2019 Kia Soul: engine failure

Filed Oct 19, 2026 · Engine, Transmission · OH

Engine seized while driving with no warning. Dealer has submitted findings to kia corporate techline for powertrain warranty claim which is requesting a $700 engine teardown at my expense

Filed Jul 28, 2026 · Engine · 59,000 miles · OH

The contact owns a 2019 Kia Soul. The contact stated that while driving at an undisclosed speed, there was a burning odor and smoke coming from the exhaust pipe. Additionally, the engine was consuming an excessive amount of engine oil. The contact pulled over and checked the engine oil level, and the dipstick indicated that the engine oil level was extremely low. The contact stated that engine oil was added to the engine. The vehicle was taken to the dealer, where it failed the oil consumption test; however, the manufacturer declined to replace the engine and informed the contact that the vehicle was not covered under warranty. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 59,000.

Filed Jul 14, 2026 · Engine · PA

I was driving through a busy intersection when the vehicle stopped accelerating causing risk to myself and other drivers. I was able to get the vehicle through the intersection and pulled over. I turned the vehicle off and it would not restart. I had the vehicle towed to my local independent service center where a diagnostic was performed. It was found to be engine failure due to the connecting rod to the pistons. It resulted in a loud rod knock and white smoke from the engine. There were no warning lights or sounds or quality of driving prior to the failure until the vehicle suddenly stopped accelerating. Vehicle was regularly maintained. Kia is currently in a lawsuit due to engine failure but does not include my VIN even though it experienced the same exact cause of engine failure as many of their other vehicles. The vehicle has not been inspected by the manufacturer, police, or insurance representives.

Filed Apr 25, 2026 · Engine · OH

On [XXX], while my vehicle was at the dealership for a federally mandated engine replacement recall (Campaign PI2107Y/Z), the service department attempted to obstruct the completion of the safety repair. The dealership informed me that unless I paid a 264.40 fee for maintenance and fluids, they were required by the manufacturer to drain the old, contaminated coolant from my failed engine and reuse it in the brand-new replacement engine. This threat of intentional contamination poses a severe safety risk, as reusing old fluid from a failed engine can lead to premature engine failure or overheating, potentially creating another hazardous situation on the road. I contacted the manufacturer corporate office (Case [XXX]), and they confirmed that no such requirement to reuse old coolant exists and that the dealership had not even attempted to file a claim for fluids. The dealership misrepresented manufacturer policy to monetize a free safety recall and threatened to sabotage the integrity of the new engine to force a sale. This issue was confirmed to be a dealership-level fabrication by the manufacturer’s corporate customer service line. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 19, 2026 · Engine · TX

Engine has 86k miles and has been well maintained. Recently it started to consume oil rapidly as per last oil change report. We took it to dealership after oil change mechanic suggested needing to have problems looked at per Kias recent service bulletins on high oil consumption issues. I requested the car be evaluated for the oil issue and the dealership service tech confirmed "engine damage DUE TO high oil consumption" but would not perform oil consumption test. The particular vin is not included in current recalls or bulletins but has the same engine as other model years that are in the recall/bulletins for engine oil consumption. Dealership suggests engine replacement but the car is out of warranty because it changed owners before 100k miles. I have opened a case with kia and, to date, they continue to deny the engine replacement due to car being out of warranty. This oil consumption issue is a MAJOR SAFETY RISK and ALL KIAS HAVING THIS ENGINE ISSUE should be offered replacement by Kia, assuming regular maintenance is proven. Other Kias with this same engine are being replaced at Kias expense but Kia is trying to save money by only approving certain year models, leaving thousands of Kia owners left at having to replace engines at the owners expense (over $9000 dollars) when the car itself is no longer worth barely half of that cost. the federal safety agency needs to step in to protect the consumers and issue a bulletin for any Kia model having this type of oil consumption issue before more people die or suffer major breakdowns and wrecks from car fires or engine lock ups.

Filed Apr 14, 2026 · Engine · IL

I have always taken my 2019 Kia Soul to the dealership in Quincy IL, where I had purchased it from as the first and only owner. I have recently drove it to work and it made an awful noise and started to run rough. Upon taking it to the dealership I learned that cylinder number 3 had blown and even melted the coil pack connector boot to the spark plug. It has used more oil than usual over the years in-between oil and filter changes. Since this problem has occurred, I have learned that the engine manufacturer has had similar issues with engine failure in multiple models. Including 2019 Kia Soul such as mine. I would like for it to be replaced under the same settlement for this engine type and it's flaws.

Filed Nov 29, 2025 · Engine · AZ

The vehicle had a catastrophic engine failure while driving in traffic. The engine would turn over making loud grinding noises but would not start, and the vehicle had to be towed. The engine had only 92,077 miles on it when it failed. Subsequent engine teardown found pieces of the connecting rod bearings which had disintegrated (see attached photos). This failure damaged the piston, crankshaft, valves, and cylinders. This engine has been the subject of a class action lawsuit due to a manufacturing defect of the connecting rod bearings and premature failures in thousands of engines. The engine is part of a class action lawsuit, but we are ineligible for the extended warranty since it had not yet received the knock sensor software update that was required by the lawsuit. However, this software update does not fix the defective connecting rod bearings and only provides a possible warning of an impending failure. I was never notified of this required update. This engine should have been part of a mandatory recall, but instead, KIA chose to release an update that made warranty eligibility impossible for customers who were unaware of its existence. This defective engine is a serious hazard and almost caused a major accident when the engine suddenly failed.

