2011 Hyundai Sonata: engine knocking or ticking

Filed Aug 18, 2026 · Engine · CA

The vehicle suffered an internal connecting rod bearing failure, a known manufacturing defect affecting the Theta II GDI engine. The failure was explicitly diagnosed via the manufacturer - specific OBD-II fault code p1326 Knock Sensor Detector System. This defect causes sudden engine stalling poses an immediate risk of catastrophic engine failure or fire while driving. Hyundai Motor America has denied financial reimbursement for the required engine repair because the work was completed by an independent shop and third-party arbitration deadline (BBB Auto Line) communicated to me. The manufacturer is actively refusing to remedy an acknowledged safety defect.

Filed Jul 22, 2026 · Acceleration, Engine · OK

I test drove the vehicle at an auction, watched several other people test drive the vehicle. Before the auction I test drove it one more time and put my obd scan tool on it to make sure there were no hidden codes or problems. I won the bid,and picked up the vehicle. I drove it approximately 6 miles from the auction and the falshing engine light popped on. I immediately pulled over in heavy freeway traffic. Put my scan tool on it and found out the knock sensor had triggered. The vehicle was shaking and making a terrible racket. It was inoperable in the worst possible spot on Highway 51 during rush hour traffic. I managed to slowing coast down the offramp and roll into a parking lot. I then called Purdy Hyundai and spoke with a service advisor and provided the VIN#. He (Vue Kue) informed me that the vehicle qualified for the recall and warranty work based on exactly that issue. I had the vehicle towed to the Purdy dealership on July 8th 2026. I was told today that it was unlikely that Hyundai would honor the recall because I did not have service records of a vehicle I had owned for 6 miles of driving. I filed a complaint with Hyundai corporate. Claim#43010067 and awaiting the reconciliation of this situation. Of which they appear to to be avoiding.

Filed Jul 1, 2026 · Engine · CA

Rod bearing issue due to particles in engine causing engine to not accelerate as normal and jerk when goes over 10 MPH can’t exceed 50 miles causing safety issues and knocking/clicking noise took it to Hyundai and was informed it is apart of the recall but wont replace engine my vehicle has ALL the same issues as the Hyundai recall but my VIN isn’t registered on the site for recall on carfax it shows a pattern of the previous owners being car in for maintenance and engine issues but engine never being replace under recall

Filed Mar 31, 2026 · Engine · GA

On March 18, 2026 I brought my vehicle to AutoNation Hyundai for an oil change and full diagnostic. Your dealership’s own diagnostic report showed no knock sensor code, no engine issues, and no active warning lights. My car was fully drivable when I dropped it off. Within 30 minutes of picking my vehicle up, the check engine light began blinking and the car became completely undrivable. It has not moved since March 20, 2026 at the dealership. The dealership did an additional diagnostic and found a knock sensor that was not there during the first diagnostics and have stated that my engine has too many miles to be covered uder warranty.

Filed Mar 25, 2026 · Engine · MD

The vehicle suddenly stopped and died while driving. The mechanic confirms that the engine is gone, contact Hyundai. Ourisman of Rockville and Hyundai Motor America (HMA) refuses to replace the engine for free. The vehicle has now developed a severe engine knock consistent with the well-documented defect affecting Hyundai’s Theta II engines. Hyundai has publicly acknowledged this issue and issued a major recall covering approximately 470,000 vehicles with the following specifications: • Model Years: 2011–2012 • Engines: 2.0L and 2.4L • Manufacturing Period: December 11, 2009 – April 12, 2012 Hyundai and federal regulators identified the safety concern as manufacturing debris that could restrict oil flow to rod bearings. This defect can lead to engine knocking and eventual engine failure. Critically, Hyundai has acknowledged that engine failure may stall the vehicle while driving, significantly increasing the risk of a crash. Hyundai’s official remedy for this defect required dealerships to: • Inspect engines for bearing noise • Replace the engine if necessary • Honor Hyundai’s extended engine warranty of 10 years / 120,000 miles for affected vehicles. This issue has also been the subject of significant litigation, including the class action lawsuit Case No. [XXX], filed January 23, 2018, against Hyundai Motor America (HMA), Kia Motors America, Inc. (KMA), Hyundai Motor Company (HMC), and Kia Motors Corporation (KMC). Despite these well-known issues, Ourisman of Rockville failed to disclose any of the following when selling my daughter's this vehicle: 1. The widespread engine defects associated with the 2011 Hyundai Sonata. 2. The recall and safety concerns related to debris restricting oil flow to rod bearings. 3. The extended Hyundai engine warranty covering affected vehicles up to 120,000 miles. This omission is particularly concerning because this defect presents a serious safety hazard and a clear and present danger. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.

