Tl*the contact owns a 2005 keystone outback-sydney (travel trailer). While stationary, the rear of the trailer caught fire. Approximately ten minutes later, the entire trailer was engulfed in flames. The fire department extinguished the fire and filed a report. The cause of the failure was determined to be from a power surge. The vehicle was destroyed. There were no injuries. The failure mileage was unknown. Updated 09/24/08. *lj updated 09/30/08.
The worst 2005 Keystone Outback-Sydney problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Electrical1
- Tires1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Electrical1
- Tires1
Recalls 3
Equipment
- What is wrong
- Keystone RV Company (Keystone) is recalling various 2003-2018 Crossroads, Dutchmen, and Keystone recreational trailers equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit:
- Risk
- In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
- Remedy
- Keystone will notify owners and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Keystone customer service at 1‑574‑535‑2100, or Kidde customer service toll-free at 1‑855‑262‑3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Keystone's number for this recall is 17-307.
Recall number 17V755000 · Recall details
Equipment: recreational vehicle/trailer
- What is wrong
- Keystone is recalling 161,250 my 2004-2007 fifth wheel and travel trailers equipped with a two-door refrigerator manufactured by the dometic corporation. The refrigerator may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.
- Risk
- If this solution is exposed to an ignition source under certain specific circumstances, it can result in a vehicle fire.
- Remedy
- Keystone is working with dometic to repair these refrigerators (please see 08e032). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained stericycle inc. To manage this campaign. Stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners may contact dometic/stericycle at 1‑888‑446‑5157 or keystone at 1‑866‑425‑4369.
Recall number 08V325000 · Recall details
Electrical system: wiring
- What is wrong
- On certain travel trailers, during production, the wiring was routed over the top of the gray holding tank on the backside in a location where the wiring could become pinched by the heat plenum framing.
- Risk
- Pinched wiring could cause an electrical short. Electric power may become in-operable in affected units due to breakers being tripped.
- Remedy
- Dealers will re-route the wiring. The recall began december 10, 2004. Owners should contact keystone at 574‑535‑2100.
Recall number 04V577000 · Recall details
What 2005 Keystone Outback-Sydney owners say
Most recent owner complaints, unedited.
Nanco tires- dot code on kc tci date code 4604 I suffered a sudden failure in august 2005. No accident and minimal damage to vehicle. During spring inspection three additional tires matching these codes have begun to separate at the sidewall. Keystone rv has installed this tire on probably thousands of rv's in the country and I have through email found a minimum of 15 additional people with the same failure. The risk of unexpected failure and accident is high from this type of problem should it be widespread. Nanco has agreed to replace my damaged tires.
Compare the 2005 Keystone Outback-Sydney
Other model years
20052007
Questions about the 2005 Keystone Outback-Sydney
Is the 2005 Keystone Outback-Sydney reliable?
Owners have filed 2 complaints about the 2005 Keystone Outback-Sydney, close to a typical Outback-Sydney model year.
What is the most common problem with the 2005 Keystone Outback-Sydney?
Electrical system, with 1 complaint. Next is tires (1).
How many recalls does the 2005 Keystone Outback-Sydney have?
3 recalls, covering equipment and electrical system.
Was there a recall on the 2005 Keystone Outback-Sydney electrical?
Yes, 1 recall: 04V577000. Check your VIN to see if your car still needs the free repair.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2005 Keystone Outback-Sydney?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history