Hyundai Santa Fe door locks problems

Filed Jun 25, 2026 · Electrical · MD

On June 24, 2026, my spouse was operating our 2025 Hyundai Santa Fe when the vehicle suffered a sudden, catastrophic, and total electrical failure while actively on the roadway. The vehicle was stopped at a traffic light when all propulsion power was instantly lost, the engine shut down, and all electronic systems—including the center infotainment screens and instrument cluster—went completely dark. Safety Hazard & Entrapment Incident: Simultaneous with the total electrical failure, the vehicle's electronic door lock system malfunctioned. The rear passenger doors and rear liftgate locked completely and could not be disengaged or opened from the inside by the passengers. Due to this total power loss and lock failure, my young daughters were trapped in the rear seats. My spouse was forced to climb over the center console from the front seat into the rear cabin to manually extract our children through the front doors. The family had to abandon the disabled vehicle in live traffic and walk down the roadway to reach a safe location. This constitutes a severe safety hazard involving both sudden loss of motive power on a public road and occupant entrapment due to safety lock/latch failure during an electrical short. The vehicle has been towed to Pohanka Hyundai of Capitol Heights for inspection.

Filed May 29, 2026 · Electrical, Seats · IA · 1 injury

My 2024 Hyundai Santa Fe (VIN: [XXX] ) is suffering from a severe, systemic vehicle-wide electrical network failure. The main digital instrument cluster screen has suffered four separate total blackouts (XXX), completely eliminating all driver visibility of the speedometer, odometer, safety malfunction telltales, and critical warning alerts while operating the vehicle at highway speeds. The vehicle has also experienced continuous battery collapses, recurring navigation freezes, and malfunctioning proximity key fobs/electronic door locks that fail to secure or unlock the vehicle.Most severely, on XXX, a defective, short-circuiting heated seat element experienced an uncontrolled thermal spike and caused physical thermal burn injuries to the right side of my body during an out-of-state trip. Photographic evidence of the physical body burns has been preserved. The authorized dealership was presented with this defect during an extended 38-day shop visit immediately following the incident but was completely unable to diagnose, or repair this severe electrical safety hazard. The vehicle remains unsafe to occupy. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 4, 2026 · Driver assistance, Electrical · MO

"What component malfunctioned...?" - Electrical system (suspected) "How was safety put at risk?" - We were unaware if the dashboard instruments were reading correctly. We also couldn't lock/unlock the doors or open/close the windows. The tailgate would also not open. "Has problem been reproduced?" - Not yet - plan to have the service center inspect. "Has vehicle been inspected by the manufacturer?" - No "Were there warning messages or symptoms?" - Yes, when the issue occurred. The vehicle reported 13 warnings/alerts. Happened for the first time on 5/2/2026 GENERAL DESCRIPTION: While the vehicle is parked or idling after sitting for a period of time, the dashboard suddenly displays approximately 13 warning alerts simultaneously, including a message stating "Check Emergency Stopping function" among others. During this condition, multiple vehicle systems become inoperative, including: - Power windows - could not open/close - Door locks - could not lock/unlock - Tailgate operation - could not open (it was closed) The vehicle appears to experience a system-wide electronic failure affecting both body controls and safety systems. The condition is intermittent but has occurred multiple times. Restarting the vehicle does NOT immediately resolve the issue. After driving for a period of time, the vehicle eventually returns to normal operation. This is a safety concern because: - Critical safety systems (automatic emergency braking / driver assist features) are (potentially) disabled - Basic vehicle functions (locks/windows) are unavailable. This is a concern if the door can't be opened and one needed to exit through the window in an emergency. - The failure occurs without warning and cannot be reliably reproduced on demand This appears to be a broader electrical or communication system failure rather than a single component issue.