Filed Jan 26, 2026 · Engine · NY

My Hyundai Sonata has encounter two failing cylinders (compression loss) due to scoring. When driving in the highway I got engine shudder and loss of power (speed) that could have put me in dangerous driving condition, accident or other. These GDI engines are notorious for poor oil circulation due to faulty designed piston rings. Hyundai has long history with these poorly manufactured engines and class action lawsuits. I notified Hyundai but they are not willing to remedy the situation. I have worked with local dealership Miller Hyundai, as well as corporate. All I get are excuses and that I’m not covered. These engines are completely problematic with oil consumption and oil blow by, causing seizing, rod bearing failure, carbon buildup, cylinder damage, etc. The info on the internet over customers and these GDI engines is overwhelming. Oil related Fires are another issue as well. Hyundai needs more accountability than the class action for rod baring failures. Because of the damage to my pistons, I could have gotten in accident with loss of power on highway…full due to poor piston rings, damage from improper oil flow and near complete engine failure.

Filed Jan 22, 2026 · Engine, Steering · 138,000 miles · NC

The contact owns a 2011 Hyundai Sonata. The contact stated that while driving approximately 65 - 70 MPH, there was a grinding sensation coming from the front wheels, and the grinding sensation was felt in the steering wheel. The vehicle was taken to the dealer, who diagnosed that the rod bearings and hubs had failed, causing the grinding sound. The contact was informed that the rod bearings and hubs needed to be replaced. The vehicle was towed to a certified mechanic, and the vehicle was repaired. The contact stated that while driving at various speeds the following day, there was a loud grinding sound coming from the vehicle. The sound also occurred while the vehicle was parked. While attempting to accelerate from 25 - 35 MPH, the engine started knocking, and the vehicle clunked and jerked. The vehicle decelerated, and the contact pulled over to the side of the road. The contact became aware that the accelerator pedal was not operating as needed. While on the side of the road, the contact turned off the vehicle and attempted to restart the vehicle; however, the vehicle failed to restart. The vehicle was towed to a certified mechanic, who diagnosed that the engine had failed, and the mechanic recommended the engine replacement. The vehicle was not repaired. The vehicle was towed to a different dealer, Capital Hyundai of Greensboro (801 E Bessemer Ave, Greensboro, NC 27405), and the contact was informed of the federal safety agency Campaign Number: 15V568000 (Engine). The vehicle was not repaired because the manufacturer stated that the maintenance history was not satisfactory enough to warrant an engine replacement. The failure mileage was approximately 138,000.

Filed Nov 25, 2025 · Engine · 137,600 miles · AR

The contact owns a 2011 Hyundai Sonata. The contact stated that while driving at an undisclosed speed and making a left turn, the vehicle experienced a loss of motive power. The contact was able to restart the vehicle; however, an abnormal knocking sound was heard, and there was smoke coming from under the hood. The contact was able to drive the vehicle to a nearby residence, where it temporarily remained. The contact attempted to drive the vehicle a few miles to qualify for towing, per the vehicle insurance provider. The vehicle was towed to a local dealer, where it was diagnosed with a rod bearing failure. The vehicle was not repaired due to insufficient engine oil maintenance records. The contact related the failure to the federal safety agency Campaign Number: 20V746000 (Engine). The manufacturer was made aware of the failure. The failure mileage was approximately 137,600.

