection letter will remain on the otherwise blank screen. The screen also shudders / tears occasionally before blanking. It does this whether the vehicle is moving or parked. I purchased the vehicle used, Jan 2 2026. I noticed the problem a couple of days later. It has continued. It is not getting any worse or any better.

Filed Apr 10, 2026 · Electrical · TX

The digital screens that contain the gauge cluster and infotainment array intermittently flicker, black out, or go to static. Sometimes it's one side or the other and sometimes it is both. When the gauge cluster screen is affected, the heads-up display on the windshield also turns off. All of this can happen while the vehicle is idle or while driving. Sometimes the displays flicker and sometimes they just black out or go to static for the entirety of the drive. It is available for inspection. The biggest safety concerns are the complete lack of a speedometer or warning lights when this problem occurs. The problem did not have to be reproduced by the dealer because the screens and the HUD were completely blacked out when the vehicle was taken in for service. The problem was supposedly "repaired" with an "update". The problem has since resurfaced. The vehicle was inspected by service center personnel at a Hyundai dealership. When asked, a representative of that dealership stated that the problem is common amongst all Hyundai models featuring digital displays. There was no warning of the problem. One day the problem did not exist and the next it did.

Filed Mar 16, 2026 · Driver assistance · 50,667 miles · NJ

The contact owns a 2021 Hyundai Santa Fe. The contact stated that the vehicle was repaired under the federal safety agency Campaign Number: 24V879000 (BACK OVER PREVENTION), but the failure occurred. The contact stated that the back over prevention camera displayed a distorted image or a black screen occasionally while the vehicle was in reverse(R). The failure obstructed the driver's visibility, which prevented the driver from safely operating the vehicle. The dealer was contacted, and the contact was informed that there was no record that the vehicle had been taken to the dealer. The contact found the paperwork provided by the dealer when the recall repair was completed. The vehicle was not taken to the dealer or an independent mechanic for the most recent failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 50,667.

Filed Feb 25, 2026 · Electrical · MI

The rearview backup camera system malfunctioned. The camera was replaced under a safety recall on my 2021 Hyundai Santa Fe. Within four days of the recall repair, the camera continued to fail intermittently, displaying a blank/black screen and not providing a rearview image when the vehicle was placed in reverse. The vehicle is available for inspection upon request. I also have video documentation clearly showing the malfunction occurring. The failure of the rearview camera puts me and others at risk because the system is required to provide visibility behind the vehicle when reversing. When the screen goes blank, I cannot see pedestrians, children, vehicles, or objects behind me. This creates a significant risk of a backing collision, especially in parking lots and residential areas. The vehicle was brought back to the dealership four days after the recall repair because the issue continued. The dealer stated they could not duplicate the issue at the time of inspection and are requesting a diagnostic fee to continue evaluation. However, I have video evidence clearly showing the malfunction occurring after the recall repair. The vehicle has been inspected by the dealership that performed the recall repair. It has not been inspected by police or insurance representatives. The manufacturer has not personally inspected it beyond the dealership performing the recall repair. There were no warning lamps. The issue presents intermittently when shifting into reverse, at which time the display screen fails to show the rearview camera image. The issue first appeared prior to the recall repair and continued within four days after the recall component was replaced.

Filed Feb 22, 2026 · Electrical, Engine · AZ

After turning off the radio with the push button control the instrument cluster and navigation display panel went completely dead black. After pushing multiple buttons several times the panel came back to life. This has not yet been reported to the dealer. On 12/12/2025 this same vehicle also experienced faulty engine / power train components which required replacement @1199 miles. Throttle body assembly and torque converter assembly which caused loss of power when accelerating onto a high speed parkway attempting to reach @55mph along with excessive vibration when brakes were off. Took dealer 22 days to fix the problem.

