The rear passenger control arm broke off of the subframe due to severe corrosion despite Hyundai applying a corrosion preventative under recall 17-01-013 on 12/1/2015. During all service work following the preventative in 2015, corrosion was never brought up as a concern by the dealership (we have all service records since date of initial purchase). Thankfully we had just reached our destination and were parking the car when the failure happened. Had the part failed 5 minutes earlier, we would have been on the highway at over 60mph and could have been seriously injured or worse. We had our Tucson towed to the dealership for repair as well as additional recall work under Campaign 952 for corrosion of the fuel band. We were contacted by the dealership on 8/22/24 and told that the new subframe could not be installed as the corrosion was so severe, the body mounts had also corroded away so there was nothing to attach the new subframe to. The dealership advised us that our Tucson is now totaled and it is SOLELY due to corrosion that Hyundai has been aware of and has been subject to multiple class action lawsuits over it. This is absolutely unacceptable. This car is still in perfect mechanical condition and the exterior has absolutely ZERO rust but now it can no longer be driven due to Hyundai’s shoddy subframes.
The worst 2007 Hyundai Tucson problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Airbags13
- Engine9
- Body8
- Suspension8
- Brakes7
- Transmission6
- Lights5
- Acceleration4
- Electrical4
- Steering4
- Driver assistance3
- Fuel system2
- Seat belts2
- Seats2
- Visibility2
- Tires1
Specific symptoms reported on the 2007 Hyundai Tucson
Recalls 5
Exterior lighting: brake lights: switch
- What is wrong
- Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz, 2009-2011 Genesis, 2010-2011 Genesis Coupe, 2007-2008 Entourage, and 2006-2008 Tiburon vehicles. Originally, in April 2013, Hyundai recalled 1,059,824 model year 2007-2009 Accent and Tucson, model year 2007-2010 Elantra, model year 2007-2011 Santa Fe, model year 2008-2009 Veracruz, model year 2010-2011 Genesis Coupe, and model year 2011 Sonata vehicles. In September 2013, Hyundai informed the agency that it was adding more vehicles to this campaign, representing an additional 652,512 units. The total number of vehicles being recalled is now 1,712,336. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake transmission shift interlock feature, preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.
- Risk
- Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of Park without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.
- Remedy
- Hyundai will notify owners, and dealers will replace the stop lamp switch, free of charge. The safety recall began on April 22, 2013. Owners may contact Hyundai at 1‑800‑633‑5151. Hyundai's recall campaign number is 110.
Recall number 13V113000 · Recall details
Exterior lighting
- What is wrong
- Hyundai is recalling 3,011 model year 2005-2007 elantra, tucson, sonata, azera and accent vehicles. A malfunctioning stop lamp switch may cause the brake lights to fail to illuminate when the brake pedal is depressed or may cause the brake lights to remain illuminated when the brake pedal is released. A defective stop lamp switch may also affect the operation of the brake-transmission shift interlock feature so the transmission would not be able to be shift out of the "park" position. It may also cause the electronic stability control (ESC) malfunction light to illuminate, and it may not deactivate the cruise control when the brake pedal is depressed.
- Risk
- Any of these malfunctions could lead to a crash.
- Remedy
- Dealers will replace the stop lamp switch free of charge. The recall began on september 2, 2009. Owners may contact hyundai of puerto rico customer service at 1‑787‑999‑4310.
Recall number 09V280000 · Recall details
Exterior lighting: brake lights: switch
- What is wrong
- Hyundai is recalling 532,633 my 2006-2007 accent, entourage, sonata, my 2007 azera, elantra and santa fe, my 2005-2007 tucson and my 2007-2008 veracruz vehicles. The stop lamp switch in the affected vehicles may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause the brake lights to remain illuminated when the brake pedal is released. A stop lamp switch malfunction may also affect the operation of the brake-transmission shift interlock feature so the transmission shifter would not be able to be shifted out of the park position. It may also cause the electronic stability control (ESC) malfunction light to illuminate, and it may not deactivate the cruise control when the brake pedal is depressed.
- Risk
- Any of these malfunctions, alone or in combination, may lead to a crash.
- Remedy
- Dealers will replace the stop lamp switch free of charge. The recall began on june 29, 2009. Owners may contact the hyundai customer assistance center at 1‑800‑633‑5151.
Recall number 09V122000 · Recall details
Air bags: frontal: driver side: inflator module
- What is wrong
- On certain vehicles, static air bag deployment testing conducted by the federal safety agency using fifth percentile female dummies indicated that a small stature adult driver not wearing a seat belt and involved in a frontal or near frontal crash, the deployment of the driver air bag may not occur.
