Going down the road driving the car lost power and went in limp mode with no warnings on the dash at all!
2021 Hyundai Sonata engine problems
35 complaints (26% of all complaints for this car). Typical mileage when it fails: 47,000. 1 crash reported.
- owner complaints
- 35
- of this car's complaints
- 26%
- typical mileage
- 47,000
- crashes
- 1
- recalls
- 0
Which part fails
Owners did not name a specific part.
At what mileage
Complaints by mileage at the time of the problem.
0k-25k
25k-50k
50k-75k
75k-100k
100k-125k
125k-150k
150k-175k
175k-200k
200k+
Hyundai Sonata engine problems in other years
Specific symptoms reported on the 2021 Hyundai Sonata engine
Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.
Related recalls
No recalls on record for this model year.
Related investigations
Loss of Motive Power
the federal safety agency received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitionersâ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODIâs evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to the federal safety agency which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. Â There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in the federal safety agency's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, the federal safety agency does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing the federal safety agencyâs reasons for denial of the petition will be published. The reference numbers for the complaints to the federal safety agency cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to
DP22003
What 2021 Hyundai Sonata owners say
Most recent owner complaints, unedited.
At approximately 130,000 miles, vehicle developed and internal coolant leak caused by a failed Exhaust Heat Recovery System (EHRS) in the center muffler assembly, matching TSB 23-EM-009H - a known manufacturing defect documented by Hyundai. Coolant has been slowly leaking internally into the exhaust system. The authorized Hyundai dealership initially failed to diagnose the internal leak and told me there was no leak and wanted to send me home. After pushing back, the internal leak was confirmed. If not caught, this defect could result in engine overheating or complete engine failure without warning. Hyundai Motor America has denied goodwill coverage despite this being a documented manufacturing defect.
The car will idle high around 1200 rpms. The car will most of the times fix the issue when you turn the car off and back on but it will start again after driving. This is a known issue with the car. I have had the egr valve replaced since it will pop up the codes P240F and P049 for egr slow response and control position exceeded learning limit but the problem came back within two days. I did find a forum that deals with the joint connector repair but this needs to be a recall as I have come across many people who have this problem and paying out of pocket to fix it.
The contact owns a 2021 Hyundai Sonata. The contact stated while driving at an undisclosed speed, the engine shuddered and the engine stalled. In addition, the engine seized. No warning lights were illuminated. The contact stated that the vehicle was seized in the middle of the road. The contact stated that while attempting to start the vehicle, the vehicle started. The failure reoccurred. The vehicle was towed to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 140,000.
The Exhaust Heat Recovery System (EHRS) has failed for the second time on this vehicle. The first failure occurred at approximately 35,000 miles and was repaired under Hyundai Technical Service Bulletin 23-EM-009H, which Hyundai issued to address this exact defect across 2020-2023 Sonata Hybrid models. The vehicle has now reached 71,000 miles and is experiencing the identical symptoms: coolant loss, overheating, and white exhaust smoke. The EHRS shares a coolant loop with the hybrid battery thermal management system. Coolant loss from this failure puts the hybrid battery and power electronics at risk of overheating, creating a potential fire and safety hazard. The recurring nature of this failure following an official TSB repair suggests the root cause has not been adequately addressed by Hyundai's current repair protocol.
The internal core of the Exhaust Heat Recovery System (EHRS), part of the center muffler/front pipe assembly (#28600-L5210), suffered a catastrophic failure. This allowed approximately 9 gallons of engine coolant to leak directly into the hot exhaust stream. Safety Risk: This failure creates a severe visibility hazard. During acceleration from stop lights and stop signs, the vehicle emits massive, thick clouds of white glycol smoke. The smoke is so dense that it completely obscures the driver's view of trailing vehicles and prevents following drivers from seeing the roadway or my vehicle's brake lights, creating a high risk of rear-end collisions. Additionally, the rapid loss of coolant caused the engine to overheat and lose power while in motion, nearly causing a stall in active traffic. Confirmation: The failure was confirmed by the service department at Washington Hyundai (Invoice #174281). This is the second failure of this specific component (previously failed in Jan 2025). The manufacturer issued TSB 23-EM-009H for this defect, acknowledging it affects 2020-2023 Sonata Hybrids, but no safety recall has been issued. Symptoms: The issue was preceded by a "sweet" burning smell and a sudden "Engine Overheating" warning on the dashboard. The failed component has been replaced by the dealer, but the manufacturer refused to replace the coolant-poisoned Oxygen (O2) sensors, leaving the vehicle in a technically compromised state. The failed unit is likely held by the dealer for warranty parts return.
