2014 Kia Sorento brakes problems

Filed Nov 4, 2026 · Brakes, Electrical · 120,000 miles · AZ · fire

The contact owns a 2014 Kia Sorento. The contact received notification of the federal safety agency Campaign Number: 23V652000 (Service Brakes, Hydraulic). The contact stated that while the vehicle was parked and turned off overnight, an underhood might have fire occurred. While inspecting the vehicle the following day, the contact discovered a large hole in the battery, burned underhood components, and melted wiring harness sections on the battery terminal and engine. The contact stated that an overheated fuse might have caused the fire, which might have been extinguished overnight by the heavy rain. The vehicle was towed to the dealer; however, the vehicle was not diagnosed or repaired. The dealer informed the contact that the dealer would only replace the HECU fuse under the recall, and the contact was responsible for all additional repair costs. The dealer informed the contact that if diagnostic testing could not be completed, the contact was required to remove the vehicle from the dealer lot. The contact stated that prior to the underhood fire, the vehicle lost motive power while driving and failed to restart. The vehicle was towed to the contact's residence. The manufacturer was notified of the failure by telephone. The failure mileage was approximately 120,000.

Filed Aug 28, 2026 · Brakes, Electrical · HI

I am filing an official safety complaint against the manufacturer for refusing to perform federally mandated safety recall repairs on my vehicle. My vehicle is impacted by critical safety recalls involving high-severity fire risks, specifically the Hydraulic Electronic Control Unit (HECU) electrical short circuit risk. Corporate Customer Care and my local authorized dealership have officially refused to schedule or perform these safety recall repairs. The representatives explicitly stated that my vehicle is denied service because I purchased it used from a third-party private owner, and because I do not possess complete historical maintenance records. The manufacturer is conflating civil class-action lawsuit requirements with federally mandated safety recalls. Under the National Traffic and Motor Vehicle Safety Act, a manufacturer cannot legally condition or deny an active, free safety recall repair based on a vehicle's third-party purchase history or maintenance records. Due to poorly trained employees at both the dealership and customer care offices, I have faced constant misinformation that has wasted an immense amount of my time. Because this non-compliance has caused a severe safety hazard to drag on for an extended period, I am also requesting that a loaner vehicle be provided immediately until this vehicle is made safe to drive. The manufacturer has logged these denials and communications under an active corporate file, which I can provide directly to investigators upon request. I request that the federal safety agency investigate this non-compliance and instruct the manufacturer to immediately authorize the local service center to perform all open fire safety recall remedies without cost or penalty.

Filed Jul 23, 2026 · Brakes, Electrical · GA

This is a follow up of the federal safety agency case# 1840444. Complaint Description: Vehicle exhibited active CAN-bus communication timeout code DTC C1642 targeting the Hydraulic Electronic Control Unit (HECU). Following the official technical safety guidelines established under the federal safety agency Campaign 20V519000 (Kia SC197), an isolated parasitic current draw test was performed between the engine junction box positive power post and the ABS2 circuit terminal. Testing across three independent iterations utilizing a digital multimeter confirmed a continuous localized parasitic draw of 218.6 uA. This dramatically exceeds the manufacturer's maximum safety engineering threshold of 70.0 uA by over 312%. This quantified excessive amperage draw conclusively isolates an internal circuit board short-circuit condition caused by a failure of the internal HECU brake fluid seals. The vehicle presents an immediate network communication failure, brake malfunction, and thermal/fire risk. Kia Corporate must be compelled to immediately authorize an expedited, zero-cost component replacement under the active safety recall mandate.

Filed Jul 11, 2026 · Brakes, Electrical · GA

This is a follow up submission to the federal safety agency case #XXX. Organization Under Complaint: Hutchinson Kia, [XXX] Complaint Summary: The dealership is utilizing unfair and deceptive financial gating practices to avoid its legal obligations under a federal safety recall. The dealership refuses to look at or evaluate a vehicle subject to an urgent fire-risk HECU safety recall unless the consumer first authorizes a $189.00 diagnostic fee. The dealership refuses to give a firm, legally binding commitment that this fee will be waived for a confirmed recall component. Instead, they require the consumer to assume all financial risk upfront, stating the fee will only "likely" be waived based on their own internal, unverified findings. This creates a high-pressure trap where the consumer is forced to sign away financial rights to access a free, federally mandated safety remedy. The dealership is weaponizing a acute shortage of independent import and specialized repair facilities in the Macon, GA market. They are aware consumers have almost no local alternative venues to get an independent, affordable cross-check scan, and are using this regional monopoly to coerce consumers into signing open-ended diagnostic authorizations. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jun 10, 2026 · Brakes · 103,000 miles · TX

The contact owns a 2014 Kia Sorento. The contact stated that while driving on several occasions at various speeds, the brake pedal was depressed and traveled further than normal intermittently. The vehicle was taken to an independent mechanic, where the failure could not be replicated. The vehicle was then taken to a dealer, where it was diagnosed that the HECU had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 103,000.

