2025 Kia Carnival Hybrid transmission problems

Filed Oct 22, 2026 · Acceleration, Fuel system · TX

My 2025 Kia Carnival Hybrid was purchased new in January 2025. The problem began almost immediately, with the vehicle first presented to an authorized Kia dealer for this condition at only 810 miles. The vehicle repeatedly and unpredictably enters reduced-power or “limp mode,” causing a sudden loss of normal acceleration and limiting it to approximately 35 mph. This creates a serious safety risk on highways, while merging, crossing intersections, or whenever acceleration is needed to respond to traffic. Equally concerning, the vehicle does not consistently display a warning or retain a hard diagnostic error code when the loss of power occurs. Sometimes a check-engine light or “Check Hybrid System - Stop Safely” message appears, but at other times the vehicle enters limp mode with no warning. After turning the vehicle off and restarting it, normal operation may return and the error disappears, leaving the dealer unable to retrieve a stored code showing what occurred. The vehicle has been presented to an authorized Kia dealer for this recurring issue at least five times. In August 2026, it remained in limp mode and had to be towed to the dealer. We were initially told no error code had been found. Near the end of the service period, we were told a code had appeared indicating a faulty sensor, which was replaced, but the reduced-power problem later recurred. The vehicle’s automatically generated August performance report also indicated no vehicle issues despite the August incident. A Kia TechLine case was later opened, but the recurring problem was not identified or permanently corrected. The vehicle is available for inspection.

Filed Oct 5, 2026 · Acceleration, Electrical · MI

Within 5 minutes of driving, the car stopped accelerating. Check hybrid system alert appeared one minute later. Car stalled out within approximately 1-2 minutes after warning light appeared. No other warning lights were present prior. This is a 2025 new Kia Carnival Hybrid. I was stranded on the side of a 55mph road. The first time the police helped me roll it off the road. The second time it couldn’t be pushed even though it appeared to be in neutral. The car dies but the accessory functions will not turn off. We have to unplug the battery each time. This car could die ANYWHERE leaving you stranded in a very dangerous situation. There is very little warning. This is extremely hazardous. This is the SECOND time this has occurred with a combined total of 5 hours waiting for tow trucks and countless hours contacting Kia. Kia kept the car for two weeks and recharged the battery. That’s it. It died again within 24 hours of being returned to us. This is UNSAFE and unreliable.

Filed Oct 2, 2026 · Acceleration, Brakes · TX

This complaint is a follow up to complaint #XXX. I took the car in to Dennis Eakin Kia in [XXX] to repair what caused the car to go into Limp Mode after slamming on the brakes. The dealership did a deep scan of the hybrid control and power train control module for historical or iintermittent codes. They could find none because the car apparently does not save them after the ignition is turned off. They are trashed. They also tried 4 times to re-create the event by slamming on the brakes, but were unable to re create it. They returned the car to me without fixing it. This is another deep -imbedded safety hazard of this car that a well-documented safety hazard from many drivers cannot be fixed because the car trashes any evidence of these incidences. This car is a clear danger to drivers, a danger that can only be fixed through a recall to get them off the road until a fix is executed by the manufacturer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 30, 2026 · Acceleration, Brakes · TX

I had to slam on my brakes and the car went into Limp Mode, not allowing acceleration above 20 MPh. I drove for a while and then pulled into a parking lot and turned off the car and back on again. I was able to achieve normal acceleration after turning the car back on. We felt unsafe having no control over our speed and cars honking and racing around us. I am afraid to drive my family in this car for fear of having to slam on my brakes at a highway intersection or off/on ramp, which could cause a fatal crash. A Kia dealership is performing a diagnostic now and will advise. The vehicle has not been inspected by another agency. No warning lights went on that I can recall.

Filed Feb 22, 2026 · Electrical, Engine · KY

The vehicle shows a Driver Assistance System Warning randomly. Then the vehicle is unable to accelerate past ~30MPH. We almost got hit when this happened. The warning does not show up in notifications nor does it show up in diagnostics. It gets reverts back to normal when the vehicle is turned off then turned back on. It seems to reset.

Filed Nov 6, 2025 · Acceleration, Transmission · 3,000 miles · WA

The contact owns a 2025 Kia Carnival Hybrid. The contact stated that while driving at undisclosed speeds, the vehicle hesitated before accelerating while depressing the accelerator pedal. There were no warning lights illuminated. The vehicle was taken to the dealer, who was able to duplicate the failure; however, the vehicle was not diagnosed, and the cause of the failure was not yet determined. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was opened. The failure mileage was approximately 3,000. The VIN was not available.

Filed Oct 2, 2025 · Electrical, Fuel system · TX

When the vehicle is idling, the battery refuses to charge, therefore, the car suddenly dies and makes it unsafe to pull over and dyes while driving, very dangerous and transmission doesn’t shift properly.

Filed Aug 27, 2025 · Acceleration, Engine · TX

The hybrid car intermittently switches into EV mode after coming to a complete stop (e.g., at a traffic signal or after briefly stopping to pick up my child). When this happens, the vehicle does not accelerate properly once back on the road and feels stuck in EV mode, unable to accelerate beyond ~45 mph. This creates a safety concern when merging or crossing intersections.

Filed May 9, 2025 · Acceleration, Transmission · CA

The Kia Carnival Hybrid wouldn't allow me to accelerate, topping out at 30/31 MPH despite me fully pressing down on the accelerator. It has happened twice now (a few days apart) and can only be resolved by turning the car off and then back on. Compared to similar complaints logged on the federal safety agency website, the difference is that this happened when it was roughly 50-60 degrees outside--not during extremely low temperatures as the other examples have described.

Filed Apr 5, 2025 · Fuel system, Transmission · UT

Vehicle lost power and would not accelerate past 30 mph even when fully pressing down on the accelerator. After a few minutes a warning flashed to check vehicle hybrid system. Pulling over to the shoulder and restarting the car returned the car to normal operation.