2021 Hyundai Sonata: sudden loss of power

Filed Aug 1, 2026 · Engine, Transmission · LA

Going down the road driving the car lost power and went in limp mode with no warnings on the dash at all!

Filed Mar 26, 2026 · Engine, Fuel system · PA

The internal core of the Exhaust Heat Recovery System (EHRS), part of the center muffler/front pipe assembly (#28600-L5210), suffered a catastrophic failure. This allowed approximately 9 gallons of engine coolant to leak directly into the hot exhaust stream. Safety Risk: This failure creates a severe visibility hazard. During acceleration from stop lights and stop signs, the vehicle emits massive, thick clouds of white glycol smoke. The smoke is so dense that it completely obscures the driver's view of trailing vehicles and prevents following drivers from seeing the roadway or my vehicle's brake lights, creating a high risk of rear-end collisions. Additionally, the rapid loss of coolant caused the engine to overheat and lose power while in motion, nearly causing a stall in active traffic. Confirmation: The failure was confirmed by the service department at Washington Hyundai (Invoice #174281). This is the second failure of this specific component (previously failed in Jan 2025). The manufacturer issued TSB 23-EM-009H for this defect, acknowledging it affects 2020-2023 Sonata Hybrids, but no safety recall has been issued. Symptoms: The issue was preceded by a "sweet" burning smell and a sudden "Engine Overheating" warning on the dashboard. The failed component has been replaced by the dealer, but the manufacturer refused to replace the coolant-poisoned Oxygen (O2) sensors, leaving the vehicle in a technically compromised state. The failed unit is likely held by the dealer for warranty parts return.

Filed Feb 22, 2026 · Engine, Fuel system · GA

On i believe 1/14/26, my check engine light came on. Scheduled appt.for 1/16/26 for diagnostic. Several things were wrong. I decided to come back due to not having the money at the time. Over the wked, I remembered a recall notice i received around November that I asked about in November during my oil change & was told the parts aren't in & they'd give me a call. Upon viewing the recall it seemed some things I was told on 1/16/26 could be a result of the recall. I called my service person Linda on 1/20/26, she spoke to her supervisor & they informed me some of the issues seem to stem from the recall. Linda gave me the manufacturer recall contact information. I contacted them on 1/20/26. She explained there was indeed a recall, there wasn't a remedy yet, it was safe to drive & if something changes, to call back. On 1/28/26 around 5:30am I left home for work & my car all of a sudden experienced a loss of power. It wouldn't go past 30mph. I returned back home & called out of work. I called the manufacturer recall & informed them. She made an appt. to take my car in the follow day, 1/29/26. I decided to drop it off that same day, 1/28/26. I had someone follow me being i could only go 30mph on a flat road & 10mph on a slight hill. I found out my service person Linda was no longer employeed there. I spoke with another employee. He said they would have to do another diagnostic. I left my car. I called the dealership on 1/29/26 for an update, they had not looked at my car. I called the manufacturer recall, they assigned a case manger to my case. Jay from the NCA, called me on 1/30/26 I believe. We've communicated several times without me receiving a adequate update. He's saying the issue seems to be steamed from the recall, there is now remedy yet, & they are still investigating. I've been without a car since 1/28/26, still making payments, missing work, haven't been offered a loaner & have no idea when or if I will get my car back.

Filed Jan 15, 2026 · CO

Component or system involved and availability for inspection: The issue involves the transmission / drivetrain system. When I entered my VIN on Hyundai’s official dealership website, a safety recall related to the transmission appeared. I took a screenshot of this recall. When I later contacted Hyundai Motor America and spoke with my assigned case manager, I was told that no such recall existed for my VIN. A few days after that call, the recall no longer appeared when checking the VIN online. The vehicle is available for inspection upon request. How safety was put at risk: A transmission-related safety recall presents a risk of loss of power, inability to accelerate, or sudden mechanical failure, which could increase the risk of a crash, especially during normal driving conditions such as merging, accelerating, or driving at highway speeds. The uncertainty and inconsistency regarding whether a safety recall applies to my vehicle has put my safety and the safety of others at risk. Confirmation by dealer or service center: The problem has not been repaired by a dealer, as Hyundai denied that a recall existed despite it previously appearing under my VIN on their official website. Independent service centers that recently serviced the vehicle did not identify or report any transmission warnings or failures. Inspection by manufacturer or others: The vehicle has not been physically inspected by Hyundai for this recall issue. My only interaction with the manufacturer was a phone call + email with a Hyundai case manager, who stated that no recall applied to my VIN. Warning lamps, messages, or prior symptoms: There were no warning lights, messages, or symptoms prior to this issue. The vehicle recently received routine maintenance, including an oil change, tire balancing, and tire rotation, and none of the service providers reported any problems or concerns related to the transmission or overall vehicle condition. I am 34 weeks pregnant with no way to the hospital.

