2025 Jeep Wrangler 4xe technical service bulletins
210 technical service bulletins and manufacturer communications cover the 2025 Jeep Wrangler 4xe, including 16 warranty extensions.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- D-26-11
- ID-26-24
- Addition of 2.0L T4 Long Block or Complete Engine to the Powertrain Service Center (PTSC) Pre-Approval Program
- ID-26-04
- ID-26-24 (XC2) 2.0L PHEV
- D-26-11 (XC2) 2.0L PHEV
- D-26-06
- ID-26-06
- D-25-15
- ID-25-11
- Warranty Newsletter – Volume 12, Issue 2
- FCA Caribbean Warranty Newsletter – Volume 12, Issue 2
- D-26-06 (XU1)
- ID-26-06 (XU1)
- FCA Caribbean Warranty Newsletter – Volume 11, Issue 4
- Warranty Newsletter – Volume 11, Issue 4
- Compressor Assy High number of compressor replacements when complaint is noise and supplier analysis comes...
- Fuse block - pwr distribution a/c
- High Voltage Battery Has Lower SOC After Overnight Sleep Cycle
- Flash: Drivetrain Control Module (DTCM) Updates Customers must experience a Malfunction Indicator Lamp...
- The Customer May Complain About a Popping Noise, Grinding Noise, or an Intermittent No Reverse or Forward...
- Transmission kit - with torque converter
- Socket - drag link inner
- Charger - battery
- MIL-On and/or Engine Oil Leak
- Shifter If shifter is having trouble shifting between 1st and 2nd gear, then adjust cables as described in...
- Passive Entry O/S Dr Handle Prior to replacing an inoperative passive entry door handle, perform Star...
- Customer States Driver Seat inoperative
- Turbocharger Kit Please note that many turbo components are serviceable separately and full turbo...
- Water Leak In Rear Cargo Area Customers may comment on the following: SYMPTOM: ● Water leak in the rear...
- Customer States Driver Seat Inoperative.
- Pad - instrument panel
- Display Exchange part has been superseded
- Switchbank 4 gang The customer will notice either one or two of the following conditions: 1. Fuel Door is...
- DCSD Before replacing this part for a Blank screen, screen flickering or screen inoperative concern,...
- Spark plug - none
- Core – heater
- Instrument Panel Cluster (IPC) and Radio Compass Display has Dashes (--)
- Fuel Delivery Module Before replacing the fuel module for DTCs P0461 and P062A and other not start, long...
- Enclosure - speaker
- Flash: Integrated Dual Charging Module (IDCM) Updates Customers must experience a Malfunction Indicator...
- Throttle body – none
- Motor - blower with wheel
- Transmission Auxiliary Oil Pump Failure Customers must experience a Malfunction Indicator Lamp (MIL)...
- Wiring – injector
- Bolt - hex flange head
- Radio/ETM is Adding Approximately 27mA Draw to Vehicle When in Logistics Mode
- Heater - electric coolant
- Fuel Oil Refresh Mode (FORM) Message
- Prior to replacing an inoperative passive entry door handle, perform Star Online S2623000040.
- Passive Entry Exterior Door Handle Inoperative When Touched To Lock And Or Unlock.
- Motor and linkage - windshield wiper
- Switch - steering wheel
- Transmission Auxiliary Oil Pump Failure Customers must experience a Malfunction Indicator Lamp (MIL)...
- Radio Message "Power Surge On USB Detected" Customers may comment on the following: ● The radio displays...
- PHEV Engine Replacement XC2 Warranty Extension Customers must experience a Malfunction Indicator Lamp...
- Sensor – knock
- Instrument Panel Cluster (IPC) Flicker Turn By Turn The
- Radio Volume Jumping Up To Max Volume After Radio Wake Up
- High Voltage Battery Pack Replacement XU1 Warranty Extension Customers must experience a Malfunction...
- Before replacing the PIM, please check if the HV DC Connector is seated properly on the PIM and Battery...
- High Voltage Connector Seal And Fastener Service Parts Are Now Available
- Before replacing High voltage harness, please note the connector bolt and connector seal is available for...
- Wind Noise From Hard Top Freedom Panels Near Rear View Mirror While Driving.
- Radio Remains On After Ignition Off
- Rear Defroster Inoperative Customers may experience one or more of the following: SYMPTOM: ● Rear window...
- Universal Garage Door Opener (UGDO) Inoperable Technicians may or may not find the following Diagnostic...
