I am filing this complaint regarding a sudden and unexpected engine failure in my 2012 Kia Sorento LX equipped with the 2.4L Theta II engine. Vehicle Information: Year: 2012 Make/Model: Kia Sorento LX Engine: 2.4L Theta II VIN: [XXX] While driving, my vehicle experienced a sudden engine failure and lost power, leaving the vehicle inoperable. This occurred without warning. The vehicle received routine maintenance, including regular oil changes, and the failure was not due to intentional neglect or misuse. I am concerned because this vehicle is equipped with the Kia Theta II 2.4L engine family, which has been associated with previous recalls, investigations, settlements, and numerous consumer complaints involving engine seizure, premature failure, stalling, and safety concerns. I understand my specific VIN may not currently fall within an active recall; however, my vehicle has experienced the same type of catastrophic engine failure reported by other Kia owners with similar engines. I am concerned that vehicles outside current recall VIN ranges may still be experiencing the same defect. An unexpected engine failure while driving creates a serious safety concern due to the potential for sudden loss of power and increased risk to occupants. I am requesting that the federal safety agency review whether additional 2012 Kia Sorento vehicles equipped with the 2.4L Theta II engine may be affected and whether Kia's current recall population adequately addresses the known engine failure concerns. I have also contacted Kia requesting that they review my vehicle, authorize a no-cost diagnostic evaluation, and determine whether the engine failure is related to known Theta II engine defects. [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
2012 Kia Sorento engine problems
475 complaints (54% of all complaints for this car). Typical mileage when it fails: 99,612. 2 crashes reported.
- owner complaints
- 475
- of this car's complaints
- 54%
- typical mileage
- 99,612
- crashes
- 2
- recalls
- 3
Which part fails
- Engine: oil/lubrication: sump/tank: drain plug1
- Engine: engine control module (ecu/ECM): software1
At what mileage
Complaints by mileage at the time of the problem.
Kia Sorento engine problems in other years
Specific symptoms reported on the 2012 Kia Sorento engine
Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.
Engine failure 157Stalling 130Check engine light 113Knocking 86Loss of power 46Oil consumption 33Won't start 26Overheating 9
Related recalls
Engine
- What is wrong
- Kia Motors America (Kia) is recalling certain 2012-2013 Sorento, 2012-2015 Forte and Forte Koup, 2011-2013 Optima Hybrid, 2014-2015 Soul, and 2012 Sportage vehicles. An engine compartment fire can occur while driving.
- Risk
- An engine compartment fire increases the risk of injury.
- Remedy
- Kia will notify owners, and dealers will inspect the engine compartment for fuel and/or engine oil leaks, perform an engine test and make any repairs, including engine replacement, as necessary, free of charge. In addition, Kia dealers will update the Knock Sensor Detection System (KSDS) software, free of charge. The recall began January 27, 2021. Owners may contact Kia customer service at 1‑800‑333‑4542. Kia's number for this recall is SC200.
Recall number 20V750000 · Recall details
Engine
- What is wrong
- Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V‑224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
- Risk
- A fuel leak in the presence of an ignition source can increase the risk of a fire.
- Remedy
- Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1‑800‑333‑4542. Kia's number for this recall is SC172.
Recall number 18V907000 · Recall details
Engine and engine cooling: engine
- What is wrong
- Kia Motor Company (Kia) is recalling certain 2011-2014 Optima, 2012-2014 Sorento and 2011-2013 Sportage vehicles. Machining errors during the engine manufacturing process may cause premature bearing wear within the engine.
- Risk
- Bearing wear may result in the engine seizing, increasing the risk of a crash.
- Remedy
- Kia will notify owners, and dealers will inspect the engine assembly, and replace the engine if necessary, free of charge. The recall began June 20, 2017. Owners may contact Kia customer service at 1‑800‑333‑4542. Kia's number for this recall is SC147.
