2004 Hyundai Sonata locks problems

Filed Aug 22, 2011 · Locks · 73,500 miles · MD · 1 injury

Tl* the contact owns a 2004 hyundai sonata. The contact stated that the chrome handle on the rear passenger door peeled and caused the contact to cut his hand. The vehicle was taken to the dealer who stated his vehicle was not included in the federal safety agency campaign id number: 09v171000 ( latches/locks/linkages: doors: latch). The manufacturer was contacted confirmed that the vehicle was not under recall and offered no other assistance. The failure mileage was 73,500.

Filed Aug 19, 2010 · Body, Locks · 93,000 miles · TX · 1 injury

Inside door handles thin covering (appears to be aluminum) is peeling apart and I have cut my hand on the sharp edge which came apart. Dealer will not replace the handle because hyundai has not recalled the 2004 models which has the ***same problem**as the 2003 model.

Filed Aug 1, 2010 · Body, Locks · 14,200 miles · NJ

Chrome is peeling off the interior door handles causing cuts to hands/fingers on my 2004 hyundai sonata.

Filed Mar 14, 2010 · Body, Locks · 85,000 miles · MN · 2 injuries

2004 hyundai sonata. Built iin february 2004, the chrome plating of the interior door handle came loose. Our hands have been cut several times by the sharp edges of the chrome that is peeling back. Finally had to peel the chrome off and sand the edges.

Filed Dec 14, 2009 · Lights, Locks · 57,446 miles · DE

Emergency flashers began flashing for no apparent reason and would not be turned off. Then trying to use the keyless entry door opener, the locks began locking and unlocking. When the car was running this stopped. We took it to the dealer and they replaced the etac module, then the entire fuse box. After returning home, the hazard lights again began flashing while the car was parked. This would stop and begin again intermittently. Returned to the dealer and left the car for several days. Finally a switch was replaced and the problem ceased.

Filed Dec 3, 2009 · Locks · 60,000 miles · NJ

I have a 2004 hyundai sonata - same problem as with the 2002-2003 listed below - this should not have been closed. Recall campaign 09v171000 has 1 related investigation(s) the federal safety agency action number: pe08071 vehicle make / model: model year(s): hyundai / sonata 2002 manufacturer: hyundai motor company component: latches/locks/linkages:doors:latch date investigation opened: december 15, 2008 date investigation closed: may 29, 2009 summary: the manufacturer has issued a safety recall notification as a result of this investigation. The recall affects 91,202 my 2002-2003 subject vehicles produced from january 28, 2002, through march 22, 2003. The vehicle recall population was defined by the manufacturer's use of a new supplier for the chrome plating process beginning in january 2002, and a production change in march 2003 to improve adhesion of the plating to the door handle. Vehicles being recalled represent 59 percent of the total my 2002-2003 production, but account for 91 percent of the consumer complaints received. The process change for my 2002 vehicles resulted in a dramatic increase in complaints (1200 percent on a per unit rate basis). My 2003 vehicles built after march 2003 production change showed a similar decline in the complaint rate. Based on the manufacturer's action, this investigation has been closed.

Filed Oct 30, 2009 · Locks · 34,000 miles · FL · 1 injury

Tl* the contact owns a 2004 hyundai sonata. In february 2009, the top edge of the interior door handle developed cracks. As a consequence she injured herself while opening the door. She took the vehicle to the dealership to be inspected and was told that the part for the repair would cost $70.00. The vehicle had not been repaired to-date. Her model year was excluded from recall# 09v171000 & 09v317000 (latches/locks/linkages:doors:latch). The current mileage was approximately 36,000. The failure mileage was approximately 34,000.

Filed Sep 30, 2009 · Locks · 88,000 miles · NJ

The chrome plating on the passenger side door handle as worn to the point where it has cracked and left a sharp edge on my 2004 hyundai sonata. This caused a recall of 2002-2003 hyundai sonatas 09v‑171.

Filed Aug 31, 2009 · Body, Locks · 51,900 miles · NJ · 1 injury

2004 hyundai sonata - interior door handle caused hand laceration by peeling chrome plating /crack in door handle assembly.

Filed Aug 30, 2009 · Locks · PA · 1 injury

2004 hyundai sonata - the interior handles have developed very sharp edges which we did not notice until I sliced my middle finger open yesterday while trying to open the door. Upon closer inspection, both front door handles have razor-sharp edges in places. I have not yet had the opportunity to contact hyundai.