2016 Kia Soul: check engine light

Filed Nov 4, 2026 · Engine · 230,000 miles · WI

The contact owns a 2016 Kia Soul. The contact stated that the vehicle was taken to a dealer to be repaired under the federal safety agency Campaign Number: 19V120000 (Engine, Engine and Engine Cooling). The contact stated that prior to the dealer visit, the check engine warning light was illuminated. The contact stated that the dealer had not successfully completed the recall repair, because the check engine warning light remained illuminated when the vehicle was retrieved. The contact informed the dealer that the recall instructions required a catalytic converter inspection and a diagnostic scan to read and clear the trouble codes; however, the dealer responded by claiming that the recall parameters only authorized a software update. The failure mileage was 230,000.

Filed Nov 4, 2026 · Engine · AZ

My vehicle was towed to the dealer to address a recall. Campaign 19V120/SC176. I advised them I had codes #300, 303 &304. I requested a compression test & documentation of the findings. They instead cleared the codes, addressed the ksds software update & declared the car "fixed". Upon leaving, the engine lost power (in traffic) & the check engine light returned. I limped the car back & again requested a compression test which they did not perform even after pulling codes of a "misfire". They pulled the plugs & advised replacement as well as replacement of the coils for $1,200. I believe I'm entitled to knowing the health of the engine by means of a compression test & possible short block replacement if it's deemed necessary (per recall SC176)

Filed Oct 30, 2026 · Engine · 122,000 miles · AZ

The contact owns a 2016 Kia Soul. The contact stated that while driving 25 MPH, the check engine warning light illuminated. The vehicle was taken to the dealer to be repaired under Kia Campaign Number: SC176 (Engine Control Unit (ECU) Logic Improvement). A compression test was performed by the dealer, and it was determined that the cylinder compression was low, which indicated an engine failure. However, the dealer determined that only the catalytic converter would be replaced because DTC: P030X was not retrieved. The contact stated that the service campaign repair was not adequate for the failure. The manufacturer was notified of the failure by phone but confirmed the assessment of the dealer. The failure mileage was approximately 122,000.

Filed Sep 27, 2026 · Engine · CA

Dear Kia Customer Care, I am writing to formally express my disappointment and serious concern regarding my 2016 Kia Soul, VIN [XXX], its engine failure, the applicable engine recall/warranty coverage, and my experience obtaining assistance and repairs through Kia. Most importantly, this situation involved more than an inconvenience or ordinary mechanical problem. My son's safety was placed at serious risk when my Kia abruptly lost power and became disabled in high-speed freeway traffic. XXX – Dangerous Freeway Breakdown On Saturday, XXXX, at approximately 9:30 p.m., my son, [XXX], was driving my Kia Soul on the [XXX] from [XXX] toward [XXX], for his 11:00 p.m. work shift. According to [XXX], the vehicle abruptly began losing speed and eventually came to a complete stop near the freeway median. The vehicle was left in an extremely dangerous position with high-speed traffic approaching nearby. [XXX] noticed that the check-engine light had illuminated. He repeatedly attempted to restart the vehicle, but it would not start. When [XXX] called me for assistance, I panicked because of the dangerous circumstances. My immediate concern was that my son or another motorist could be seriously injured. I contacted AAA for emergency roadside assistance. Because of the hazardous location, AAA contacted the California Highway Patrol (CHP) to assist until the tow truck arrived. [XXX] was instructed not to leave the vehicle because of the high-speed traffic surrounding him. AAA ultimately towed my Kia Soul to Kia Cerritos because it was the closest Kia dealership I could locate that offered an overnight vehicle drop-off. XXXX – Vehicle Received by Kia Cerritos On Sunday, XXX, a service representative contacted me to confirm that Kia Cerritos had received my vehicle. I was asked what had occurred the previous evening, and I explained the incident in detail. XXX INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 16, 2026 · Engine · GA

My car is under 130000 miles and about two years ago I already had to replace one catalytic converter. The past six months the oil usage of my car, which has always been high and requires frequent topping off and more frequent oil changes at my mechanic, has gotten even worse. A check engine light came on a few weeks ago due to a catalytic converter fault. While car is still functional my mechanic expects the second converter will have to be replaced soon. These are all signs of an engine and system that is not functioning properly and could cause an issue at any time.

Filed Sep 8, 2026 · AK

I own a 2016 Kia Soul 1.6L GDI with approximately 108,956 miles. The vehicle is consuming approximately 1/2 quart of engine oil every 1,000 miles. There is no obvious external oil leak. I am concerned about excessive oil consumption and possible internal engine damage. The vehicle also produces a very loud exhaust-type noise from the front of the vehicle when starting, which appears to be coming from the front exhaust/manifold/catalytic-converter area. The vehicle currently has no check-engine light. I checked the VIN through the federal safety agency and it shows zero unrepaired recalls. I am requesting that the federal safety agency document this complaint and review whether these symptoms could indicate a safety-related defect affecting this vehicle or other Kia Soul vehicles with the same engine. It is getting worst and loud

