2012 Kia Sorento brakes problems

Filed Aug 19, 2026 · Airbags, Brakes · 227,079 miles · MI

The contact owns a 2012 Kia Sorento. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the vehicle failed to exceed 20 MPH. There were several unknown warning lights illuminated, and the air bag warning light was also illuminated. The contact received notification of the federal safety agency Campaign Number: 23V652000 (Service Brakes, Hydraulic). The vehicle was taken to the dealer, and the recall repair was performed. The failure reoccurred six months later. The vehicle was towed to the dealer. The contact was informed that the failure was caused by wiring issues with the front passenger's seat. The vehicle was not yet repaired. The vehicle was towed to an alternate dealer. The vehicle had not been diagnosed. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 227,079.

Filed Jun 24, 2026 · Brakes, Suspension · NY

I had taken the Kia Sorrento to a local shop to get an oil change, and Mavis tire had discovered that the rear suspension and rear subframe were severely corroded with rust and I was told that the car is unsafe to drive. I had noticed as well that my brakes would not normally stop when I go to press them as a bit of a kickback and the traction sensors and ABS sensors and emergency brake sensors would go off and on for no reason.

Filed Feb 4, 2026 · Brakes, Engine · 250,000 miles · OH

The contact owns a 2012 Kia Sorento. The contact received notifications of the federal safety agency Campaign Numbers: 20V750000 (Engine) and 23V652000 (Service Brakes, Hydraulic); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The contact stated that while driving into a parking spot, the vehicle suddenly lost power and stalled. The contact later replaced the battery, but the vehicle failed to start. The vehicle was towed to a certified mechanic, who diagnosed the vehicle with engine failure. The vehicle was not repaired. The manufacturer was informed of the failure and informed the contact that, due to the vehicle not having the sensor changed before the failure, the engine could not be replaced. The dealer informed the contact tha,t due to the mileage, the vehicle would not be covered and would not qualify for the extended warranty coverage for the engine replacement. The failure mileage was approximately 250,000.

Filed Jan 8, 2026 · Brakes, Engine · 106,000 miles · AL

The contact owns a 2012 Kia Sorento. The contact stated that the rod bearings were knocking, and the check engine warning light was illuminated. The contact received notification of the federal safety agency Campaign Numbers: 15V626000 (Power Train), 23V652000 (Service Brakes, Hydraulic), and 20V750000 (Engine). The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The contact called the warranty company which declined the repairs. The failure mileage was approximately 106,000.

Filed Dec 5, 2025 · Brakes · 212,000 miles · GA · fire

The contact owns a 2012 Kia Sorento. The contact stated the vehicle was serviced at the local dealer for the federal safety agency Campaign Number: 23V652000(SERVICE BRAKES, HYDRAULIC) regarding a safety fire hazard. Days later, while the vehicle was idling, smoke was suddenly present coming from under the hood. The contact opened the hood of the vehicle and discovered flames and smoke coming from the fuse box located in the front of the engine bay. The contact, who was a local fire investigator, retrieved a fire extinguisher and extinguished the flames. The fire department was called to the scene, and a fire report was filed. The vehicle was later towed to the home, and the manufacturer and local dealer were notified of the incident. The manufacturer sent an investigator to the home to examine the vehicle. The investigator determined that the fire had originated at the front of the engine compartment, but did not determine the cause of the fire. No injuries were reported. The contact was concerned that the fire was related to the recall service previously performed. The failure mileage was 212,000.

Filed Aug 19, 2025 · Brakes, Engine · 11,877 miles · LA

The contact owns a 2012 Kia Sorento. The contact received notification of the federal safety agency Campaign Number: 23V652000 (SERVICE BRAKES, HYDRAULIC). The contact stated that while driving at 60 MPH, the vehicle jerked with an abnormal rattling coming from the engine. The check engine warning light was illuminated. The contact pulled over to the side of the road, and the vehicle was towed to the residence. The vehicle was then towed to a dealer, where it was diagnosed, and determined that there were metal shavings found inside the engine. The dealer requested that the contact provide the history of maintenance on the vehicle. The contact provided documents; however, the dealer refused to perform the recall repair due to a lack of maintenance on the vehicle. The vehicle was not repaired. The vehicle was towed back to the residence. The failure persisted, and the vehicle remained at the residence unrepaired. The manufacturer was not notified of the failure. The failure mileage was approximately 11,877.

Filed Aug 11, 2025 · Brakes, Driver assistance · TX

Parking lights stay on, change brake light switch but the hole that the switch goes in is not aligned with the brake stopper to turn off the stop brakes, therefore it remains on. Battery needs to be unplugged to keep from draining. The mechanism to stop the lights from remaining on is somehow shifted to no longer turn off the brake lights.

Filed Mar 6, 2025 · Brakes, Electrical · HI

The downhill break control (DBC) and the traction control system is is engaged and eliminated in the dash. It causes smoke or steam to come from under the hood after it is driven. This is the second time this issue has happened. I spent over $3,000 and six months getting this fixed last time. If there is not a recall on these things it should be recalled and fixed without me having to pay for it again. I believe it should have been covered the first time it happened.

Filed Feb 10, 2025 · Brakes · 100,000 miles · MO · fire

The contact owns a 2012 Kia Sorento. The contact stated that upon parking the vehicle at his home, an abnormal burning odor began to emit from the vehicle's vents. Upon inspection of the vehicle, the contact discovered that the engine had caught fire and did not engulf beyond the vehicle's firewall. The contact used his home's water hose and sprayed the engine for approximately 25-30 minutes until the fire was fully extinguished. The police and fire departments were not notified of the failure and no injuries were reported. Upon investigation, the contact discovered the federal safety agency Campaign Number: 23V652000 (Service Brakes, Hydraulics) which was linked to the failure. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle was not repaired. The failure mileage was approximately 100,000.

Filed Jan 13, 2025 · Brakes · 142,739 miles · AR · fire

The contact owned a 2012 Kia Sorento. The contact stated that while the vehicle was parked and unoccupied, she was informed by an individual if she was the owner of the vehicle since it was smoking and caught on fire. Prior to the fire, unknown warning lights would illuminate and un-illuminated intermittently. The Fire Department was on the scene and extinguished the fire. The vehicle was towed to an impound lot and then towed by the insurance company. The vehicle was deemed a total loss by the insurance company. The local dealer was contacted; however, the vehicle was not repaired due to the VIN not being included in a recall at the time the failure occurred. The contact received the federal safety agency Campaign Number: 23V652000 (SERVICE BRAKES, HYDRAULIC) after the vehicle caught fire and was destroyed. The manufacturer was not made aware of the failure. The failure mileage was approximately 142,739.