Filed Nov 4, 2025 · Engine · TX

I am filing this complaint regarding a catastrophic engine failure in my 2011 Hyundai Sonata. According to Hyundai’s own documentation, Service Campaign 953, issued in 2018, was never performed on this vehicle. This campaign addresses the risk of connecting rod bearing failure caused by residual metal debris in the crankshaft oil passages.

Filed Oct 21, 2025 · Engine, Lights · FL

I bought this car from someone in April of 2024 and the person who i bought it from said everything was perfectly fine, they brought it to the Hyundai dealership and according to the mechanic there the engine was fine….i have taken care of the engine since i bought the car, kept up with oil changes and everything….until a few days ago when the whole thing ceased up on me while driving down the road to my sons school. I wasnt going fast either, the speed limit is 40mph where i was when it happened, but I’m glad i have quick reflexes because otherwise we would have wrecked the car. Everything shut off on me and now its knocking. There is alot of metal shavings in my oil and my mechanic tried to drain it a few times to get the debris out of the oil but it does no good.

Filed Oct 3, 2025 · Engine · 216,301 miles · TX

The contact owns a 2011 Hyundai Sonata. The contact stated that while driving at various speeds, there was an abnormal knocking sound coming from under the hood. No warning lights were illuminated. In addition, the contact stated that while attempting to start the vehicle, the engine hesitated while turning over. The vehicle was towed to a local dealer, where it was diagnosed, and determined that the long block kit and engine needed to be replaced. The contact was advised that due to the mileage and aftermarket engine in the vehicle, the recall repairs were denied. The contact related the failure to Hyundai Service Campaign: 953. The manufacturer was made aware of the failure. The failure mileage was approximately 216,301.

Filed Oct 2, 2025 · Engine, Fuel system · MD

The affected component is the engine/rod bearing (Theta II 2.4L). My 2011 Hyundai Sonata stalled and the engine locked up twice in live traffic (March 2025 and July 2025). The vehicle is available for inspection if needed. This created a serious safety risk to me and others on the road, as the stall occurred on [XXX] at highway speeds. This failure could have been catastrophic had it happened on the DC/Baltimore Beltway or another high-traffic roadway. Hyundai’s system shows Recall 132 was marked complete at very low mileage (around 32,000 miles), but my vehicle later developed oil consumption and stalling consistent with rod bearing failure. Capitol Heights Hyundai noted a warranty pre-authorization (PA) in March 2025 and told me Hyundai needed my mailing address “for the claim,” but later said it was a typo and that no record exists. The dealership charged me for a diagnostic but did not inspect the vehicle for rod bearing failure, despite symptoms consistent with Recall 132. Annapolis Hyundai, where the car was purchased as a CPO, has admitted they have no documentation that Recall 132 was ever performed (no repair order, mileage, or technician notes). Yet Hyundai’s system shows Recall 132 marked “complete.” Without proof that the KSDS software or bearing inspection was done, I belive this recall should be considered open. Hyundai Consumer Affairs has stated that I must pay for towing and diagnosis before they will investigate, with possible reimbursement later. This conflicts with federal law (49 U.S.C. § 30120), which requires recall diagnosis and repair at no cost to the consumer. Prior to the failures, my vehicle had a history of oil consumption and “no oil on dipstick” findings, which are known precursors to rod bearing failure. No warning lamps appeared before the stalls. I am requesting the federal safety agency’s assistance in requiring Hyundai to provide documentation or reopen Recall 132 and perform a no-cost inspection/repair to ensure this vehicle is safe to operate INFORMATION REDACTED PURSUANT TO THE FREEDOM OF