- Risk
- This can cause increased risk of injury to the driver under certain crash conditions.
- Remedy
- Dealers will replace the driver air bag module with one that is designed to provide an increased margin of compliance for low risk deployment for small stature adults who are not properly wearing the seat belts. The recall began on september 6, 2007, and will be performed in two mailings. Owners may contact hyundai de puerto rico at 1‑800‑981‑0188.
Recall number 07V197000 · Recall details
Air bags: frontal: driver side: inflator module
- What is wrong
- On certain sport utility vehicles, during static air bag deployment testing conducted by the federal safety agency using fifth percentile female dummies indicated if a small statured adult driver, not wearing a seat belt, is involved in a frontal or near frontal crash, deployment of the driver air bag may result in an insufficient margin of compliance as measured by the test dummy used in the federal safety agency test.
- Risk
- This can cause increased risk of injury to the driver under certain crash conditions.
- Remedy
- Dealers will replace the driver air bag module. The recall began on january 29, 2007, and will be conducted through six mailings. Owners may contact hyundai at 1‑800‑633‑5151.
Recall number 06V445000 · Recall details
See all 5 recalls for the 2007 Hyundai Tucson
Defect investigations
Stop lamp switch failure
By letter dated april 15, 2009, hyundai notified the agency that it will conduct a safety recall (the federal safety agency recall number 09v122) to replace the stop lamp switches on many of its model year 2005-2008 vehicles.see recall 09v122 for a complete list. The agency opened its investigation based on five complaints of stop lamp failure across several 2007 hyundai models. The agency also received early warning (ewr) reports on this issue.most of those failures were traced to the improper operation of the stop lamp switch that controls stop lamp illumination.a malfunctioning stop lamp switch can cause the vehicle's brake lights not to light during braking, or alternatively, it can cause the brake lights to stay lit even when a driver takes the foot off the brake pedal. Failure of the stop lamps to illuminate properly creates the hazard of rear end collisions when drivers following the subject vehicle do not recognize that the vehicle is slowing or stopping. Hyundai reported one crash incident (a frontal impact), without injury, that was alleged to have been caused by this defect.the agency reviewed the incident and cannot conclude that it is related to this defect. There are other potential problems related to failure of the stop lamp switch: failure of the cruise control to disengage, interference with proper functioning of antilock brakes and electronic stability control, and inability to move the gear shift lever out of park position.based on the above safety recall, this investigation is closed.
PE09003
Technical service bulletins for the 2007 Hyundai Tucson 45
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Some Hyundai vehicles may be equipped with a parking distance warning (PDW) sensor(s) that may trigger...
- Higher-than-expected engine oil consumption
- Higher-than-expected engine oil consumption
- The federal safety agency has issued an urgent safety advisory regarding dangerous, counterfeit...
- The federal safety agency has identified the presence of substandard and dangerous driver’s-side airbag...
- This bulletin provides information regarding condensation related to the accumulated moisture in the...
- This bulletin contains information about the proper removal of the windshield wiper blade protective cover...
- This bulletin provides important checkpoint guidelines when performing engine oil and filter change services.
- Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships
- Follow the guidelines outlined in
2007 Hyundai Tucson fuel economy
Official EPA estimates in miles per gallon (MPGe for electric). Ranges cover trims that share the same engine.
| Engine | Drive | City | Highway | Combined |
|---|---|---|---|---|
| 2.0L 4‑cyl | FWD | 19-20 | 25 | 22 |
| 2.0L 4‑cyl | 4WD | 19 | 24 | 21 |
| 2.7L 6‑cyl | FWD | 18 | 24 | 20 |
| 2.7L 6‑cyl | 4WD | 17 | 23 | 19 |
What 2007 Hyundai Tucson owners say
Most recent owner complaints, unedited.
Check engine light came on. Had Advanced Auto check and informed it's an airbag module and I've not struck anything
PLEASE include my car in recall “CAMP113” see photo! The rear crossmember steel is doing exactly what your recall is for!! Please HELP BEFORE I DIE!
The contact's daughter owned a 2007 Hyundai Tucson. The contact stated that while her daughter was driving at approximately 45–50 MPH, she rear-ended another vehicle. The seat belt did not restrain the daughter in the seat, causing her chest to strike the steering wheel and her head to strike the front windshield. Additionally, the air bags did not deploy upon impact. The daughter received medical attention for a fractured sternum and bruising of the lungs. A police report was filed. The vehicle was towed to a tow yard and was not yet deemed totaled by the insurance company. The manufacturer was made aware of the failure and informed the contact that the failure was caused by excessive force upon braking. The failure mileage was approximately 170,000. The VIN was unavailable.
