Kia Sorento grinding brakes problems

Filed Jul 21, 2026 · Visibility · NY

The panoramic sunroof on my 2023 Kia Sorento intermittently fails to close. When commanded to close, the glass travels most of the way, then stops or reverses before reaching the fully closed position. It frequently takes many repeated attempts. In some cases the panel will not seat at all until the vehicle is driven over rough pavement, and the resulting vibration allows it to complete closure. The malfunction is accompanied by a loud grinding or scraping noise from the roof assembly during travel. This condition has been present since I purchased the vehicle new. The sunroof has seen very limited use. Safety risk: the glass panel cannot be reliably secured. An open or unseated panoramic panel at highway speed presents a risk of water intrusion, wind loading on an unsecured glass panel, and loss of roof structure integrity. Repeatedly operating the switch and monitoring the panel while driving is a significant distraction from the driving task, and driving specifically to induce vibration in order to force closure is itself an unsafe workaround. Dealer history: I have reported this to a Kia dealership on multiple occasions. I was told there is no defect and that the cause is debris, which is inconsistent with a vehicle purchased new with minimal sunroof use. On one visit the dealer cleaned the assembly as a goodwill gesture. This did not correct the noise or the closure failure. The vehicle was returned to me as repaired while the noise and the failure to close were both still present. Kia issued Technical Service Bulletin BOD125 (Rev 1, 02/27/2017) describing a slow-to-close condition and abnormal closing noise on the prior-generation Sorento (UMa), remedied by cleaning and lubricating the rear guide rails and replacing the rear tilt levers. My vehicle exhibits the same failure mode described in that bulletin. The component is available for inspection on request. No warning lamps or messages preceded or accompanied the failure.

Filed Jul 9, 2026 · Steering · 19,000 miles · FL

The contact owns a 2020Â Kia Sorento. The contact stated that while driving 30 MPH with her daughter and parents in the vehicle, an abnormal squeaking sound was heard emanating from the steering wheel. No warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the steering column needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but the repair was delayed because the manufacturer required information from the dealer, while the dealer claimed to be waiting for a response from the manufacturer. The failure mileage was 19,000.

Filed May 11, 2026 · Engine · CT

I am submitting this complaint regarding a 2019 Kia Sorento that has experienced recurring oil loss/oil starvation and engine-related issues that I believe may present a safety concern. I purchased the vehicle used with approximately 45,000 miles. Since ownership, the vehicle has experienced repeated incidents involving low or nearly empty oil levels despite regular maintenance and monitoring. The vehicle previously underwent an oil consumption evaluation, however the issue continued afterward. During one event, the vehicle was reportedly found approximately three quarts low on oil. More recently, the vehicle again appeared to have little to no oil visible on the dipstick and began exhibiting drivability and engine concerns including grinding/banging noise during acceleration, intermittent timing/tensioner-type noise, misfires on cylinders 1 and 2, exhaust smoke, and strong oil-burning odor from the exhaust. Due to concern over possible engine damage and reliability, the vehicle was returned to the dealership for further diagnosis and repair. The dealership replaced ignition coils and spark plugs and road tested the vehicle extensively. While the vehicle is currently operating, I remain concerned that the underlying oil consumption/oil starvation condition may not have been permanently resolved. My concern is that repeated oil starvation conditions could potentially lead to sudden engine failure, loss of power while driving, or other safety-related issues. I am requesting that this issue be reviewed to determine whether similar complaints or defects exist involving oil consumption, oil starvation, or related engine failures in this vehicle.

Filed Mar 20, 2026 · Electrical, Engine · OK

My vehicle completely shut off while I was driving with my children in the car. The dealership replaced the battery but never identified the root cause. Since then my car has been experiencing RPM surging while in Park — the engine revs up and down repeatedly on its own. The vehicle also feels sluggish and does not want to accelerate properly while driving. Additionally since taking ownership of the vehicle my window has squealed every time it rains and I roll down the window. The dealership has replaced the seals, lubricated and cleaned the window multiple times and the problem persists. The defective window seal also caused a gash in my window tint requiring replacement. I have taken my car to my Kia dealership multiple times and they have been unable to fully resolve these issues. My car is currently at the dealership right now and they still cannot find the problem. I contacted Kia Corporate on March 20, 2026 and opened a formal case. These defects have put my children in danger and I am requesting a formal federal investigation.

