The contact owns a 2023 Kenworth T680. The contact stated that while operating the vehicle and pressing the wiper fluid button, the wiper fluid did not immediately spray, and the contact was unable to immediately clean the front windshield. The contact stated the after several attempts the wiper fluid sprayer operated normally. Later, the front windshield wipers malfunctioned. The contact stated that when the front windshield wipers were activated in the continuous setting, the wipers were randomly delayed. Additionally, while activating the turn signal and the wipers the features were delayed. The vehicle was taken to the local dealer who diagnosed an electrical short in the wiper and turn signal mechanism, and that the mechanism needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 205,000. The VIN was invalid.
The worst 2023 Kenworth T680 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Transmission4
- Driver assistance2
- Body1
- Brakes1
- Suspension1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Transmission4
- Driver assistance2
- Body1
- Brakes1
- Suspension1
- Tires1
- Visibility1
Recalls 9
Electrical system: propulsion system
- What is wrong
- PACCAR Incorporated (PACCAR) is recalling certain 2022-2025 Peterbilt 520, 579, and 2021-2025 Kenworth T680 trucks. The high voltage (HV) contactors may open, causing a sudden loss of high voltage and a loss of drive power.
- Risk
- A loss of drive power increases the risk of a crash.
- Remedy
- Dealers will update the software and replace the electrical harness, free of charge. Owner notification letters were mailed May 13, 2025. Owners may contact Peterbilt's customer service at 1‑940‑591‑4220 and Kenworth's customer service at 1‑425‑828‑5888. PACCAR's numbers for this recall are 25PBC and 25KWC.
Recall number 25V181000 · Recall details
Electrical system: software
- What is wrong
- PACCAR Incorporated (PACCAR) is recalling certain 2021-2025 Peterbilt and Kenworth vehicles, equipped with Bendix EC80 Advanced Electronic Control Units (ECU). Please see the recall report for a complete list of models. Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop functioning.
- Risk
- Safety systems that depend on the ECU (Automatic Traction Control, ABS, Electronic Stability Control, Active Cruise Control, and Collison Mitigation System) may not function properly or at all, increasing the risk of a crash.
- Remedy
- Dealers will reprogram the ECU software, free of charge. Owner notification letters were mailed February 3, 2025. Owners may contact Kenworth's customer service at 1‑425‑828‑5888 and Peterbilt's customer service at 1‑940‑591‑4220. PACCAR's numbers for this recall are 24KWL and 24PBL.
Recall number 24V915000 · Recall details
Power train: automatic transmission: lever and linkage: column shift
- What is wrong
- PACCAR Incorporated (PACCAR) is recalling certain 2021-2024 Peterbilt 365, 367, 389, 535, 536, 537, 548, 567, 579, and 2021-2025 Kenworth T180, T280, T380, T480, T680, T880 and W990 trucks. The right-hand gear shifter stalk connectors may have been improperly crimped, resulting in a loss of communication.
- Risk
- A loss of communication between the gear shifter and the transmission may result in the vehicle becoming disabled after coming to a stop, increasing the risk of a crash.
- Remedy
- Dealers will inspect and replace the gear shifter assembly as necessary, free of charge. Owner letters were mailed December 15, 2025, then phased after that. Owners may contact Kenworth customer service at 1‑425‑828‑5888 or Peterbilt customer service at 1‑940‑591‑4220. PACCAR's numbers for this recall are 24PBE and 24KWE.
Recall number 24V190000 · Recall details
Service brakes, air: supply: reservoir/tank
- What is wrong
- PACCAR Incorporated (PACCAR) is recalling certain 2009-2021 Kenworth C500, 2012-2021 Kenworth T440, 2009-2015 Kenworth T660, 2015-2024 Kenworth T680, 2009-2024 Kenworth T800, 2009-2020 Kenworth T370, 2014-2023 Kenworth T880, 2011-2016 Kenworth T470, 2023 Kenworth T480, and 2009-2019 Kenworth W900 vehicles. The air tanks have an insufficient volume of air for the brake system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 121, "Air Brake Systems."
- Risk
- Insufficient air volume can reduce braking performance and increase the risk of a crash.
- Remedy
- Dealers will install the correct volume air tanks, free of charge. Owner notification letters were mailed August 12, 2024. Additional owner notification letters were mailed October 27, 2025. Owners may contact PACCAR customer service at 1‑425‑828‑5888. PACCAR's number for this recall is 24KWD.
