2023 Kia Sorento: grinding or squealing brakes

Filed Jul 21, 2026 · Visibility · NY

The panoramic sunroof on my 2023 Kia Sorento intermittently fails to close. When commanded to close, the glass travels most of the way, then stops or reverses before reaching the fully closed position. It frequently takes many repeated attempts. In some cases the panel will not seat at all until the vehicle is driven over rough pavement, and the resulting vibration allows it to complete closure. The malfunction is accompanied by a loud grinding or scraping noise from the roof assembly during travel. This condition has been present since I purchased the vehicle new. The sunroof has seen very limited use. Safety risk: the glass panel cannot be reliably secured. An open or unseated panoramic panel at highway speed presents a risk of water intrusion, wind loading on an unsecured glass panel, and loss of roof structure integrity. Repeatedly operating the switch and monitoring the panel while driving is a significant distraction from the driving task, and driving specifically to induce vibration in order to force closure is itself an unsafe workaround. Dealer history: I have reported this to a Kia dealership on multiple occasions. I was told there is no defect and that the cause is debris, which is inconsistent with a vehicle purchased new with minimal sunroof use. On one visit the dealer cleaned the assembly as a goodwill gesture. This did not correct the noise or the closure failure. The vehicle was returned to me as repaired while the noise and the failure to close were both still present. Kia issued Technical Service Bulletin BOD125 (Rev 1, 02/27/2017) describing a slow-to-close condition and abnormal closing noise on the prior-generation Sorento (UMa), remedied by cleaning and lubricating the rear guide rails and replacing the rear tilt levers. My vehicle exhibits the same failure mode described in that bulletin. The component is available for inspection on request. No warning lamps or messages preceded or accompanied the failure.

Filed Jan 2, 2024 · Steering · 1,328 miles · TX

The contact owns a 2023 Kia Sorento. The contact stated while driving 45 MPH, there was an abnormal squealing sound coming from the steering wheel and the steering wheel was difficult to turn. There was no warning light illuminated. The vehicle was taken to the dealer to be diagnosed. The contact stated that the vehicle received an unstated repair; however, the failure persisted. The manufacturer was made aware of the failure. The approximate failure mileage was 1,328.

Filed Jan 2, 2024 · Steering · 2,400 miles · VA

The contact owns a 2023 Kia Sorento. The contact stated while driving 35 MPH, there was squealing sounds coming from the steering wheel and the steering wheel was difficult to turn. The contact stated that several system warning lights illuminated and the check lane departure warning, check speed limit, check high beam assist, and check driver attention messages were displayed. The vehicle was taken to the dealer to be diagnosed but was not repaired. The contact stated that the failure persisted. The manufacturer was made aware of the failure. The approximate failure mileage was 2,400.

Filed Dec 14, 2023 · Steering · WA

While driving there is a loud squeak that is coming from the steering column on the left side. The dealerships cannot reperform because it only happens about 60% of the time when driving. We have brought the vehicle in twice now and both times the dealership could not recreate the noise. Many people are having the same issue with the 2022 and 2023 Kia models. They have speculated on what is causing the sound. One individual that was able to get their dealership to work on it said their dealership had to replace the "power pack" which is a steering column control module. Another individual said that their dealership had to emergency order a new steering column to replace it. Each of these makes me believe that there is an issue that Kia is not addressing that is putting the lives of drivers at risk. If the steering control module goes out while driving it could cause the driver to be unable to turn normally and cause an accident, or if something breaks within the steering column that restricts the movement of the steering wheel an individual could go off the road or hit someone. Steering issues are extremely dangerous to the driver and the general public, so I am hopeful that this will help get the ball moving on finding out what is going on with these steering columns before a serious accident occurs. Thank you.

Filed Nov 19, 2023 · Driver assistance, Steering · TX

Made several attempts to fix squeaking and rattling in steering column when lane keep assist is engaged. Dealership vehicle was purchased from notified me " we cannot replicate the problem", after driving my vehicle 59 miles. I sent multiple of the issue via email and text message. Finally, the service manager agreed to let her shop foreman do a ride along. At this time, Demontrond Kia acknowledged there was an issue. Demontrond Kia diagnosis was " Found vapor lines vibrating on brake lines causing the noise from steering wheel." Kia technicians re-routed vapor lines from brake line and test drove the vehicle another 89 miles. Two days later the same exact issue was still present. At this time, the Service manager has yet to respond back to me. I sent a request for an appointment to take care of the reverse camera recall through the kia access app twice after emailing the Service manager. I still have not heard a response.