Recall number 17V224000 · Recall details
Related investigations
Loss of Motive Power
the federal safety agency received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitionersâ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODIâs evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to the federal safety agency which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. Â There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in the federal safety agency's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, the federal safety agency does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing the federal safety agencyâs reasons for denial of the petition will be published. The reference numbers for the complaints to the federal safety agency cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to
DP22003
Engine Fires
On March 29, 2019, the Office of Defects Investigation (ODI) opened two Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) to broadly investigate incidents of non-crash fires (regardless of origin or operational status of the vehicle) on various model year Hyundai and Kia vehicles. During the PE investigations, Hyundai and Kia issued several recalls to address vehicle fires, including those due to engine failures involving various engine types. The remedies for the engine failure recalls typically involve engine inspection (to detect existing damage), and if necessary, engine replacement. Additionally, both manufacturers have been installing an engine control software modification known as Knock Sensor Detection Software (KSDS) which is intended to detect impending engine failure, alert the driver, and limit engine power (to lessen likelihood of engine failure).KSDS is being installed under recalls and non-safety field actions, and both companies have extended limited engine warranties (see recall files). On December 22, 2021, ODI upgraded PE19-003 and PE19-004 to this Engineering Analysis (EA21-003, covering both Hyundai and Kia) to evaluate the scope of the prior recalls related to engine failures/fires and the efficacy of the recall remedies for the recalls, as well as the long-term viability of related programs and non-safety field actions being conducted by Hyundai and Kia. The former issue involved approximately 550,000 MY 2013 Hyundai Elantra, MY 2011 Kia Sorento, and MY 2012-2015 Kia Rio. The latter issue involved approximately 2.5 million recalled vehicles, which have been identified as displaying potential remedy concerns: Hyundai recalls 15V‑568, 17V‑226, 20V‑746, and 21V‑727; and Kia recalls 17V‑224, 19V‑120, 20V‑750, and 21V‑844. Regarding the recall scope issue, among all of the scope vehicles identified at EA opening, ODI found only the MY 2011 Kia Sorento vehicles equipped with both the Theta II 2.4L 4-cylinder Multi-Point Injection (MPI) and the Lambda II 3.5L 6-cylinder MPI engines experienced relatively high rates of reported fires. In December 2023, Kia issued recall 23V‑877 that will cover about 80,000 MY 2011 Kia Sorento vehicles equipped with the Theta II 2.4L MPI engines.  The remedy will involve an inspection, and if necessary, a replacement of the engine, as well as the installation of KSDS.  It should be noted that in 2021 these vehicles were included in a KSDS product improvement campaign with warranty extension. For the MY 2011 Sorento vehicles equipped with the Lambda II 3.5L engines, ODI believes that future engine failures/fires involving these vehicles will likely be due to a lax in adhering to the proper or scheduled engine maintenance (regular engine oil changes), rather than a design or manufacturing engine issue. Regarding the issue of the efficacy of the recall remedies, ODI found the majority of the recalled Hyundai and Kia vehicles, by model, experienced lower reported fire rates after the remedies were applied. Furthermore, ODI found that for most vehicles that did not receive the recall remedies, by model, experienced relatively high fire rates. To address this problem, Hyundai informed ODI in December 2023, that it will renotify all of its owners covered by the Hyundai recalls of engine failures/fires every 8 months for the next 3 years. In December 2023, Kia stated that it will renotify the majority of its owners every 8 months for the next 3 years.Several previously recalled Kia models are excluded from the renotification due to their lower reported rates of engine fires. Overall, the renotification actions will help to increase the recall completion rates, thus reduce the frequency of engine fires in the future. In view of the recall action being taken by Kia and renotification actions being taken by both Kia and Hyundai, ODI is closing this Engineering Analysis. Also, both companies have been released from the 2020-iniated Consent Orders (Kia since November 2022 and Hyundai since November 2023). The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to
EA21003
Scope and Timeliness