Recall number 24V145000 · Recall details
Electronic stability control (ESC)
- What is wrong
- PACCAR Incorporated (PACCAR) is recalling certain 2022-2023 Peterbilt 579 and 2023 Kenworth T680 vehicles. Incorrect software in the battery electric heavy duty electronic stability control program may underestimate the mass of the vehicle. As such, these vehicles may fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 136, "Electronic Stability Control Systems on Heavy Vehicles."
- Risk
- An incorrect estimate of the vehicle mass can reduce the performance of the stability control system and increase the risk of a crash.
- Remedy
- Dealers will update the software, free of charge. Owner notification letters are expected to be mailed March 17, 2023. Owners may contact PACCAR's customer service at 1‑425‑828‑5888 (Kenworth) and 1‑940‑591‑4220 (Peterbilt). PACCAR's numbers for this recall are 23PBA and 23KWA.
Recall number 23V007000 · Recall details
Electrical system: instrument cluster/panel
- What is wrong
- PACCAR Incorporated (PACCAR) is recalling certain 2022-2023 Kenworth T680, T880, W990, and Peterbilt 365, 367, 389, 567, and 579 vehicles. The digital display may freeze and not display critical safety information. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 101, "Control and Displays" and 102, "Trans Shift Lever Seq/Starter Interlock/Trans Braking Effect."
- Risk
- The loss of display information, such as vehicle speed and warning lights, can increase the risk of a crash.
- Remedy
- Dealers will update the software, free of charge. Owner notification letters are expected to be mailed December 16, 2022. Owners may contact Kenworth's customer service at 1‑425‑828‑5888 and Peterbilt's customer service at 1‑940‑591‑4220. PACCAR's numbers for this recall are 22KWK and 22PBK.
Recall number 22V779000 · Recall details
Engine and engine cooling: engine: engine control module (ecu/ECM)
- What is wrong
- PACCAR Incorporated (PACCAR) is recalling certain 2023 Peterbilt 220, 389, 520, 536, 537, 348, 367, 567, 548, 579, and 2023 Kenworth T680, K270, T440, T880, W990, K370, T280, T380, T480, T800, and W900 vehicles. The engine control module (ECM) may experience an internal electrical short-circuit, causing the engine to stall.
- Risk
- An unexpected engine stall can increase the risk of a crash.
- Remedy
- Dealers will replace the ECM, free of charge. Owner notification letters are expected to be mailed October 16, 2022. Owners may contact Kenworth's customer service at 1‑425‑828‑5888 and Peterbilt's customer service at 1‑940‑591‑4220. PACCAR's number for this recall is 22KWG and 22PBG.
Recall number 22V631000 · Recall details
Structure: underride
- What is wrong
- PACCAR Incorporated (PACCAR) is recalling certain 2022-2023 Kenworth T680 tractor trailers. The mud flap may contact the fuel tank while the vehicle is in motion, creating wear on the fuel tank over time.
- Risk
- Excessive wear of the fuel tank may allow fuel to spill on the roadway, which can increase the risk of a crash or injury.
- Remedy
- Dealers will inspect the fuel tank and install an anti-sail device to prevent the mud flap from contacting the fuel tank, free of charge. Owner letters were mailed February 1, 2023. Owners may contact Kenworth's customer service at 1‑425‑828‑5888. Paccar's number for this recall is 22KWF.
Recall number 22V582000 · Recall details
Steering
- What is wrong
- PACCAR Incorporated (PACCAR) is recalling certain 2022-2023 Kenworth T170, T270, T280, T370, T380, T440, T470, T480, T680, T800, T880, W900, W990, C500, and 2022-2023 Peterbilt 325, 330, 337, 348, 365, 367, 389, 520, 536, 537, 548, 567, and 579 vehicles. The steering gears may have been assembled incorrectly, which can cause the gears to fracture.
- Risk
- A fractured steering gear can cause a loss of steering control, increasing the risk of a crash.
- Remedy
- Dealers will inspect the steering gear serial numbers, and replace the steering gears as necessary, free of charge. Owner notification letters were mailed September 26, 2022. Owners may contact Kenworth's customer service at 1‑425‑828‑5888 and Peterbilt's customer service at 1‑940‑591‑4220. PACCAR's numbers for this recall are 22PBE and 22KWE.
Recall number 22V547000 · Recall details
Technical service bulletins for the 2023 Kenworth T680 86
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- KW & PB 14 fuel injector part numbers (seven for MX-11 and seven for MX-13 engines) have been added to...
- Fuel Injection Pump part number 2344776PEX for MX-13 engines has been added to this warranty policy.
