Jaguar XF fuel smell problems

Filed Oct 26, 2026 · Fuel system · TX

My 2011 Jaguar XF 5.0L V8 developed a serious fuel leak involving a cracked flange on top of the fuel tank. The problem initially presented as a strong raw gasoline odor around the vehicle, particularly after driving. The gasoline smell was noticeable near the rear of the vehicle, eventually became apparent around the entire exterior, and entered the passenger compartment through the air-conditioning vents. Initially, the odor was more noticeable when the fuel tank was full, but it later occurred even when the tank was approximately half full. An independent mechanic inspected the vehicle and identified a cracked flange on top of the fuel tank. The mechanic confirmed that gasoline was leaking from the cracked flange and showed me visible gasoline leakage underneath the vehicle. There was no check engine light or other warning indicating a fuel system malfunction. This condition presents a serious fire hazard because gasoline is escaping from the fuel system, and gasoline vapors can enter the passenger compartment. I am concerned about the safety of the driver, passengers, and others near the vehicle. The failure appears similar to the cracked fuel tank outlet flange condition described in Jaguar safety recall J027 (the federal safety agency recall 12V‑521). On October 20, 2026, an authorized Jaguar dealership informed me in writing that the vehicle's VIN was not associated with any open safety campaigns. The dealership offered a paid diagnostic inspection but declined goodwill repair assistance. The dealership did not physically inspect the vehicle. I am requesting that the federal safety agency investigate this potentially related fuel system failure and determine whether the recall population should be reviewed. The vehicle has not been repaired and is currently being kept off the road because of the fire risk. I have obtained Jaguar Technical Bulletin J027NAS2, dated May 7, 2013, concerning Safety Recall J027 for a cracked fuel tank fuel outlet mounting flange. The bulletin identifies 2010–2012

Filed May 29, 2025 · Fuel system · 160,000 miles · TX

The contact owns a 2010 Jaguar XF. The contact stated while driving at an undisclosed speed, there was an abnormal fuel odor inside the vehicle. There was no warning light illuminated. The contact stated that the fuel odor was more evident while the A/C unit was activated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact stated that the fuel cap was replaced; however, the failure reoccurred. The manufacturer was made aware of the failure. The contact referenced the federal safety agency Campaign Number: 12V521000 (Fuel System, Gasoline); as a possible cause for the failure; however, the VIN was not included. The contact was advised to contact the federal safety agency Hotline to report the failure. The failure mileage was 160,000.

Filed Nov 28, 2022 · Fuel system · 67,614 miles · CA

The contact owns a 2011 Jaguar XF. The contact stated when the vehicle was started, there was an abnormal gasoline odor surrounding the vehicle. The contact stated that there was no gasoline odor inside the cabin of the vehicle, only outside of the vehicle. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the fuel tank flange assembly needed to be replaced. The vehicle had not been repaired. The manufacturer had been informed of the failure. The contact researched online and related the failure to the federal safety agency Campaign Number: 12V521000 (Fuel System, Gasoline) however, the VIN was not included. The failure mileage was 67,614.

Filed Aug 30, 2022 · Fuel system · GA

The contact owns a 2011 Jaguar XF. The contact stated that after parking the vehicle, an abnormally strong fuel odor was detected. Upon inspection, the contact noticed fuel leaking from the fuel tank fuel outlet flange. The dealer was made aware of the failure and scheduled an upcoming appointment. The vehicle was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The contact related the failure to the federal safety agency Campaign Number: 12V521000 (Fuel System, Gasoline) however, the VIN was not included in the recall. The failure mileage was unknown.

Filed Aug 21, 2022 · Fuel system · NM

I have read several reports of my specific model of car with a flange issue in the fuel rail system and yet my car is not apart of this recall it smells of gas and I'm sure it's regarding this same defect. I have no check engine light on my gas is being consumed at a faster rate than expected and yet I'm being told my car isn't affected which it is. This is the issue why don't you all add these vehicles to the list there are so many.

Filed Feb 9, 2022 · Fuel system · 104,000 miles · MD

The contact owns a 2010 Jaguar XF. The contact received notification of the federal safety agency Campaign Number: 20V081000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, a fuel odor was detected. The dealer and Jaguar West Columbia (12500 New Car Dr, Clarksville, MD 21029) were made aware of the failure but informed the contact that parts were not yet available. The manufacturer was not made aware of the failure. The vehicle was not repaired. The failure mileage was approximately 104,000. Parts distribution disconnect.

Filed Jan 21, 2022 · Fuel system · MS

Since purchasing this vehicle, I have noticed the smell of gasoline within the cabin of the vehicle. The smell becomes nauseating after a while. I have three small children who complain about the smell inside the cabin and I worry about their safety as well as their mother’s and mine. There have been recalls regarding this issue with this very vehicle, but for some reason mine is not included in the recall. I have called Jaguar USA and they say the vehicle’s VIN is not listed as one of the ones recalled.

Filed Sep 21, 2021 · Fuel system · 91,000 miles · TN

The contact owns a 2011 Jaguar XF. The contact stated that while driving at various speeds, an abnormally strong gasoline odor would emit throughout the vehicle with the check engine warning remaining illuminated on the instrument panel. The contact discovered that fuel was leaking from the fuel tank on the passenger’s side of the vehicle. The manufacturer was notified of the failure and informed him that the vehicle was not included in the federal safety agency Campaign Number: 12V521000 (Fuel System, Gasoline) which he linked to the failure. The contact was then instructed by the manufacturer to take the vehicle to a local dealer for an inspection; however, the contact declined. The vehicle had yet to be repaired. The failure mileage was approximately 91,000.

Filed Aug 11, 2021 · Fuel system · 140,000 miles · WA

The contact owns a 2011 Jaguar XF. The contact stated that while operating the vehicle, there was an abnormal fuel odor present inside and outside the vehicle. Upon inspection, it was discovered that fuel was leaking underneath the vehicle on the rear passenger’s side. The cause of the failure was not determined. The local dealer and manufacturer were notified of the failure. The contact was informed that the vehicle was not included in the federal safety agency campaign number: 12V521000 (Fuel System, Gasoline). The contact indicated that the vehicle had experienced the failure listed in the recall. The failure mileage was 140,000.

Filed Apr 29, 2020 · Fuel system · 78,600 miles · FL

Tl* the contact owns a 2011 jaguar xf. The contact stated that after parking and exiting the vehicle, there was an abnormal fuel odor outside of the vehicle. The vehicle was taken to alpine jaguar sales department (6606 n andrews ave, fort lauderdale, fl 33309) to be diagnosed, which was still pending. The vehicle was not repaired. The VIN was not included in the federal safety agency campaign number: 12v521000 (fuel system, gasoline). The manufacturer was notified of the failure. The approximate failure mileage was 78,600.