Filed Jun 4, 2026 · Brakes · 157,000 miles · AR · fire

The contact owned a 2014 Kia Sorento. The contact stated that while driving at 10 MPH, smoke emanated from the vehicle's hood. There was no warning light illuminated. The contact coasted to a driveway and attempted to open the hood when the vehicle became engulfed in flames. The vehicle was consumed by the fire. There was no injury sustained. The local Fire Department was contacted and extinguished the fire, and a fire report was filed. The fire report was provided. The vehicle was towed to the tow lot and deemed a total loss. The contact stated that the dealer was not contacted. The contact was provided notification of the federal safety agency Campaign Number: 23V652000 (SERVICE BRAKES, HYDRAULIC); by the Fire Department. The contact notified the manufacturer about the failure stated in the recall. The contact stated that the manufacturer sent a technician to inspect the vehicle. The failure mileage was approximately 157,000.

Filed Nov 6, 2025 · Brakes, Engine · 80,000 miles · CO

The contact owns a 2014 Kia Sorento. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. No warning lights were illuminated. In addition, the contact stated there was condensation coming out of the exhaust pipes. The contact was stopped by another driver and was informed that the condensation coming out of the exhaust smelled like a bakery. The vehicle was taken to the dealer; however, the vehicle was not inspected. The contact was informed that a diagnostic test was needed and was provided with the cost of the diagnostic test. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact received notifications of the federal safety agency Campaign Number: 17V224000 (Engine and Engine Cooling) and the federal safety agency Campaign Number: 21V331000 (Service Brakes, Hydraulic). The manufacturer was made aware of the failure but provided no assistance. The contact was informed that a diagnostic test needed to be performed and that there was a cost for the diagnostic test. The failure mileage was approximately 80,000.

Filed Jun 19, 2025 · Brakes, Engine · TN

I have had nothing but issues with my Kia since I purchased it May 30th, 2023. It's continually stalling, completely looses power, sometimes won't operate at all. My Kia is very unsafe and completely unreliable. I had to have it towed to the dealership before my first payment was even due. My Kia has has to be taken to the dealership a total of 5 times and still nothing has been resolved, other than oil change, diagnostic testing, spark plugs replacement, "fuel system service", HECU fuse installed. As of today's date (June 19th, 2025) I still owe close to $12,000 on it. This is utterly ridiculous and needs to be resolved asap. It has been continual issues from May 30th, 2023 through current date (June 19th, 2025). In 15 months I have only been able to drive it 4,876 miles. That's how unreliable it is. I need help getting these issues resolved asap.

Filed Apr 1, 2025 · Brakes, Engine · 147,000 miles · AL

The contact owns a 2014 Kia Sorento. The contact stated while starting the vehicle, there was a ticking sound coming from the vehicle. Later, on the same day, while pulling into a friend’s driveway, the engine began making a knocking sound. The contact decided to drive to the residence nearby, and the engine started knocking again, eventually causing the engine to fail and the vehicle to lose motive power. The check engine warning light was illuminated. The vehicle was towed to the dealer who diagnosed that the rods had failed due to excessive rust, causing the rods to knock. The dealer stated that the engine needed to be replaced; however, the vehicle was not yet fully inspected or diagnosed. The contact informed the dealer that the VIN was included in the federal safety agency Campaign Number: 23V652000 (Service Brakes, Hydraulic) and asked that the recall repair be completed; however, the dealer had not confirmed completion of the recall repair. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case. The failure mileage was 147,000. Parts distribution disconnect.

Filed Mar 14, 2025 · Brakes, Steering · OK

All of it. Car randomly shuts off and lose power steering. No. Dealership has inspected. ALL the lights in the dash light up, screen says battery discharge warning, car shuts off and lose power steering while driving down the road.