2004 Hyundai Sonata steering problems

Filed Apr 29, 2026 · Steering, Suspension · MI

2004 Hyundai Sonata GLS front sub frame (K Frame) has rusted out but I guess for certain VIN numbers there was a recall. Mine has the same issue and has caused suspension issues with the control arms and axles, subframe has snapped due to rusting in Michigan.

Filed Apr 18, 2023 · Steering, Suspension · VI

the federal safety agency Campaign 09V124000 (Hyundai Recall #089) - excessive corrosion, thinning of the metal and perforation of the front sub-frame steel, due to road salt, resulting in separation of the forward mounting of the lower control arm increasing the risk of a crash. The recall was issued in 2009 for 1999-2004 Hyundai Sonatas. The present owner purchased the vehicle in 2014 with no knowledge of previous recall. The excessive corrosion and perforation of the sub-frame was brought to the owner's attention in December 2022 during a routine oil change by a Meineke shop and reported as unsafe to drive. The vehicle was towed to Route 1 Hyundai in Monmouth Junction, New Jersey, for inspection and repair estimate on December 30, 2022 and an online complaint filed with Hyundai Motor America for the recall (Case #[XXX]). Following numerous email communications to Hyundai Consumer Affairs, it was confirmed by a National Consumer Affairs representative that the vehicle was covered in Hyundai Recall #089. Route 1 Hyundai took photos of the front sub-frame and H-frame, completed a report and submitted it to Hyundai Motor America. Hyundai Motor America responded that they are declining assistance due to the failure being out of warranty caused by the time in service and mileage of the vehicle. The vehicle has 80,000 miles on the odometer. I am of the understanding that safety recalls are never out of date. Please verify if the response made by Hyundai Motor America is justified. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Filed Jul 10, 2019 · Steering, Suspension · 220 miles · RI

I have a 04 hyundai sonata which was recalled for the subframe rot and the dealership says it doesnt come up with my VIN but iv had to replace 2 tired and a tie rod and the sub frame is getting worse causing more damage my car pulls bangs and one day my whole suspension will detach and how is it not under the recall I have a house and two children and can not afford a new car so please help me understand

Filed Jun 9, 2019 · Steering, Wheels · MS

Takata recall my steering get tight while I'm driving which makes it hard to turn while on the highways

Filed Jan 19, 2019 · Steering, Suspension · 133,321 miles · TN

The contact owns a 2004 hyundai sonata. While the vehicle was undergoing routine maintenance due to steering issues and front end noise an independent mechanic diagnosed that there was extensive rust and corrosion concerning the front cradle frame near the front passenger side tire and near the concentrix brake adjustment for both rear tires pertaining to the subframe. The independent mechanic advised the contact to contact the local dealer for the manufacturer for a recommendation.dealer recommends the entire cradle be replaced as it will not last much longer and can be dangerous to drive as it is almost rusted through and the rear brakes cannot be adjusted due to rust. There is a recall 09v124000 for this for cars from the rustbelt states but I am in tn and it is not covered. I am in the mountains of north east tn and it should be covered as we also get snow and they salt the roads. This car is dangerous to drive in its present condition and hyundai needs to have this fixed as obviously from the complaints there is lots of this. Mfg in sept of 2003 so it is within the time frame

Filed Oct 26, 2017 · Steering, Suspension · 200,000 miles · VA

The 2004 hyundai sonata has a recall for the front sub frame rusting to the point where the front suspension mount rust to the extent that the lower control arm separates from it's mounting bracket which can cause loss of control and possible accident. There is a recall for this for cars that were sold or registered in the salt belt states. Every state in my area are listed except my state of virginia. My cars sub frame completely rusted through to where the lower control arm separated from it's brackets while moving entering an exit onto a major highway i95 causing severe damage which isn't covered. The recall is 09v124000. I believe virginia should be added to this recall due to it being in the same area as the other states with the same weather pattern.

Filed May 4, 2017 · Body, Steering · 188,000 miles · KY

Tl* the contact owns a 2004 hyundai sonata. While driving unknown speeds, the steering was unstable and the vehicle shook. The check engine indicator illuminated. The vehicle was taken to an independent mechanic who diagnosed that the cradle had a large rust spot. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 188,000.

Filed Mar 11, 2017 · Steering · IL

When I drive in the rain and go through standing water the steering column freezes making it virtually impossible to move.

Filed Aug 19, 2016 · Steering, Suspension · KS

Severe corrosion on front subframe. It is a recall but no feedback from hyundai. Salt belt corrosion (lawsuit) again no feedback. Extremely dangerous , could result in injury

Filed Nov 22, 2015 · Body, Steering · 70,000 miles · NY

Front sub frame rusted. Crack in the sub frame near the right front wheel. Car has 70,000 miles on it. Danger of subframe breaking and control arm disconnect.