the federal safety agency opened Recall Query (RQ) 17-003 to investigate the timeliness and scope of Kia?s Theta II GDI engine recall (Recall No. 17V‑224), and Kia?s compliance with reporting requirements. On November 23, 2020, the Agency entered into a Consent Order with Kia to administratively resolve the federal safety agency?s assertions of violations of law in connection with RQ17-003. the federal safety agency?s assertions included that Kia may be liable for civil penalties on multiple grounds, including that Recall No. 17V‑224 was untimely and Kia?s recall report contained certain inaccuracies.Under the Consent Order, Kia agreed to a total civil penalty of $70,000,000. The total civil penalty included a payment of $27,000,000 as a Non-Deferred Amount.Kia also agreed to a sum of $27,000,000 as an Abeyance Amount to be deferred and held in abeyance pending its satisfactory completion, as reasonably determined by the federal safety agency, of the requirements of the Consent Order.Kia also agreed to a $16,000,000 Performance Obligation Amount to be expended by Kia to fulfill specified Safety Data Analytics Infrastructure obligations. The Consent Order also includes other terms designed to enhance Kia?s safety practices, and requires Kia to retain a Third-Party Auditor who directly reports to the federal safety agency.Other than RQ17-003, the Consent Order is not intended to affect any other current or future investigation of the federal safety agency which may involve vehicles equipped with Theta II GDI engines. In particular, Engineering Analysis (EA) 21-003 (which is upgraded from Preliminary Evaluation (PE) 19-004) continues the federal safety agency?s evaluation of certain performance and design issues relating to the Theta II and other engines.Nothing in the Consent Order discharges Kia from any obligation to comply with the Safety Act or regulations thereunder, including the obligation to carry out recalls in accordance with the law, and to initiate a recall upon any future determination by Kia, or upon any finally adjudicated order from the federal safety agency, that vehicles equipped with Theta II GDI engines contain a defect related to motor vehicle safety or do not comply with an applicable FMVSS.This RQ is closed. Closure of this RQ has no bearing on the terms of the Consent Order, including Kia's ongoing performance obligations, and does not represent a determination by the agency as to Kia's performance under the Consent Order to date.
RQ17003
What 2012 Kia Sorento owners say
Most recent owner complaints, unedited.
The contact owned a 2012 Kia Sorento. The contact’s spouse stated that while driving at an undisclosed speed, the vehicle suddenly lost motive power with no warning lights illuminated. The contact's spouse noticed smoke coming from the front of the vehicle, prompting the contact’s spouse to pull over to the side of the roadway. Moments later, the front of the vehicle caught fire. The local fire department responded to the scene and extinguished the fire; however, the cause of the fire had not yet been determined. The vehicle was completely consumed by the fire and deemed destroyed. No police report was filed, The manufacturer was not notified of the failure. The contact’s spouse stated that the incident was extremely traumatic and believed the vehicle posed a serious safety hazard. The failure mileage was not available.
The clock spring needs fixed no features including the horn is working in my airbag light is staying on. Also I now have a loud knock in my motor I understand this should fall under the extended 15 yr 150k warranty; 2012 Kia vehicles (specifically the Sorento) with V6 engines are covered under major safety recalls for engine failure and fire risks. The primary issue involves metal debris from manufacturing that can cause premature engine bearing wear, stalling, and fire. You should check your VIN on the federal safety agency site or Kia's recall page to confirm, as these recalls are still active.
Engine warning lamp illuminated as the engine lost some power. Code was diagnosed as the knock sensor issue. Unit taken to mechanic to evaluate and diagnose. Repair shop notified us that based on the sensor, the engine could succumb to a failure at any time. Engine oil was flushed, cleaned, and replaced. Code was addressed currently. This is similar to the failures observed by other engines in this class, however, it does not appear this engine is part of the lifetime warranty or recall.
The contact owns a 2012 Kia Sorento. The contact stated that while driving 75 MPH, the check engine warning light was flashing on the instrument panel. There was a misfire coming from the engine. The contact stated that the vehicle was sputtering while depressing the accelerator pedal and cautiously drove to the nearest independent mechanic. The mechanic used a code scanner and retrieved a fault code for an inoperable knock sensor and wiring harness. The vehicle was also taken to another independent mechanic who provided the same information. The dealer was notified of the failure, and the contact was informed that there were no recalls on the vehicle. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was unknown.