Filed Apr 22, 2026 · Electrical, Suspension · KY

The vehicle intermittently fails to reverse properly, hesitates, jerks, and at times locks despite no obstruction present. This occurs during normal use and creates a serious safety concern, particularly when backing out of parking spaces or into traffic. In addition, the vehicle exhibits ongoing electrical issues, including intermittent warning lights, rearview camera distortion or failure, inconsistent system operation, intermittent inability to unlock using the key fob or door handle, and the vehicle fan or air system continuing to run for extended periods after the vehicle has been turned off. These issues occur without consistent warning and have not been resolved despite multiple service visits. The vehicle is also subject to an active safety recall (the federal safety agency Recall 26V218000, Manufacturer Recall 298) involving the front seatbelt anchor. The recall remains unrepaired, with no remedy currently available. I have personally experienced the seatbelt becoming stuck and not releasing properly, which presents an additional safety risk. The vehicle also experienced a battery failure. I was initially informed that the battery could not be replaced without cost; however, it was later replaced. Despite repeated concerns, the hybrid battery system was not tested or evaluated, and this remains an unresolved issue affecting vehicle reliability and safety. Additionally, the vehicle has experienced tire tread separation and peeling requiring replacement. This is not consistent with normal wear and may indicate alignment, suspension, or other underlying vehicle-related defects. The vehicle has been inspected by the dealership multiple times; however, the issues were not reproduced and no corrective repairs were performed. These problems are intermittent and occur during regular day-to-day operation. Collectively, these unresolved issues present an ongoing safety risk to the driver and others.

Filed Nov 13, 2025 · Driver assistance · GA

1. [XXX] – I went to get into the Satna FE, the lights blinked and mirrors moved into the unlock position, but doors would not open. I had to use my husbands car since he was out of town to get to work. I came home at lunch after calling my husband and my salesperson , Paula and used the valet key and was able to unlock and get into the vehicle. I then started the Santa FE and this is when the safety warning message appeared. I felt unsafe and Paula had the Hyundai of Statesboro tow the vehicle from my home, retained it for approximately three days, and reported the issue resolved after clearing diagnostic messages and conducting a 50-mile road test. Vaden of Statesboro contacted me on October 17th stating it was ready for pickup and all the codes were cleared. I picked it up on October 18th. 2. [XXX] – The same issued with the doors not opening and had to use the valet key again, the safety warning reappeared around midday while driving, accompanied by a hard shift / drivetrain shock. The vehicle was returned to Hyundai of Statesboro at approximately 5 p.m. The dealer acknowledged the repeated issue and provided a rental vehicle for me ([XXX]), while repairs continue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 7, 2025 · Electrical · 72,000 miles · IN

The contact owns a 2017 Hyundai Santa Fe. The contact stated that the automatic power door locks failed to operate as needed. Due to the failure, the contact had to manually unlock and lock all doors inside the vehicle. In addition, the contact stated that the button to unlock the gas cap also failed to operate as needed. The vehicle was not yet diagnosed or repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 72,000.

Filed Jan 23, 2025 · Body · CA

The back passenger door will not open from outside or inside (driver side) which is safety issue that needs to be recalled immediately.

Filed Dec 10, 2024 · Body · FL

Locked the doors normally with the remote. Went into the doctor's office. Returned to the car the driver's door would not unlock. All other doors worked normally. Could not unlock the door with either handle, the switch or the remote. The Dealer says that the door latch mechanism failed in the locked position with the door closed. This would make it very difficult to exit the car in an accident, fire or submersion. The only exit is to crawl over the high mid console and exit through the right front passenger door, this is a very difficult maneuver.

Filed Oct 20, 2024 · NC

My drivers side door will not close. Everytime I close it, it doesn’t latch and remains open. There is absolutely no way to close the door. This happen while I was driving my car, the door flew open and when I shut it, it wouldn’t latch.

Filed Aug 6, 2024 · VA

My driver side passenger door will not open from the inside or the outside. You can hear the locking mechanism lock and unlock, however the door is stuck shut. It locked my 2 year old in. Put her in, drove about 15 minutes down the road then was no longer able to open her door. This is obviously not safe for anyone of any age. There are multiple forums of multiple people with the same issue with a malfunction of Hyundais doors. Hyundai needs to make their vehicle safe.