The contact owns a 2007 Hyundai Tucson. The contact stated while driving approximately 45 mph when the contact noticed smoke coming from the front driver's side brakes. The contact was able to pull over and had the vehicle towed to the contact's residence. The contact stated no warning lights were illuminated. The vehicle was not taken to a local dealer. The manufacturer was informed of failure and told the contact that their VIN was not included in a recall. The failure mileage was approximately 175,000.
Rear subframe has excessive corrosion which lead to a a lower control arm failure. In short the control arm bracket on the subframe rusted away and the control arm fell off. My wife could have been killed. It seems that this same issue pertains to several Tuscons. Car is sitting on transport trailer currently.
Took my car to get inspected and would not pass inspection due to rust underneath the vehicle salt corrosion. Was advised that engine was going to fall out. Took my vehicle to Hyuandai dealer for a gas tank recall which they fixed about a month ago and are now denying claims to fix the rust-which the whole car underneath is rusting. Hyundai bowser has rust issues with their vehicles and recalls. Hyundai Bowser PA-51 and Lewis Run Road, Pittsburgh, PA 15236 412‑469‑2100. My car was at Bowser Dealership on 05/19/2021 and Tina case manger called 06/07/2021 they denied to fix rust salt corrosion on vehicle.
Tl* the contact owns a 2007 hyundai tucson. The contact stated that while having a routine vehicle check-up by an independent mechanic, the technician informed the contact that the transmission main seal was leaking. The vehicle was test driven and the technician indicated that the transmission needed to be replaced due to the main seal leak. The transmission was replaced. The failure recurred. Additionally, the heater failed to engage properly. Johnny londoff chevrolet (1375 dunn rd, florissant, mo 63031, (314) 227-1437) was contacted and informed of the failure. The contact was then informed that the VIN was not under recall. The manufacturer was notified of the failure and informed the contact to contact the federal safety agency to file a complaint. The failure mileage was approximately 94,000.
Tl* the contact owns a 2007 hyundai tucson. The contact stated that while driving at various speeds, the vehicle stalled with several warning lights simultaneously illuminated on the instrument panel. The vehicle would restart soon after failure. The contact took the vehicle to bill dodge auto group (4 saunders way, westbrook, me 04092) where they were unable to diagnose the vehicle. The manufacturer had been notified of the failure and a case was filed. The contact had yet to hear from the manufacturer who offered no further assistance. The vehicle had yet to be repaired. The failure mileage was 199,250.
Tl* the contact owns a 2007 hyundai tucson. The contact stated that while driving at 40 MPH, she heard an abnormal rattling sound coming from the vehicle. The contact took the vehicle to an independent mechanic who discovered a hole on the rear of the subframe due to corrosion. The vehicle was towed to autonation hyundai o'hare (1509 s river rd, des plaines, il 60018) where pictures were taken of the hole in the subframe and submitted to the manufacturer for review. After the review, the manufacturer decided not to assist the contact with the repair of the vehicle due to an expired warranty. The vehicle was not repaired, and remained in the possession of the dealer. The failure mileage was 127,800.
Compare the 2007 Hyundai Tucson
Tucson vs Ford EscapeTucson vs Honda CR-VTucson vs Jeep CherokeeTucson vs Toyota RAV4Tucson vs Chevrolet EquinoxTucson vs Nissan RogueTucson vs Subaru ForesterTucson vs Kia Sportage
Other model years
2005200620072008200920102011201220132014201520162017201820192020202120222023202420252026
Questions about the 2007 Hyundai Tucson
Is the 2007 Hyundai Tucson reliable?
Owners have filed 65 complaints about the 2007 Hyundai Tucson, fewer than a typical Tucson model year.
What is the 2007 Hyundai Tucson year score?
The 2007 Hyundai Tucson scores 78 out of 100 (average). The score compares it with the other model years of the Hyundai Tucson: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2007 Hyundai Tucson?
Airbags, with 13 complaints, typically around 68,000 miles. Next is engine (9).
How many recalls does the 2007 Hyundai Tucson have?
5 recalls, covering exterior lighting and air bags.
Was there a recall on the 2007 Hyundai Tucson airbags?
Yes, 2 recalls: 07V197000, 06V445000. Check your VIN to see if your car still needs the free repair.
What year does the Hyundai Tucson have bad airbags?
The Hyundai Tucson model years with the most airbags complaints are 2006 (37 complaints), 2005 (31 complaints) and 2016 (15 complaints).
What gas mileage does the 2007 Hyundai Tucson get?
Official estimates for the 2007 Hyundai Tucson range from 19 to 22 mpg combined. The most efficient version (2.0L 4-cyl, FWD) gets 19-20 city and 25 highway.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2007 Hyundai Tucson?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history