Filed Aug 23, 2026 · Engine · CA

I am filing a formal safety compliance complaint regarding my 2016 Kia Soul (1.6L GDI engine) and a structural failure of the exhaust/catalytic converter system related to the federal safety agency Campaign 19V120000 / Recall SC176. The vehicle has thrown a persistent P0420 Check Engine Code (Catalyst System Efficiency Below Threshold) and is experiencing unsafe driving conditions, including severe power loss and sudden engine stalling in active traffic. Authorized franchise Valley Kia of Modesto has refused to honor the safety recall framework. They have denied federal compliance by refusing to perform the mandated exhaust inspections, engine combustion tests, or hardware replacement under the open recall guidelines, falsely claiming prior software updates absolve them of replacing the failed physical hardware. Corporate Case #26299283 was opened on August 19, 2026, but the franchise continues to operate in complete non-compliance with federal motor vehicle safety standards, leaving an active fire and stalling hazard unresolved.

Filed Jul 19, 2026 · Engine · NJ

Check engine light came on and car was out of oil even though an oil change was done about a month ago. Catalytic converter was replaced once already. Per mechanic excess heat caused out to leak catalytic converter needs replacing again and now engine is damaged as all engine oil leaks out where it cannot be detected on ground. Danger of fire according to recall sc176 and mechanic. Car was smoking so it has been parked for safety to avoid fire

Filed Jul 15, 2026 · Engine · 140,000 miles · CA

The contact owns a 2016 Kia Soul. The contact stated that while the vehicle was parked, it was started, and there was smoke coming from the engine compartment. The vehicle was turned off to stop the smoking. The check engine warning light was illuminated. The vehicle was towed to a dealer, where it was diagnosed, and it was determined that the engine needed to be replaced. The vehicle was not repaired. The contact researched and became aware of an unknown recall; however, the VIN was not under recall. The manufacturer was not notified of the failure. The failure mileage was approximately 140,000.

Filed Jun 23, 2026 · Engine, Transmission · FL

What component or system failed or malfunctioned, and is it available for inspection upon request? The vehicle is a 2016 Kia Soul 1.6L GDI with approximately 83,000 miles. The vehicle experienced engine performance issues, loss of power, and stalling. A Kia dealership diagnosed a failed/melted catalytic converter and reported metal shavings in the engine oil. The vehicle has not been repaired and is available for inspection upon request. How was your safety or the safety of others put at risk? The vehicle stalls and loses power, creating a safety hazard while driving in traffic. A sudden loss of power increases the risk of being struck by another vehicle and makes it difficult to safely maintain speed, merge, or cross intersections. Because the vehicle is unreliable and may stall unexpectedly, I do not consider it safe to operate. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The condition was confirmed by an authorized Kia dealership. The dealership diagnosed a clogged/melted catalytic converter and reported metal shavings in the engine oil. The dealership advised that the catalytic converter must be replaced before they would perform further engine diagnosis. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? The vehicle was inspected by an authorized Kia dealership. Kia Customer Care was notified of the issue and reviewed the claim but declined assistance. To my knowledge, the vehicle has not been inspected by a Kia field engineer, police agency, or insurance investigator. Were there any warning lamps, messages, or other symptoms prior to the failure, and when did they first appear? Yes. The vehicle experienced drivability issues, loss of power, and check engine light illumination. Diagnostic trouble codes reported included P0420, P2191, and P2196. The symptoms progressively worsened and eventually resulted in severe performance issues and stalling.

Filed Jun 15, 2026 · Engine · IL

hello the federal safety agency i have a problem with my car. which kia soul plus with 83000 miles on it. It have check engine light blinks with code p1326 which is knock sensor recall. i went to kia dealer at federico kia at wood river illinois they replaced the knock sensor. it show up back in 6 miles. i took it back to the dealer.they hold the car for one week. they said you got denied of engine replacement due to lack of maintenence. it have sevice records on carfax.

Filed Jun 4, 2026 · Engine · CA

My 2016 Kia Soul (1.6L GDI engine) experienced a catastrophic, sudden engine failure while driving, preceded by Check Engine Light code P0420 (Catalyst System Efficiency Below Threshold). This exact failure sequence is the precise subject of active the federal safety agency Safety Recall Campaign 19V120 (Kia Campaign SC176).Although the vehicle received the mandated SC176 preventative software update in 2019, the underlying mechanical defect was not cured. High exhaust gas temperatures caused the catalytic converter to degrade and fracture internally. The fractured abrasive substrate particles were then siphoned backward into the engine combustion chamber during normal valve operation. This caused immediate, severe scoring of the cylinder walls and piston damage, leading to total engine seizure and failure. This defect presents an extreme safety risk. Sudden engine failure at highway speeds causes an immediate loss of motive power, braking assistance, and power steering, significantly increasing the risk of a high-speed collision. Furthermore, fractured connecting rods or oil leakage stemming from this specific engine failure pose a severe vehicle fire hazard. The vehicle is currently held for diagnostic verification at Kia Riverside in California. I am filing this complaint because the manufacturer's 2019 software remedy was entirely ineffective at preventing the mechanical destruction of the engine and catalytic converter. I am requesting that the federal safety agency hold Kia accountable to fulfill the physical repair and replacement mandates of Recall SC176 at zero cost to the consumer, regardless of the prior software logging.