2020 Kia Telluride body problems

Filed Oct 7, 2026 · Body · NY

This afternoon i noticed that my 2020 Kia Telluride paint has and continues to peel in large chunks in my driveway. All was good this morning and then all of the sudden large pieces of paint started to break away. Near the windshield hood area.

Filed Sep 23, 2026 · Body, Engine · CA

I am the original owner of a 2020 Kia Telluride that was purchased new in December 2019 and currently has approximately 98,000 miles. The vehicle has been routinely serviced, including regular maintenance performed through authorized Kia dealerships. Recently, the vehicle developed a serious apparent engine problem. An independent repair facility inspected the engine oil and found it was very low and visible metallic particles/shavings in the oil. The oil also appeared abnormally burned. The repair facility found no evidence of an external oil leak and advised that the vehicle should not be driven because of the condition of the engine oil and presence of metal. I had the vehicle towed to an authorized Kia dealership rather than continue operating it. There were NO Engine or warning lights indicating low oil. The vehicle is currently awaiting diagnosis by Kia under the 10-year/100,000-mile powertrain warranty. I am concerned that the presence of metal in the engine oil indicates an internal engine component failure that could result in sudden engine seizure, loss of propulsion, or other engine failure while the vehicle is being operated in traffic. There was no crash, fire, or injury associated with my vehicle at the time the problem was discovered because I stopped operating it after being advised not to drive it. The vehicle also has significant premature paint delamination on the roof. Large areas of the original factory paint have separated/flaked away from the roof despite the vehicle being approximately six years old. This is not isolated rock chipping or normal cosmetic wear; it appears to be a widespread failure of paint adhesion. I am concerned about additional paint separating from the vehicle while traveling at highway speeds and potentially becoming airborne, as well as the long-term effect of exposed roof metal and corrosion. Kia has been notified of the paint condition but has declined to repair it.

Filed Sep 15, 2026 · Body · VA

In March of 2025 I noticed that my Kia Telluride had a quarter size piece of paint missing in the middle of the roof near my windshield. As the past year has progressed paint delamination has occurred across the roof of my vehicle with other delamination spots being noticed in other areas of the body. My vehicle is a 2020 with 66,000 miles and is a white pearlescent coat. The delamination is exposing the body of my vehicle to the elements, causing rust and deterioration at a rapid speed. With a simple hand washing, the paint peeled off of my roof in a large area. This should not be occurring with a vehicle that has been well taken care of and should have many years of life left. Kia should be held responsible for the delamination that is occurring widely with the white pearlescent paint color.

Filed Sep 10, 2026 · Body · MD

On December 9, 2025, the factory exterior paint on my 2020 Kia Telluride (Snow White Pearl) began experiencing massive, sudden delamination, shearing completely off the roof down to the factory primer layer in a sheet larger than a hand towel. The peeling is continuing to spread due to wind exposure while driving. Furthermore, the paint failure has compromised the protective coating, causing specs of rust to actively break through the paint throughout the trunk and exterior body panels. This indicates a severe manufacturing defect in factory paint adhesion and corrosion protection, posing a direct threat to the vehicle's structural integrity and body longevity. Kia America has refused warranty assistance due to vehicle age/mileage limits, despite this being a widespread manufacturing failure.

Filed Jul 27, 2026 · Body · AZ

I attempted to open the moonroof on our 2020 Kia Telluride. When it opened, it was cockeyed and off track. I pushed the button to close it, and I heard a plastic piece break and the moonroof remained stuck open. I took this car to Kia of Olympia, Kia of St. Cloud and Horne Kia, all confirmed that the plastic parts that broke are related to to their issued TCB#BOD319. This is well known and frequent issue on 2020-2022 Kia Tellurides, where the plastic for the wind guard snaps off and gets lodged in the sunroof track. Even though this is a known issue with the Kia Telluride, they have declined to cover the repair cost, and we now must pay over $7,000 for an entirely new sunroof assembly.

