2025 Kia Carnival Hybrid electrical problems

Filed Oct 28, 2026 · Electrical · 16,000 miles · IL

The contact owns 2025 Kia Carnival Hybrid. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The vehicle unexpectedly switched to Safe Mode and decelerated. In addition, the check the hybrid system and the message to “Stop the Vehicle” was displayed. The vehicle was taken to the dealer and the vehicle was repaired. The contact stated that the hybrid system was repaired and the vehicle was repaired; however, the failure reoccurred. The contact stated that the failure also occurred while accelerating from the vehicle idling. The contact stated that the failure was a known failure with the vehicle. The manufacturer was contacted, and a case was filed. The failure mileage was approximately 16,000.

Filed Oct 14, 2026 · Acceleration, Electrical · NC

In May 2026, after driving through a heavy rainstorm on the highway, the car suddenly cut off cruise control and showed multiple warning lights (for most, if not all assistance systems) and an error message that was some version of "check hybrid system." When searching the code it seemed to be related to an electrical short in the hybrid system. I had no electric power to the engine, but the gas functionality still sort of worked, so I could drive, but there was a 2-3 second delay between pushing the gas pedal and getting any acceleration, and said acceleration was minimal. This occurred at 70+ mph on a busy highway, so the sudden lack of acceleration and control was alarming and put us and the cars around us at risk due to sudden speed change. When we pulled into a safe stop and turned the car off for a few minutes and then back on, the error messages were gone and hybrid system seemed functional again. The check engine light remained, but turned off after the next short trip. There had been no warnings, lights, or symptoms of any issues at any point prior to this occurring. The car was not seen at the time due to being on vacation and not near any Kia dealership. It is being seen in a few weeks, but as this was 5 months ago, I do not anticipate anything being found to explain the issue, particularly after reading other online reports of this issue. A similar issue happened recently (Oct 2026) with no rain present. I had just started driving, and got a warning about lane-keeping assist, but no others. I pulled over, couldn't find any other errors or details, and everything else seemed fine. I continued driving, and 1-2 minutes later, while trying to accelerate onto the highway, I suddenly had no acceleration power with the pedal touching the floor. I was again at risk of a high-speed accident if I had not been able to move the car toward the shoulder quickly. No error code appeared at the time of acceleration loss. Power returned after restarting the car.

Filed Oct 5, 2026 · Acceleration, Electrical · MI

Within 5 minutes of driving, the car stopped accelerating. Check hybrid system alert appeared one minute later. Car stalled out within approximately 1-2 minutes after warning light appeared. No other warning lights were present prior. This is a 2025 new Kia Carnival Hybrid. I was stranded on the side of a 55mph road. The first time the police helped me roll it off the road. The second time it couldn’t be pushed even though it appeared to be in neutral. The car dies but the accessory functions will not turn off. We have to unplug the battery each time. This car could die ANYWHERE leaving you stranded in a very dangerous situation. There is very little warning. This is extremely hazardous. This is the SECOND time this has occurred with a combined total of 5 hours waiting for tow trucks and countless hours contacting Kia. Kia kept the car for two weeks and recharged the battery. That’s it. It died again within 24 hours of being returned to us. This is UNSAFE and unreliable.

Filed Sep 22, 2026 · Electrical, Engine · UT

On random occasions, car will display "check hybrid system" and go into limp mode (limiting speed significantly) check engine, oil, and battery lights also illuminate. Had car serviced twice by dealership who cannot replicate the error, nor can they find any engine codes stored. However, this incident keeps occurring. Planning on having the car serviced again and not picking it up until it's figured out, but also wanted to report this incidence as I have seen several posts with other people complaining of the same issue. Concern is for if this happens randomly at freeway speeds and becomes a serious road hazard.