Hyundai technical service bulletin 23-EM-009H (EHRS COOLANT LEAK) - AKA a faulty heat exchange that causes the coolant to leak into the exhaust and burn away. Resulting in a very hard to diagnose coolant disappearance. This should be a recall. They have literally already acknowledged a manufacturer defect with the service bulletin. The problem is that in most cases, it occurs out of the 60k or 100k warranty. The dealer seems to have discretion as to which of the mileage limits apply. One dealer in NC told me 60k and my local in SC told me 100k. My problem started at ~90k, but was just topped off on fluid and repaired as "normal evaporation". Now 12k later at 102k, they acknowledged the TSB but claimed I was out of warranty. With me being out of warranty, they claimed that Hyundai would not send them tsb parts and that I would need to replace the whole system with the normal skus around $3k.
P0471 code before 55k miles even after repair is made
On i believe 1/14/26, my check engine light came on. Scheduled appt.for 1/16/26 for diagnostic. Several things were wrong. I decided to come back due to not having the money at the time. Over the wked, I remembered a recall notice i received around November that I asked about in November during my oil change & was told the parts aren't in & they'd give me a call. Upon viewing the recall it seemed some things I was told on 1/16/26 could be a result of the recall. I called my service person Linda on 1/20/26, she spoke to her supervisor & they informed me some of the issues seem to stem from the recall. Linda gave me the manufacturer recall contact information. I contacted them on 1/20/26. She explained there was indeed a recall, there wasn't a remedy yet, it was safe to drive & if something changes, to call back. On 1/28/26 around 5:30am I left home for work & my car all of a sudden experienced a loss of power. It wouldn't go past 30mph. I returned back home & called out of work. I called the manufacturer recall & informed them. She made an appt. to take my car in the follow day, 1/29/26. I decided to drop it off that same day, 1/28/26. I had someone follow me being i could only go 30mph on a flat road & 10mph on a slight hill. I found out my service person Linda was no longer employeed there. I spoke with another employee. He said they would have to do another diagnostic. I left my car. I called the dealership on 1/29/26 for an update, they had not looked at my car. I called the manufacturer recall, they assigned a case manger to my case. Jay from the NCA, called me on 1/30/26 I believe. We've communicated several times without me receiving a adequate update. He's saying the issue seems to be steamed from the recall, there is now remedy yet, & they are still investigating. I've been without a car since 1/28/26, still making payments, missing work, haven't been offered a loaner & have no idea when or if I will get my car back.
The EHRS coolant system failed and had a leak causing the coolant to be excessively burned off as thick white smoke. This caused me to not be able to see anything behind me and forced others to stop or slow down dramatically to avoid colliding with me. I had my engine overheat and force me to pull over on the side of an unsafe road because the exhaust system burned off my entire tank of coolant in less than a mile. I have taken this to a Hyundai dealership and they confirmed it was the EHRS system failure and told me it was a fairly known issue with the 2020-2023 Sonata Hybrids. I was told that even if I get it replaced the possibility of having it happen again are pretty high. This seems extremely unsafe to myself and others.
Questions about the 2021 Hyundai Sonata engine
Does the 2021 Hyundai Sonata have engine problems?
Owners have filed 35 complaints about the engine of the 2021 Hyundai Sonata, 26% of all its complaints, more than any other problem.
At what mileage do 2021 Hyundai Sonata engine problems start?
The typical (median) mileage in owner complaints is 47,000 miles.
Was there a recall on the 2021 Hyundai Sonata engine?
There is no recall for this problem on this model year.
What year does the Hyundai Sonata have bad engine?
The Hyundai Sonata model years with the most engine complaints are 2011 (1,012 complaints), 2013 (776 complaints) and 2015 (650 complaints).
Other 2021 Hyundai Sonata problems
Fuel system 34Transmission 25Electrical 18Visibility 12Driver assistance 10Airbags 4Body 4Brakes 4Acceleration 2Seat belts 2Seats 2Steering 2Suspension 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 2021 Hyundai Sonata?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history