Filed Mar 12, 2026 · Brakes, Driver assistance · MO · crash

Driving 40 mph coming around a bend. There was a car stopped about to rear off to the left and when coming up around the turn I saw and tried to stop. I was about two car lengths behind the car when I pressed the brake down and I pushed it all the way down and nothing happened. It was grinding and shaky when pressing it down. Not tight or anything. I feel like I normally would have that tension right away to be able to stop. There was no warning or anything and the car always has warnings when something is close.

Filed Feb 14, 2026 · Electrical, Suspension · IA

My kia Sorento shocks are really bad seems like it bounces Alot More than normal and heard a squeak coming from the shocks also hard to get the to turn when Im park and electric seems to glitch with bulbs going out faster and radio acting like it shorting out since the wiring was replaced it does this

Filed Oct 28, 2025 · Electrical · CA

On October 26, 2025, Sunday, I was cleaning my windows. I discovered both rear windows would not roll up or down. I took it to Valley KIA on October 27, and it was diagnosed that I needed to replace both rear windows with new window regulator. It will be installed on October 29. I told my tech advisor about the window regulator recall on the 2017 KIA Optima and Sportage. He told me there was no recalls on the 2017 Sorento. I had to pay out of pocket to have my vehicle repaired. How could my rear window regulator fail within 4 years? It seems really perplexing for both rear windows to fail at the same time. How can I recover the cost of repairs - because 2017 KIA Optima and Sportage had the same problems. On October 22, 2025, Wednesday, I took my car to KIA Riverside regarding a voluntary recall for a multi-function switch. The rear window regulator behind the front passenger side failed on May 24, 2021. I took my 2017 KIA Sorento to Valley KIA, Fontana. The mechanic made the diagnose and replaced with new window regulator and it was installed on May 25, 2021. It poses a safety hazard if baby, children or adults are in the back seat, and windows does not roll up or down unexpectedly. It is a safety hazard when I cannot secure my vehicle. It is a safety hazard if I had things in the back seat, and it would fly out the window. It is a safety hazard when unable to open or close the window when it is hot, cold, or raining. There was no warning prior to failure. I just heard a grinding like sound, or like sound of plastic breaking when I pushed the button on driver seat to lower or try to roll the window back up.

Filed May 14, 2025 · Engine, Transmission · 56,941 miles · FL

The contact owns a 2022 Kia Sorento. The contact stated while driving approximately 60 MPH, the vehicle started losing motive power. The contact stated that the accelerator pedal was depressed; however, the engine revved without the vehicle responding as needed. The contact stated that the check engine warning light was illuminated. The contact pulled over and turned off, and restarted the vehicle, and was able to drive the vehicle to the local dealer. The dealer diagnosed the vehicle and determined that a cylinder was clogged, and the engine needed to be serviced. The vehicle was repaired; however, the contact stated that later while driving approximately 40 MPH, the vehicle started losing motive power. The contact stated that the "Service Transmission" warning light was illuminated. The contact had taken the vehicle back to the same dealer where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was repaired. The contact drove the vehicle back to the residence, restarted the vehicle, and shifted into reverse(R), and the contact heard an abnormal grinding sound with the "Transmission System Error" message displayed. The contact had the vehicle towed to the same dealer; however, the vehicle was not yet diagnosed or repaired. The manufacturer was informed of the failure. The contact researched online and related the failure to the federal safety agency Campaign Number: 22V760000 (Power Train); however, the VIN vehicle was not included. The failure mileage was 56,941.

Filed Nov 9, 2024 · Engine · SC

Driving down the interstate to pick my children up from school and all of a sudden the car made a weird bubbly grinding sound and stopped accelerating. I had to pull off and park as the car would not go any further. My vehicle has had regular maintenance and oil changes since I purchased it. I had in fact just put a full quart of oil in it. The first mechanic stated that there was metal shards in the oil. In between oil changes, I have to add several quarts of oil because it seems to just disappear. There’s no oil leak yet the oil would be almost completely gone not even a full month after a complete oil change. My car has currently been sitting at the Kia dealership for a lot now waiting for repair. I paid for the extended warranty yet. Kia is dragging their feet and won’t even offer me a rental car while I wait for my car to be repaired, no one returned my calls. No one updates me on what’s going on. I am fed up.

Filed Oct 31, 2024 · Brakes · 63,750 miles · FL

The contact owns a 2018 Kia Sorento. The contact stated while coming to a stop, there was a loud grinding sound coming from the brakes while the brake pedal was depressed. There was no warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the brake pads had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 63,750.