Filed Jul 6, 2026 · Body · GA

The power sunroof and its sliding track/rail assembly failed. While operating the sunroof using its normal electric open/close function during highway driving, the sunroof glass/panel traveled to full open and the track mechanism broke at that point, preventing normal closure. The vehicle and damaged sunroof/track assembly are available for inspection upon request. The failure occurred while the vehicle was in motion on the road, creating a distraction and an unexpected open aperture in the roof at highway speed. An uncontrolled/stuck-open sunroof exposes the cabin to wind, debris, weather, and noise, and could distract the driver attempting to address the malfunction while driving. There is also risk of glass or track hardware detaching from the vehicle. A Kia dealership inspected the vehicle and confirmed the track is broken and quoted approximately $5,000+ to replace the sunroof assembly, citing no applicable warranty coverage. No warning lamps or messages appeared prior to the fail I have found other consumer complaints/forum reports describing similar sudden sunroof track failures on this make/model during normal operation, suggesting this may be a widespread component defect rather than an isolated incident or wear item. Despite this, the manufacturer has not issued a recall or extended warranty coverage for this failure mode, leaving owners to pay approximately $5,000 out of pocket for a repair caused by what appears to be a manufacturing or design defect rather than misuse.

Filed Jul 2, 2026 · Body · 30,000 miles · FL · 1 injury

The contact owns a 2020 Kia Telluride. The contact stated that four door belt molding trim pieces had become loose and unsecured, but the front driver’s side door belt molding trim piece had become unsecured and detached from the vehicle. Additionally, the contact stated that while touching the unsecured molding, the arm became bruised and scratched. No medical treatment was required. The cause of the failures was not yet determined. The local dealer was contacted, but no assistance was offered. The manufacturer was not yet contacted. The contact was informed that the VIN was not included in the federal safety agency Campaign Number: 25V494000 (STRUCTURE). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 30,000.

Filed Jul 1, 2026 · Body · NC

Sunroof issue with the air dam that lifts up when the sunroof opens breaks off and throws the the sunroof off track so your stuck with it open or it breaks the track or glass

Filed Jun 23, 2026 · Body · CA

My vehicle’s white exterior paint and clear coat are delaminating and peeling off in pieces while driving. Loose paint pieces fly off the vehicle, creating a potential road hazard for other drivers. The defect affects the hood, the front, and the area above the windshield. The vehicle is available for inspection upon request. The paint delamination has been visually confirmed and is worsening over time. I have contacted Kia customer service multiple times by phone and email requesting repair or resolution. Kia has not responded or offered any remedy. The defect has not been inspected by the dealer as Kia declined to address it. No warning lamps or messages are applicable to this defect. The peeling first became noticeable approximately June 1st, 2026 and has progressively worsened since.

Filed Jun 20, 2026 · Body · AL

What component or system failed or malfunctioned, and is it available for inspection upon request? The factory paint on my 2020 white Kia Telluride has failed. The paint is peeling and flaking from the hood and the roof of the vehicle. The vehicle is available for inspection upon request, and I have photographs documenting the paint failure. How was your safety or the safety of others put at risk? The peeling paint exposes the underlying metal to the elements, which may lead to corrosion and deterioration of the vehicle over time. Pieces of peeling paint may also detach while the vehicle is being driven, creating a potential hazard for other motorists. In addition, the loss of the factory paint significantly reduces the value of the vehicle and raises concerns about the quality and durability of the manufacturer's finish. Has the problem been reproduced or confirmed by a dealer or independent service center? At this time, the problem has not been confirmed by a Kia dealer or an independent service center. However, I have found numerous reports from other owners of white Kia Tellurides experiencing similar paint peeling issues, suggesting this may be a widespread manufacturing defect. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? Not at this time. Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? There were no warning lights, messages, or other vehicle symptoms before the paint began peeling. The issue developed gradually as the factory paint began separating from the hood and roof under normal use.