Filed Sep 6, 2026 · Acceleration, Electrical · WV

My vehicle keeps throwing a code “check hybrid system” and slowing me down to 30mph, it will not accelerate. This is extremely dangerous. I can restart the car and it’s fine but this is a major safety issue considering it keeps happening

Filed Aug 28, 2026 · Electrical · IL

The digital instrument panel display on the right side that shows map direction goes blank or start flickering. Audio also fails to function. When it goes blank, the rear camera also stops showing and causes difficulting in reversing the car. This happens randomly, but mostly once car has driven 10-15 mins or more and not right away. Points to some effect due to heat or vibration since the screen flickering begins once its driven a little bit.

Filed Aug 11, 2026 · Electrical, Visibility · AL

I am writing to formally report a serious, recurring safety defect involving the Heating, Ventilation, and Air Conditioning (HVAC) system in my vehicle. The system intermittently shuts off completely without warning and suffers from a malfunctioning airflow diverter. This directly impacts driver visibility due to immediate windshield fogging or the inability to de-ice during cold weather conditions. Below are the logged details of the intermittent shutdowns: July 9: System shut off 22 minutes into the drive. Local time: 07:58. Ambient temperature: 76°F. Vehicle settings: 72°F, Fan Speed 3.July 11: System shut off 34 minutes into the drive. Local time: 17:10. Ambient temperature: 92°F. Vehicle settings: Low, Full Blast. Furthermore, the airflow diverter is partially stuck on defrost mode. Air constantly blows onto the front windshield regardless of the chosen setting on the selector. This uncommanded airflow creates rapid temperature differentials on the glass, causing severe condensation and clouding the driver's line of sight during operation. These compounding HVAC failures constitute a significant safety hazard by unexpectedly distracting the driver and severely reducing visibility. I request that these issues be documented and investigated for potential safety recalls. Currently, my vehicle is in the shop with a local KIA dealership. A KIA corporate service technician is on ground and investigating the electrical and HVAC issues. Feel free to reach out for additional observational notes that I have compiled.

Filed Jul 26, 2026 · Electrical, Engine · DE

My 2025 Kia Carnival Hybrid is experiencing repeated electrical and hybrid battery failures. The battery has died multiple times, and the vehicle has shut off while driving, including at higher speeds. When the vehicle shuts off, all electrical systems reset, warning lights flash, and the dashboard displays “User Authorization” notifications. This creates a serious safety hazard for me and my passengers. The defect has occurred multiple times and remains unresolved despite dealer visits. Kia corporate is not responding and is redirecting me back to BBB Auto Line without providing any repair plan. The defect is ongoing and poses a risk of crash, injury, or loss of vehicle control. These symptoms match other Carnival electrical/battery complaints already filed with the federal safety agency, including sudden shutdowns, battery failures, and electrical resets. I am submitting this report because the defect continues and Kia has not provided a permanent repair.

Filed Jul 23, 2026 · Brakes, Electrical · NY · fire

I had two very serious incidents. July 8th: Horn just started blaring unprompted. Locking/unlocking doors, turning motor on, disconnecting battery did nothing to stop it. I was trying everything and as I was trying to find the correct fuse to disable (it wasn't labeled), the horn burned out and started smoldering. If the car was not in my driveway AND I wasn't home, I believe a fire would have started if I didn't pull the fuse AND douse it with water. It was parked next to my garage, so that would have been at risk as well. July 11th: When driving, my brake line burst resulting in a complete failure of my brakes. I narrowly escaped two accidents before I realized something was amiss. But the only warning was ABS was inactive, and active cruise control wasn't working. I had no warning that complete brake failure was imminent. I was extremely lucky. Mechanics had never seen a brake failure fail in a relatively new car in very good condition.

Filed Jun 26, 2026 · Driver assistance, Electrical · CA

The vehicle began shaking and having ABS problems when driving at ~30 mph after having driven for several miles without issue. The vehicle did not have any history of problems or recent symptoms and was just over one year old. The vehicle was towed to the dealership. The dealership reported a broken driver side front wheel speed sensor wire and attributed it to rodent damage without other evidence.