Filed Jan 14, 2026 · Electrical, Transmission · IL

While driving my 2024 Hyundai Santa Fe, the vehicle experienced a complete dashboard and system blackout, as if the vehicle shut off and rebooted. This has occurred on two separate occasions. On one occasion, while stopped at a traffic light, the dashboard went completely black and restarted. After the system rebooted, the vehicle would not accelerate or move when the accelerator was pressed. I had to turn the vehicle off, restart it, and wait before it would drive again. The suspected malfunction involves the vehicle’s electrical/infotainment and related vehicle control systems. The vehicle is available for inspection upon request. My safety and the safety of others were put at risk because the vehicle lost critical dashboard information and temporarily lost the ability to accelerate while in traffic, creating the risk of being struck by other vehicles. The vehicle was inspected by an authorized Hyundai dealership (World Hyundai of Matteson). On December 23, 2025, I was informed by the dealer that a system/infotainment “glitch” had been identified and that a replacement part would be ordered. However, the part was never replaced. The dealer later stated that because the issue could not be duplicated during test drives (approximately 85 miles driven), the repair was not authorized. The dealer acknowledged the issue could not be reproduced on demand. The manufacturer (Hyundai) has not yet physically inspected the vehicle beyond dealership involvement. No police or insurance inspections occurred, as there was no crash. There were no warning lamps or messages prior to the failure. The failure occurred suddenly with a complete dashboard blackout and system restart. The first occurrence happened prior to December 23, 2025; the second occurred afterward. The issue is intermittent and unresolved. I am concerned that the defect must reoccur while driving in order to be repaired, posing an ongoing safety risk.

Filed Nov 6, 2025 · Electrical · 6,000 miles · FL

The contact owns a 2025 Hyundai Santa FE. The contact stated that while parked and seated in the vehicle, the instrument panel was blinking on and off several times before going dark. The contact stated that the infotainment system also displayed a blank screen. A dealer was contacted. The vehicle was taken to the dealer for a recall repair, and the contact was informed that there was no failure with the instrument panel. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 6,000.

Filed May 27, 2025 · Driver assistance, Electrical · CA

I am writing to formally express my deep concern and dissatisfaction with the ongoing quality and safety issues I have experienced with my 2021 Hyundai Santa Fe, which I purchased new in March 2021. Despite regular maintenance and careful ownership, this vehicle has presented a persistent pattern of failure—most notably involving the electrical systems, onboard cameras, and overall build quality. Specifically, the following issues have occurred: •The rear backup camera has intermittently failed for an extended period, frequently displaying a black screen or static lines, rendering it unusable. •The front camera system has now failed entirely, disabling several advanced safety features. A warning alert is permanently displayed on the dashboard and cannot be dismissed. •I was recently informed that repairing this front camera will cost approximately $2,400, a significant expense for a system that should not fail this early in the vehicle's life cycle. •The overall quality of the interior materials has proven to be poor, with excessive wear and inconsistent performance of various controls and features. •In general, the engine power and performance fall well below expectations, especially given Hyundai's advertised standards. These recurring issues have not only affected our driving experience but have also introduced serious safety concerns, particularly as critical systems such as cameras and driver-assist features are now non-functional. We have never experienced this extent of problems with any vehicle in our ownership history. At this point, we are extremely disappointed and frustrated, and we feel that Hyundai has failed to uphold the level of quality and reliability expected from a modern, family-oriented SUV.

Filed Jan 10, 2025 · Engine · GA

While driving my 2017 Hyundai Santa Fe Sport, I heard a knocking sound coming from the engine. Shortly afterward, the vehicle began moving jerkingly forward, and the oil, engine, and battery warning lights illuminated on the dashboard. The vehicle then shut off completely in the middle of a busy street. I attempted to restart it, but while the engine made a starting sound, it immediately shut back down. The electrical system remained functional (lights and radio), but the vehicle would not restart. Due to the failure, I had to exit the vehicle and physically push it to the side of the road in cold, rainy conditions with reduced visibility, creating a risk of being struck by oncoming traffic. Strangers who assisted in moving the vehicle also placed themselves at risk. A certified mechanic has since confirmed that the engine has locked up and identified this as a known issue with Hyundai engines. Prior to this incident, the only warning sign was the oil light briefly flashing while driving on an uneven road surface. At the time, I was on my way to have an oil change within the manufacturer-recommended time frame and assumed the light indicated routine maintenance was needed.