Engine Knocking - Car enters limp mode and has a known recall. KSDS was updated in prior recall and engine has failed at 118k Miles. Car has been well maintained. Kia asks for maintenance records, records were provided and they will not take action. KIA avoided fixing the engine and just updated software to tell you when this happens and now that the engine is failing will not honor their warranty or do work on the car despite sending maintenance records of over 10 years
The contact owns a 2012 Kia Sorento. The contact stated that after parking and turning off the vehicle, she entered the post office; after 3 to 4 minutes, she was alerted by a consumer that the vehicle had caught fire. The contact noticed fire emerging from the undercarriage. The TPMS warning light had been illuminated prior to the incident. Post office employees attempted to extinguish the fire. The fire department was called and successfully extinguished the fire. There were no reported injuries. Police were also present at the scene. The contact related the failure to the federal safety agency Campaign Number 23V-652000 (Service Brakes, Hydraulic). The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted; however, no assistance was provided. The failure mileage was approximately 200,000.
The contact owns a 2012 Kia Sorento. The contact received notifications of the federal safety agency Campaign Numbers: 20V750000 (Engine) and 23V652000 (Service Brakes, Hydraulic); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The contact stated that while driving into a parking spot, the vehicle suddenly lost power and stalled. The contact later replaced the battery, but the vehicle failed to start. The vehicle was towed to a certified mechanic, who diagnosed the vehicle with engine failure. The vehicle was not repaired. The manufacturer was informed of the failure and informed the contact that, due to the vehicle not having the sensor changed before the failure, the engine could not be replaced. The dealer informed the contact tha,t due to the mileage, the vehicle would not be covered and would not qualify for the extended warranty coverage for the engine replacement. The failure mileage was approximately 250,000.
The contact owns a 2012 Kia Sorento. The contact stated that the rod bearings were knocking, and the check engine warning light was illuminated. The contact received notification of the federal safety agency Campaign Numbers: 15V626000 (Power Train), 23V652000 (Service Brakes, Hydraulic), and 20V750000 (Engine). The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The contact called the warranty company which declined the repairs. The failure mileage was approximately 106,000.
The contact owns a 2012 Kia Sorento. The contact stated that her son had reported that the vehicle was losing motive power and had failed to exceed 15 MPH while driving. The check engine warning illuminated. The contact advised the driver to pull over and to stop the vehicle. The vehicle was towed to a local dealer, who diagnosed the vehicle and advised that the engine had failed the engine bearing test and several other engine tests. The contact was advised that the vehicle could not be driven. The contact advised the dealer that in 2024, the same dealer had performed the recall of the federal safety agency Campaign Number: 20V750000(Engine) on the vehicle. The dealer informed the contact that the vehicle qualified for a manufacturer program for engine replacement. The manufacturer was informed of the failure and advised the contact that the dealer would be contacted, but no further action was taken. The failure mileage was approximately 160,000.
Questions about the 2012 Kia Sorento engine
Does the 2012 Kia Sorento have engine problems?
Owners have filed 475 complaints about the engine of the 2012 Kia Sorento, 54% of all its complaints, more than any other problem.
At what mileage do 2012 Kia Sorento engine problems start?
The typical (median) mileage in owner complaints is 99,612 miles.
Was there a recall on the 2012 Kia Sorento engine?
Yes, 3 recalls: 20V750000, 18V907000, 17V224000. Check your VIN to see if your car still needs the free repair.
What year does the Kia Sorento have bad engine?
The Kia Sorento model years with the most engine complaints are 2016 (722 complaints), 2013 (516 complaints) and 2012 (475 complaints).
Other 2012 Kia Sorento problems
Electrical 127Brakes 103Airbags 81Lights 60Transmission 55Fuel system 39Body 35Acceleration 29Visibility 28Suspension 22Steering 20Driver assistance 18Seats 15Wheels 5Seat belts 4Locks 1Tires 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 2012 Kia Sorento?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history