- 24PBE_24KWE RH Shift Stalk Update Warranty section has been updated with revised verbiage for picture...
- The right-hand shift stalk may have an improper wire harness terminal crimp within the wire harness connector
- 32 fuel injector part numbers (16 for MX-11 and 16 for MX-13) have been added to this warranty policy.
- Replaced generic SRT codes with bulletin-specific SRT codes.
- The new 2.1m day cab lift tools, a Level 3 mandatory tool, are now available to order.
- RMI procedures have been updated to reduce the risk of progressive damage to the rocker arms
- Removed hyperlinks for bulletin migration
- Certain T680 Next Gen short hood chassis may be missing a bolt in the forward fairing.
What 2023 Kenworth T680 owners say
Most recent owner complaints, unedited.
I have 2 Kenworth trucks VIN [XXX] and [XXX] both on recall the federal safety agency 24V190. The recalls have been performed my issue is with reimbursement for prior replacement for the recalled parts. I have attached emails from Paccar as well as the invoices for the replacement of the recalled parts. Any help you can provide is appreciated as I'm not getting anywhere with Paccar or the dealers. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2023 Kenworth T680 equipped with Goodyear Tires, Tire Line: Endurance, Tire Size: 297/75/R22.5, DOT Number: 1MC37L1BW0624. The contact stated that while driving 65 MPH, there was an abnormal sound coming from the front passenger’s side of the vehicle, and afterwards, the contact felt heavy vibrations coming from the steering wheel. After a visual inspection, the contact observed that the front passenger’s side tire casing had separated from the tread. The tires were taken to an independent mechanic, who failed to provide a diagnosis. The tire was replaced by Roadside Assistance. The manufacturer was not notified of the failure. The vehicle failure mileage was 362,000, and the tire failure mileage was 50,000.
The contact owns a 2023 Kenworth T680 with the camper attached. The contact stated that the ABS warning light was illuminated before the failure. The contact stated that while standing behind the passenger side seat in between the sleeper portion and the cab, there was an abnormally loud popping sound detected. The vehicle began to move and crashed into the door of an unknown tractor-trailer cab. The vehicle had been parked for approximately 45- 60 minutes before the crash. The contact had to seek medical assistance from a therapist due to the incident. There was no report of fire, airbag deployment, or police report filed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 25,000.
The contact owns a 2023 Kenworth T680. The contact received notification of the federal safety agency Campaign Number: 24V190000 (Power Train) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall. The contact stated that while driving at an undisclosed speed, the transmission was not operating properly. The contact stated that the vehicle downshifted unexpectedly with the transmission fault warning light illuminated. The vehicle was restarted; however, the failure recurred. The dealer was contacted; however, the vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 338,388. The VIN was not available.
The contact's employer owns a 2023 Kenworth T680. The contact stated that while driving at 55 MPH with the Lane Departure Mitigation System activated, and the brakes were applied unintendedly. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 135,000.
Spacer between U-Bolt and Leaf spring which binds front suspension system with steering axle has sifted towards front side I have two units with same problem on both of those in brought in 2022 march . Same alike unit bought by one of my friend gets same problem attaching some pictures of both unit to get more specific. Thanks
The contact owns a 2023 Kenworth T680 Heavy Truck. The contact stated that while driving at various speeds, the vehicle would inadvertently pull aggressively to the right without warning. The contact stated that the sub frame was detached and not centered. The vehicle was taken to an independent mechanic and the driver's side shift stalk was replaced. The manufacturer was made aware of the failure. The failure mileage was approximately 18,011.
The contact owns a 2023 Kenworth T680. The contact stated that the dealer previously repaired the vehicle under the federal safety agency Campaign Number: 22V547000 (Steering). The contact stated that while driving at an undisclosed speed, the ABS, traction control, transmission, and hill assist warning lights illuminated. The dealer was made aware of the failure but provided no assistance. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 109,000.
Compare the 2023 Kenworth T680
Other model years
Questions about the 2023 Kenworth T680
Is the 2023 Kenworth T680 reliable?
Owners have filed 9 complaints about the 2023 Kenworth T680, close to a typical T680 model year.
What is the most common problem with the 2023 Kenworth T680?
Transmission and drivetrain, with 4 complaints. Next is driver assistance (2).
How many recalls does the 2023 Kenworth T680 have?
9 recalls, covering electrical system, power train and service brakes, air.
Was there a recall on the 2023 Kenworth T680 transmission?
Yes, 1 recall: 24V190000. Check your VIN to see if your car still needs the free repair.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2023 Kenworth T680?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history