Filed Oct 21, 2025 · Engine · TX

Vehicle: 2019 Kia Soul 2.0L GDI VIN: [XXX] Mileage: 92,200 The engine and connecting rod bearings failed — a known defect in Kia’s Theta II GDI engines. The vehicle began making a loud knocking noise and would stall when turning to start the engine within days of purchase. This is consistent with the same defect addressed in Kia’s KSDS / PI2107 Product Improvement Campaign and Theta II Engine class-action settlement. Component failed: Engine. The engine is available for inspection. Safety risk: The engine stalls unpredictably, creating a major risk of collision or being stranded in traffic. The stalling has occurred more than once, and the car is unsafe to drive, per Moritz Kia. Confirmed by: Moritz Kia Fort Worth, which diagnosed internal engine failure and quoted $6,230 for replacement. Kia Consumer Affairs refused to open a case or perform the recall, claiming it was “past due,” though the vehicle is within the 15-year/150,000-mile lifetime warranty coverage. Maintenance history: CARFAX confirms regular oil and filter changes, most recently on 05/30/2025, proving the vehicle was properly maintained. Inspection: Completed by Kia dealership; no outside inspection yet. Warning symptoms: Engine knocking and stalling Summary: Kia is refusing recall service and case creation despite this being a known manufacturing defect, not a maintenance issue. The KSDS system only detects failure after it occurs and does not fix the defect. This creates a continuing safety hazard for consumers. Kia consumer affairs dates of contact and reference numbers: 09/11/2025-#2563091, 10/15/2025-25603091 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 7, 2025 · Engine, Fuel system · NY

My 2019 Kia Soul is experiencing severe and abnormal engine oil consumption. This issue requires frequent refilling of engine oil to prevent damage. The malfunction is in the powertrain system, likely within the GDI engine, specifically related to the piston rings. This type of structural defect can lead to a sudden and catastrophic engine failure while driving, which poses a serious safety hazard to occupants and other motorists. The problem has been confirmed by me, the vehicle owner, through the observation of consistent and rapid oil level depletion. Prior to a complete failure, there were no specific warning lamps or messages related to this issue. The manufacturer, Kia Motors, has declined to perform a proper technical review, citing an expired warranty and my status as a second owner. I have opened three separate cases with Kia regarding this matter, all of which were closed without a proper resolution. I am requesting an investigation into this defect by the federal safety agency.

Filed Sep 20, 2025 · Engine · MI

Excessive oil consumption leading to complete engine failure. My wife bought this car to be her daily commute to work. When we took the car for its first oil change after hitting the change sticker milage, the mechanic noted that the engine had no oil. We filled it up with full synthetic. History of the Vehicle showed proper and on-time maintenance schedule, that's why we bought it. At the time of purchase there were no codes or engine lights. Clean title and no accidents. The engine had oil at the time of purchase. There were no indicators of problems. We also took the car to the Kia dealership for recalls and campaigns, they told us nothing about this issue. One day, first came the engine light, my wife was driving to work, the car started shaking heavily, then the vehicle failed to supply enough power to go above 50 mph. She was in the middle of the interstate, she felt that she was going to crash, or someone will crash into her. She was terrified, rightly so. When she finally reached a safe place to stop, she called me. When I came to check it out, I let the engine cool down first then checked the oil, it was very low. I put some oil and took it again to the same Kia dealership for diagnostics - the engine turned off multiple times on me at traffic lights (when near stop), the dealership took about a week to diagnose it and they finally told us that the cylinders misfired and the pressure in the cylinders were lower than capacity; they said the engine must be replaced and quoted us a used Engine of 114k at $7k replacement fee. Kia must be held responsible for their engines. We did everything in our capacity to ensure the vehicle is maintained as best as we could, my wife took loans from her family to pay for this car, and we are left with a lime.

Filed Sep 10, 2025 · Engine · PA

In february 2025 I had taken to the garage the first moment the check engine light came on and had to have the catalytic convertor replaced, costing me over 4300.00 It could have caught on fire the garage said. I have all documention and reciepts for all work since I have had the vehicle I am the 2nd owner and still making payments on this. I have kept up to date on every oil change and have the proof of that also. The car has been burning oil excessively and now the garage has determined it needs a engine replacement or rebuild costing over 5000.00 and the car only has 93,000 miles on it. I know KIA is known for issues with their engines burning excessive oil , but i found no recalls of it for my VIN.

Filed Aug 28, 2025 · Engine · TX

For some reason my 2019 Kia Soul is not included in the previous engine recall. My vehicle is experiencing severe oil burn which has caused the failure of a second catalytic converter. The first was replaced on 11/25/2024 and it is being replaced again on 8/28/2005. This failure is due to improperly heat-treated piston oil rings that lose their ability to seal, leading to cylinder wall damage, increased oil consumption, and potentially engine failure or fire.