2023 Jeep Gladiator problems

Filed Oct 6, 2026 · OH

The interior driver's side door latch lever is experiencing extreme delamination. The "liquid chrome" silver coating has cracked and peeled away from the plastic lever. This has created a razor-sharp edge that poses an immediate safety hazard, acting like an open razor blade when trying to unlock and exit the vehicle. My wife cannot open her door without actively risking laceration to her fingers a second time. I have attached pictures. This vehicle currently has only 34,862 miles on the odometer—well under the 36,000-mile factory threshold. While I understand the 3-year calendar threshold technically lapsed on September 15, we are only 3 weeks past that date. This is an obvious material failure and a well-documented factory defect across the Gladiator/Wrangler platform, not normal wear and tear. Since the vehicle is safely under the mileage limit, missed the calendar date window by only three weeks, and the defect presents an active risk of injury, I request a Goodwill Warranty Exception to cover 100% of the replacement parts and labor at our local dealership in Mt. Orab Chrysler, Dodge, Jeep and Ram 110 Gabbard Way, Mt. Orab Ohio, OH 45154 Please review this case immediately, log it as an active cabin safety concern, and provide a corporate case number and a resolution to ensure this vehicle is safe for my wife to drive. Just to mention a few other things, you can pull the report for the VIN number for this vehicle. When we first got it, it had a fuel tank issue; next, it required replacing all the clutch plates. Now, the concern is that my wife was physically hurt. This is a well-documented manufacturing failure across the 2018–2026 Jeep Wrangler (JL) and Gladiator (JT) platform. The components regularly delaminate under normal use conditions. Despite this being a known widespread defect, no active safety recall has been issued by the manufacturer to correct the physical hazard.

Filed Sep 11, 2026 · Electrical, Visibility · FL

I believe it is the blend door actuator, the heat when on defrost automatically switched between hot to ice cold which fogs up windows and causes other issues. Brought the vehicle in for for the current recall along with service on this, and this was not looked at. When the temp changes the A/C is turned off and temp is turned up to clear the window. It starts blowing ice cold air that fogs up the window almost instantly

Filed Jun 24, 2026 · Transmission · CO

The vehicle does not have linerar acceperation. At times from a start, cold or warn engine, the vehicle will abruptly accelerate harder than the gas pedal was pressed. at light throttle, the vehicle will surge, shutter or chug. Erattic acceperation. after the engine replacement for a connecting rod bearing failure, the engine was running rough, poor mileage and stalled on a wet and cold morning (32degrees, raining). The stall happened on the deaccel lane of the interstate 25 (65 mph). THe dealership replaced one injector and said the problem was fixed. But it is not. Vehicle has not stalled, but we have not had the cold/wet weather.

Filed Jun 24, 2026 · Fuel system · CO

while completly filling the vehicle with gasoline, fuel sprays out of teh filler neck onto the vehicle and ground. This has happened many times, at reputible gas stations (Costco, Sams, walmart, Loaf and Jug). Dealership replaced original filler tube. But problem still exists. Shared video with dealership and they indicated they had no problems Castle Rock Jeep, Castle rock, COlorado

Filed Jun 24, 2026 · Brakes · CO

Parking brake would not hold vehicle on hill. When the handle was released, a metalic clinking noise was heard. Castle rock jeep dealership said all was fine. Upon my inspection, I found the parking brake cable connection under teh center console was no longer connected. The cable was reconnected, and the cable was tightened to specifications indicated my Jeep. THe vehicle had 6200 miles on it. p.s. THis was after the warranty replacement of the engine. THe dealership indicated they tested several other jeeps and they all acted as mine. No concern for safety.

Filed Jun 24, 2026 · Engine · CO

5800 miles, the engine failed due to a connecting rod failure. Chrysler replaced the engine at no cost. Oil changes were done at the year mark as the mileage limit was not reached. Dealership indicates they replace several 3.6 engines a month for warranty failures Castle Rock Jeep, Castle rock Colorado.

Filed Jun 24, 2026 · Steering · OH

The contact owns a 2023 Jeep Gladiator. The contact received notification of the federal safety agency Campaign Number: 26V363000 (Steering); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Filed Jun 15, 2026 · Electrical, Steering · FL

The vehicle suffered a catastrophic, systemic high-speed CAN C data bus loop collapse (Diagnostic Trouble Code U0002-00 "Bus Off"), resulting in an immediate, total loss of communication across almost all primary factory control modules—including the Body Control Module (BCM), Powertrain Control Module (PCM), Transmission Control Module (TCM), and ABS gateway. The vehicle is completely immobilized. This specific network data loop shares an exact architectural footprint and physical circuit link with the high-current electrical defects targeted under active, open Federal Safety Recall Campaign 21D (the federal safety agency Campaign 21V‑363) for this VIN. The franchise dealership (Jacksonville CJDR) is actively using cosmetic visual framing of secondary aftermarket accessories to avoid executing baseline electrical isolation of this factory defect. Furthermore, the facility is demanding a predatory, upfront out-of-pocket retail diagnostic fee of $1,188.15 "to start" before they will address the network crash. This extortionate pricing barrier is being used to actively block a consumer from accessing a mandatory federal safety campaign remedy on a compromised, high-risk circuit. Official factory wiTECH 2 diagnostic screenshots confirming the complete vehicle network blackout are attached to this file.

Filed Jun 9, 2026 · Suspension, Transmission · IL

Vehicle has been in the shop at 17,000 miles and had a complete transfer case, front and rear output shafts and rear Danna 44 (Max Tow) replaced in November of 2025. In June of 2025 vehicle has been in another shop for the same issues that occurred before these driveline repairs for three weeks now. Shop can not diagnose issues after three weeks. A star report has been made and Jeep is sending a technician to diagnose.

Filed May 2, 2026 · Steering, Suspension · MI

Jeep Death Wobble. Going 60, hit a bump and then the entire front end of Jeep started jumping back and forth so badly, I thought the Jeep was coming completely apart and I was going to crash. Applying the brakes didn't help, the steering seemed out of control, I was terrified and felt like I was going to lose going to lose control of the vehicle or crash into an oncoming vehicle! Thank God I didn't! I just had to wait till the vehicle slowed down and it eventually it stopped. This is now the 3rd time it happened in the passed week.