- Flash: Comfort Seat Wheel Module (CSWM) Update Customers may experience the following: SYMPTOM: ● Heated...
- Flash: Powertrain Control Module (PCM) Updates Customers must experience a Malfunction Indicator Lamp...
- Seat EZ Entry Inoperable Or Doesn’t Slide Forward.
- Flash: Electronic Climate Control (ECC) Updates Customers may experience the following: SYMPTOM: ● In cold...
- The vehicle will exhibit a service transmission/check engine warning indicator for the following...
- Disengaging Stabilizer Bar Front [SHG] 1. Follow procedure in SOL s2602000001 before replacing Smart...
- Service Electric Sway Bar Lamp On In Cluster
- Active Diagnostic Trouble Code (DTC) B1A10-00, B1A11-00, B1A12- 00, B1A13-00-, B1A14-00, B1A15-00,...
- Remote Keyless Entry, Passive Entry, Remote Start Inoperative or a Cluster Message “Keyfob Not Detected”
- Windshield Wiper Blade Maintenance Customers may experience one or more of the following: SYMPTOM: ● Wiper...
- Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC)...
- 2 nd Row Center Seatbelt Jammed Or Stuck
- Glove box - instrument panel
- Panel - front seat back
- Handle - inside release
- Service transmission/check engine warning indicator for the 850RE, 8HP50, 8HP70, 8HP75, 8HP75-PHEV...
- A suspected leak may be noticed on the front or rear axle pinion seal.
- Door Hem Aluminum Body Panel Corrosion Repair Customers may experience the following: SYMPTOM: ● Filifom...
- Harman R1H Uconnect 5 Radio Software Flash Error Codes
- Uconnect Box Requires Service, Please Visit an Authorized Dealer Message on Display Message With DTCs...
- High Voltage Battery Pack Replacement XU1 Warranty Extension Customers must experience a Malfunction...
- Horn Sound Is Weak, Off Tone, Inoperative, Or Intermittent.
- Universal Garage Door Opener Prior to replacing the UGDO or sun visor, call HomeLink® Customer Care at...
- Power Top Switch Unresponsive, Full Retractable Sky Roof Does Not Open or Close
- Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC)...
- Washer Fluid Warning Lamp Illuminated When Reservoir Is Full
- Do not replace multiple shocks unless all are verified to be defective.
- Check Engine Light On And Service Hybrid System Displayed
- GMET4 dohc
- Caliper assembly - disc brake
- Not applicable to vehicles built for US market
- Power Top Switch Collapsed Into The Overhead Console Customers may experience the following: ● The power...
- Flash: Battery Pack Control Module (BPCM) Updates Customers must experience a Malfunction Indicator Lamp...
- Switch - lumbar control
- Flash: Driver Assistant System Module (DASM) Updates Customers must experience a Malfunction Indicator...
- Flash: Battery Pack Control Module (BPCM) Updates Customers must experience a Malfunction Indicator Lamp...
- Seal - roof rail
- Do not replace multiple shocks unless all are verified to be defective.
- Speaker Diagnostic Procedure Rattle, buzz and squeak coming from specific speakers.
- Axle seal We have observed that some JL/JT rear axle shafts are leaking oil
- Center stack – none
- Door - fuel fill
- Issue Description: In JL/JT vehicles, many dealers and customers are not fully aware of the correct way to...
- CEL (Check Engine Lamp)/ Brake lamp Illuminated
- Telematics Box Module (TBM) Backup Battery Replacement When DTC B1E21 Is Present Technicians may...
- Verify "Z" part number availability
- If the DTC B1E21-96: Backup Battery-Component Internal Failure is active and
- Issue Description In JL/JT vehicles, the front carpets have a perforated section below the drain plug...
- Flash: Driver Assistant System Module (DASM) Updates Customers must experience a Malfunction Indicator...
- Telematics Box Module (TBM) Backup Battery Replacement When DTC B1E21 Is Present echnicians may experience...
- Shimmy Felt In Front End
- Microphone - audio
- Temperature Control Display Is Showing Incorrect Values In Climate Widget.
- Diagnostic Trouble Code (DTC) B15A1-00 Media Port Connection 1 Connection Found Set.
- Switch - power window
- Not applicable to vehicles built for US market
- Flash: Powertrain Control Module (PCM) Updates Customers must experience a Malfunction Indicator Lamp...
- Pad kit - rear disc brake, front disc brake
- Detector - evaporative system integrity module
- 1.Identify Customer Concern Check for small traces of coolant near the water pump, especially around the...
