2020 Kia Soul: check engine light

Filed Oct 14, 2026 · Engine · CA

On XXX my 2020 Kia Soul while on the freeway, would not accelerate and silently stalled. The check engine, oil, and battery light all came on. Putting it into Park and then Drive again, the vehicle began shifting backwards. The vehicle could not be safely driven and was towed to Kearny Mesa Kia in [XXX]. The dealer diagnosed code P0017 (crankshaft position and camshaft position correlation). The technician found the exhaust camshaft out of sync because the pin on the CVVD gear had broken, which allowed the gear to spin on the camshaft. The recommended repair is replacement of the exhaust camshaft, CVVD gear and bolt, timing chain tensioner, and valve cover gasket, quoted at $3,285.34. A borescope inspection found no valve damage. The service advisor told me this is a common problem on these vehicles. An internal engine part failing like this at about 99,000 miles is a premature failure, not normal wear. A sudden loss of camshaft timing can cause stalling or a loss of power while driving, which is a safety risk. I am the third owner and bought the car used through Carvana at about 55,000 miles, so the powertrain warranty does not cover this repair. Kia America denied my request for goodwill assistance. I ask the federal safety agency to look into CVVD gear and camshaft timing failures on the 2020 Kia Soul 2.0L engine. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 4, 2026 · Engine, Transmission · ME

The vehicle experienced complete and sudden engine failure while actively driving on a roadway. The engine began making loud, violent knocking noises, the check engine light illuminated, and the vehicle completely stopped and lost all motive power mid-drive. I believe this is directly caused by the defective piston oil rings covered under the federal safety agency Safety Recall Campaign 21V‑259 (Kia Campaign SC209). The vehicle had only just begun exhibiting these severe symptoms on the exact day it stopped working. The loud engine knocking, immediate check engine light, and rapid internal oil loss all occurred rapidly within hours of each other on the same day, leading directly to the total mechanical failure and seizure. The engine component is currently intact and remains completely available for physical inspection upon request. The engine in my Kia Soul is the 2.0L Nu MPI. The vehicle was towed to an authorized Kia dealership service center. The dealership confirmed that the engine has completely failed and had loud knocking sounds, but they are attributing the issue to an external leak in an attempt to deny coverage under Safety Recall SC209. The manufacturer (via the dealership, Techline, and Kia Corporate) has inspected the vehicle, but they have refused to perform the required internal engine teardown to inspect the piston rings or to honor the federally mandated recall remedy and fix my engine for free despite the recall. I have been fighting this for over two weeks now. I also provided my regular oil change documentation to show there was zero owner neglect.

Filed Sep 18, 2026 · Engine · 154,937 miles · NY

The contact owned a 2020 Kia Soul. The contact stated that while attempting to operate the vehicle, the engine seized and the vehicle failed to start. When attempting to start the vehicle, a knock turnover was present, and the check engine warning light illuminated. The contact referenced the federal safety agency Campaign Number: 21V259000 (Engine); as the cause of the failure. The vehicle was towed to an authorized dealer, and the dealer confirmed the total engine failure was directly associated with the recall. However, the dealer refused to perform the repair, claiming that the vehicle had exceeded the extended warranty, despite a federal safety recall not being bound by warranty expiration rules. The manufacturer was notified of the failure. The failure mileage was 154,937.

Filed Sep 17, 2026 · Engine · 182,000 miles · OH

The contact owns a 2020 Kia Soul. While driving 65 MPH, the vehicle lost motive power, and the check engine warning light illuminated. The contact pulled over to the side of the road and added oil to the engine before continuing to drive. The vehicle was taken to a dealer for diagnosis, and the contact was informed that the engine and catalytic converter needed to be replaced. The contact associated the failure with the federal safety agency Campaign Number: 21V259000 (Engine). The manufacturer was notified of the failure. The failure mileage was 182,000.

Filed Sep 11, 2026 · Acceleration, Engine · NC

This car was purchased in December of 2025 with 26K miles on it. There are stall issues when using the auto start stop feature. I had to power down the car and restart it up to get the car to move. It also will throw the check engine light code and then after you drive it, it goes away which makes it difficult to take to a service shop for diagnosis. Recently the car is now at 28K (9 mo later) and it has an intermittent stutter when driving; I can only describe it as a push/pull motion and its random, during this time the check engine light came on again. On my way to take it to a service station for diagnosis, it went away. Not sure if this has been reported by other 2020 Kia Soul owners.

