2021 Hyundai Sonata: engine overheating

Filed Jun 24, 2026 · Engine, Fuel system · SC

At approximately 130,000 miles, vehicle developed and internal coolant leak caused by a failed Exhaust Heat Recovery System (EHRS) in the center muffler assembly, matching TSB 23-EM-009H - a known manufacturing defect documented by Hyundai. Coolant has been slowly leaking internally into the exhaust system. The authorized Hyundai dealership initially failed to diagnose the internal leak and told me there was no leak and wanted to send me home. After pushing back, the internal leak was confirmed. If not caught, this defect could result in engine overheating or complete engine failure without warning. Hyundai Motor America has denied goodwill coverage despite this being a documented manufacturing defect.

Filed Apr 14, 2026 · Engine · AL

The Exhaust Heat Recovery System (EHRS) has failed for the second time on this vehicle. The first failure occurred at approximately 35,000 miles and was repaired under Hyundai Technical Service Bulletin 23-EM-009H, which Hyundai issued to address this exact defect across 2020-2023 Sonata Hybrid models. The vehicle has now reached 71,000 miles and is experiencing the identical symptoms: coolant loss, overheating, and white exhaust smoke. The EHRS shares a coolant loop with the hybrid battery thermal management system. Coolant loss from this failure puts the hybrid battery and power electronics at risk of overheating, creating a potential fire and safety hazard. The recurring nature of this failure following an official TSB repair suggests the root cause has not been adequately addressed by Hyundai's current repair protocol.

Filed Mar 26, 2026 · Engine, Fuel system · PA

The internal core of the Exhaust Heat Recovery System (EHRS), part of the center muffler/front pipe assembly (#28600-L5210), suffered a catastrophic failure. This allowed approximately 9 gallons of engine coolant to leak directly into the hot exhaust stream. Safety Risk: This failure creates a severe visibility hazard. During acceleration from stop lights and stop signs, the vehicle emits massive, thick clouds of white glycol smoke. The smoke is so dense that it completely obscures the driver's view of trailing vehicles and prevents following drivers from seeing the roadway or my vehicle's brake lights, creating a high risk of rear-end collisions. Additionally, the rapid loss of coolant caused the engine to overheat and lose power while in motion, nearly causing a stall in active traffic. Confirmation: The failure was confirmed by the service department at Washington Hyundai (Invoice #174281). This is the second failure of this specific component (previously failed in Jan 2025). The manufacturer issued TSB 23-EM-009H for this defect, acknowledging it affects 2020-2023 Sonata Hybrids, but no safety recall has been issued. Symptoms: The issue was preceded by a "sweet" burning smell and a sudden "Engine Overheating" warning on the dashboard. The failed component has been replaced by the dealer, but the manufacturer refused to replace the coolant-poisoned Oxygen (O2) sensors, leaving the vehicle in a technically compromised state. The failed unit is likely held by the dealer for warranty parts return.

Filed Mar 17, 2026 · Engine · SC

Hyundai technical service bulletin 23-EM-009H (EHRS COOLANT LEAK) - AKA a faulty heat exchange that causes the coolant to leak into the exhaust and burn away. Resulting in a very hard to diagnose coolant disappearance. This should be a recall. They have literally already acknowledged a manufacturer defect with the service bulletin. The problem is that in most cases, it occurs out of the 60k or 100k warranty. The dealer seems to have discretion as to which of the mileage limits apply. One dealer in NC told me 60k and my local in SC told me 100k. My problem started at ~90k, but was just topped off on fluid and repaired as "normal evaporation". Now 12k later at 102k, they acknowledged the TSB but claimed I was out of warranty. With me being out of warranty, they claimed that Hyundai would not send them tsb parts and that I would need to replace the whole system with the normal skus around $3k.

Filed Feb 20, 2026 · Engine, Visibility · FL

The EHRS coolant system failed and had a leak causing the coolant to be excessively burned off as thick white smoke. This caused me to not be able to see anything behind me and forced others to stop or slow down dramatically to avoid colliding with me. I had my engine overheat and force me to pull over on the side of an unsafe road because the exhaust system burned off my entire tank of coolant in less than a mile. I have taken this to a Hyundai dealership and they confirmed it was the EHRS system failure and told me it was a fairly known issue with the 2020-2023 Sonata Hybrids. I was told that even if I get it replaced the possibility of having it happen again are pretty high. This seems extremely unsafe to myself and others.

Filed Jun 13, 2023 · Engine · VA

The issue is well known across the DN8 platform, hundreds if not thousands of people have this problem.Car and driver even did an article on a car with this same 2.5L turbo DCT engine having the same problem! The problem is the ITMS or thermostat housing unit. I first experienced this getting on to a highway, I lost all acceleration, the turbo dropped to 0 pSI and I received an engine overheating warning on the dash. After pulling over the car resumed normal driving, but with oil temps running 30-40 degrees higher than normal. Since then, I have had loss of boost and acceleration when passing around cars which has almost caused accidents, oil temps constantly running very high and fans constantly running on full blast even after car is off. I have been to the service center 4 times, and they have failed to "replicate" the issue and stated the fan and oil problem is "normal" which it is not. This problem needs to be addressed before somebody gets seriously hurt due to loss of power unexpectedly while driving. PLEASE help! Thank you for your time.