Filed Oct 27, 2025 · Transmission · 35,000 miles · CA

The contact owns a 2021 Hyundai Sonata. The contact stated that while driving at 30 MPH and depressing the accelerator pedal, the vehicle failed to respond and lost power. The vehicle was coasted over to the right side of the road, turned off, restarted, and returned to normal functionality. An independent mechanic was contacted. The vehicle was taken to an independent mechanic to be diagnosed; however, the diagnosis was unknown. The vehicle was not repaired. The contact related the failure to the federal safety agency Campaign Number: 22V746000 (POWER TRAIN); however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was 35,000.

Filed Dec 4, 2024 · Electrical, Engine · NJ

This car has two problems. 2 weeks I was driving on the highway. All the sudden the shutoff and lost all power on the car. Thank god I pulled to the side of the road safely. Turned the car off and turned it back on. The car started to run normal. I took it to mechanic. They scanned the car with their computer. Said the car has no problems. Tested the battery and all other components. No problems found. This happened again yesterday on the highway driving. Car engine shuts off again. The car has engine problems as well. But Hyundai denies to address it.

Filed Apr 25, 2024 · Acceleration, Transmission · TX

Vehicle began to lose power while on highway. The loss of power occurred for a few seconds, then came back. Shortly after, the RPM began changing uncontrollably. Tried shifting to manual control using paddle shifters and was able to maintain steady RPM until vehicle software switched back to automatic and RPM swung crazy again. Endangered other vehicles on road due to loss of power and fluctuations of transmission. Once parked, vehicle did not change to neutral, drive, reverse. Both manufacturer and insurance are/have reviewed vehicle and are working on a fix. No warning lights. Only indication was minor loss of power prior to incident. Loss of power was not considerable nor for a prolonged period of time.

Filed Dec 9, 2023 · Engine · TX

I was on the highway going 60 mph then all of a sudden my vehicles rpm's jumped way up to 8 and completely lost power was on I-45 in Conroe thankfully I was in the slow lane. I have attached pictures of my dash so I could get proof this time. I had to wait 7 minutes for the car to do anything. It also burned all of my engine oil. So had to buy oil for my vehicle. I just had my oil change 3 weeks ago. This has happened before on on the frontage road a few months ago. I have claims open with Hyundai Customer Care. I have been stating that my engine makes a clicking noise, it hesitates, and seizes all the time. I have had this problem since March of 2021 and I bought the car in January 2021. I know I am not a part of the engine recall but I should be. I am scared to drive it. Hyundai doesn't care one bit. Well enough is enough I will be getting rid of this death trap. If you are looking at Hyundai's don't waste your time or money.

Filed Jun 13, 2023 · Engine · VA

The issue is well known across the DN8 platform, hundreds if not thousands of people have this problem.Car and driver even did an article on a car with this same 2.5L turbo DCT engine having the same problem! The problem is the ITMS or thermostat housing unit. I first experienced this getting on to a highway, I lost all acceleration, the turbo dropped to 0 pSI and I received an engine overheating warning on the dash. After pulling over the car resumed normal driving, but with oil temps running 30-40 degrees higher than normal. Since then, I have had loss of boost and acceleration when passing around cars which has almost caused accidents, oil temps constantly running very high and fans constantly running on full blast even after car is off. I have been to the service center 4 times, and they have failed to "replicate" the issue and stated the fan and oil problem is "normal" which it is not. This problem needs to be addressed before somebody gets seriously hurt due to loss of power unexpectedly while driving. PLEASE help! Thank you for your time.

Filed Jun 8, 2023 · Engine, Fuel system · TN

When attempting to pass other vehicles or under quick acceleration such as an on ramp to the highway, the vehicle will experience a sudden loss of power and oil pressure resulting in a fail safe mode which limits your acceleration and causes a sudden decrease in speed and velocity. The issue results in the oil pressure light illuminating and requires the vehicle to be stopped and completely turned off to reset then once turned back on, the problem is “gone” until a sudden acceleration occurs again, which results in the same issue happening. There is a current recall out for similar models but my vin is not listed. I have approximately 50k miles on the car, and am the first owner.

Filed Mar 14, 2023 · Electrical, Steering · NY

After 9 months of ownership, on at least five (5) instances, the car has the following things happen at the same time: 1) all warning lights on the dashboard activate, 2) the battery discharge warning light activates, a loss of power steering, no speedometer, no cameras (rear or front), no AC, and all the safety functions are disabled including but not limited to: Forward Collision Warning, Parking Collision Warning, Automatic Emergency Braking, Lane Departure Warning, Rear Cross Traffic Warning. Yes, the car is available for inspection upon request. Safety is at risk by the loss of power steering and the deactivation of all safety functions. After each instance, the car has gone back to the manufacturer's dealer for inspection, they believed it might be an electrical issue after scanning for fault codes, but after 5 times, the dealer has not yet diagnosed the issue.