Filed Sep 3, 2026 · Engine · 70,000 miles · FL

The contact owns a 2020 Kia Soul. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the spark plugs and coils needed to be replaced. The vehicle was repaired. The contact stated that while driving at an undisclosed speed, the taillights were inoperative, there was oil leaking from the bottom of the vehicle and the vehicle stalled. The contact stated that after the vehicle was restarted, the vehicle returned to normal operation. The failure had occurred on several occasions. The vehicle was taken to a dealer to be diagnosed and the dealer stated that there was an oil consumption issue with the vehicle; however, cause of the failure was not yet determined. The vehicle was towed to an independent mechanic where it was diagnosed and determined that the bolts needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was approximately 70,000.

Filed Aug 10, 2026 · Engine · 56,375 miles · PA

The contact owns a 2020 Kia Soul. The contact stated that while driving approximately 55 MPH, the check engine and oil warning lights illuminated, and the vehicle stalled. There was smoke coming from the engine compartment. The vehicle was pulled over to the side of the road, and two hubcaps were damaged, and the vehicle was restarted. The vehicle was taken to the residence. The contact stated that when the vehicle arrived at the residence, there was no oil inside the engine. The contact added oil to the engine, and the vehicle was taken to the dealer. The vehicle was not diagnosed. The contact stated that an oil change was performed at approximately 54,000. The manufacturer was not notified of the failure. The failure mileage was 56,375.

Filed Aug 5, 2026 · Engine · 165,000 miles · TX

The contact owns a 2020 Kia Soul. The contact stated that while driving at an undisclosed speed, the vehicle was erratically shaking, and the check engine warning light was illuminated. The vehicle was towed to the dealer, where it was diagnosed with piston rings failure. The contact was informed that there was a hole in the catalytic converter. The contact was informed that the engine, catalytic converter, the two Oxygen sensors, radiator hoses, heater coil hoses, motor mounts, and the serpentine belt needed to be replaced. The contact was informed that the engine was replaced in 2022 under an unknown recall. In addition, the contact was informed that the mileage on the vehicle was 108,000, at the time that the recall repair was completed. The contact was informed that the warranty only covered the replacement of the engine. The contact stated that the failure was a consequential failure associated with the engine failure. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 165,000.

Filed Jul 16, 2026 · Engine · MI

Vehicle has 22000 miles and has a major/excessive oil consumption and engine failure. Exhaust camshaft (broken pin) Exhaust CVVT (broken pin) These components breaking caused the vehicle to stall and completely shut the vehicle down while driving 70 MPH on the freeway. The vehicle was inspected by a Kia certified mechanic and mentioned this is a well known concern. The only indicator that there was an issue was an engine light which gave a code representative of a faulty senor, not a major engine concern.

Filed Jun 3, 2026 · Engine · FL

I was driving when the vehicle stalled while slowing down. It stalled several more times at a stop light, and then when slowing down or accelerating slowly. I then noticed the engine started making a noise. I have parked it and not been able to drive it since. No safety indicators popped up during the stalling. When the engine started making a noice the check engine light then turned on. The car has only 65958miles on it. I believe it should be apart of the SC209 recall list but it is not.

Filed Jun 2, 2026 · Engine · 112,704 miles · OK

The contact owns a 2020 Kia Soul. The contact stated that the check engine warning light illuminated while driving. The contact stated that he was a mechanic, and the contact had retrieved a diagnostic code indicating a vibration in the pistons. The dealer and the manufacturer were not contacted. The vehicle was not repaired. The failure mileage was 112,704.

Filed May 27, 2026 · Engine · 109,256 miles · OK

The contact owns a 2020 Kia Soul. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to O’Reilly’s where it was diagnosed with a failed engine. The contact was informed that the engine needed to be replaced. The vehicle as not repaired. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was made aware of the failure and a case was filed. In addition, the contact was advised to take the vehicle to the dealer for diagnostic testing. The failure mileage was approximately 109,256.