- SOS Light Is On Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle...
- Intermittent Uconnect Box Requires Service Message
- ESC Light Illuminated
- Fuel Filler Door Will Not Open Customers may experience the following: ● Fuel filler door does not open
- Radio (ETM) Is Always Setting Stored DTC B15A1-00 Media Port 1 Connection
- Vehicle Complaints After a Recent Firmware Over The Air (FOTA) Update for the Telematics Box Module (TBM)
- When servicing/replacing 68415437A$ Transmission, take care to not damage the PIM to P2 harness
- Module - steering control & column
- Power top /sky one touch switch falls out of the bezel or is pushed inside it or won't stay in place
- Service Hybrid Electric Vehicle System Warning Message Customers must experience a Malfunction Indicator...
- Not applicable to vehicles built for US market
- Not applicable to vehicles built for US market
- Customer complaint may include a Mil On/Check Engine Lamp On and Electronic Throttle Control (ETC) Lamp...
- Vehicle is Not Charging When Connected to a Level One or Two Charger or a Public Charging Station
- Exterior Front Lamps Condensation Clearing Procedure Some customers may report that on occasion vehicle...
- Shock And Strut Diagnosis And Replacement Guidelines Leaking, noisy, or weak shocks or struts.
- Flash: Powertrain Control Module (PCM) Updates Customers must experience a Malfunction Indicator Lamp...
- Flash: Hybrid Control Processor (HCP) and Auxiliary Hybrid Control Processor (AHCP) Updates Customers must...
- Instrument Panel Cluster (IPC) Display Flickers, Overlapping Displayed Images, Multiple Warning Lamps Turn...
- TPMS Handling & Installation Best Practices
- Customer Indicates Tire Pressure Monitoring System (TPMS) Lights On Dash.
- Global Telematics Box Module (TBM) Firmware Over The Air (FOTA) Update To 5.65 Software Level The
- Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges...
- Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges...
- Before replacing the key fob battery, please follow the following steps: 1- Check if there is a "FOB Low...
- False fails on PCR, DBSM and PDCs Stuck Closed or open diagnostics, DTC P2AF5 or P2AF6, leading to NTF and...
- Radio Does Not Turn On Automatically When Vehicle Is Started
- Flash: Integrated Dual Charging Module (IDCM) Updates Customers must experience a Malfunction Indicator...
- Not applicable to vehicles built for US market
- Turbocharger Oil Return Line Leak Customers may experience the following: ● Engine oil leak from the...
- Windshield Wiper Blade Maintenance Customers may experience one or more of the following: ● Wiper blades...
- Tire Pressure Monitor (TPM) Service Information
- Flash: Powertrain Control Module (PCM) Updates Customers must experience a Malfunction Indicator Lamp...
- Module - engine controller
- Flash: Hybrid Control Processor (HCP) and Auxiliary Hybrid Control Processor (AHCP) Updates Customers must...
- Decreased Remote Start And RKE Range
- When replacing a camshaft and parts kit (P/N 68661146xx and/or 68661147xx), it is NOT necessary to order...
- Flash: Battery Pack Control Module (BPCM) Updates Update BPCM Software to current level
- Flash: Driver Assistant System Module (DASM) Updates Customers must experience a Malfunction Indicator...
- Global Telematics Box Module Over The Air Update from 5.39.1 to 5.65 TBM2.0 Software Version (FOTA)...
- Shim
- Unable To Refuel Vehicle Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the...
- Power Top Switch Unresponsive, Full Retractable Sky Roof Does Not Open or Close Customer...
- Underhood start/stop safety The
- Service Hybrid Electric Vehicle System Warning Message Customers must experience a Malfunction Indicator...
- B2779-04
- Backlite Heated Liftgate Glass Assembly: For rear window defrost inoperative concerns where heated glass...
- Universal Garage Door Opener (UGDO) Inoperative, LED Indicator Lamps Not Illuminating
- Washer Light On And Will Not Turn Off After Adding Washer Solvent."
- Fca caribbean warranty operations newsletter volume 11, issue 5"
- Steering Column Difficult To Adjust Up Or Down.
- AM Radio Static, With No Active or Stored Radio Antenna Diagnostic Trouble Codes (DTC).
- We have observed that some JL/JT rear axle shafts are leaking oil
VIN decoder
See the problems and recalls for an exact car
Buying a used 2025 Jeep Wrangler 4xe?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history