2017 Lincoln MKZ: engine stalls while driving

Filed Aug 20, 2026 · Engine · TN

Engine has rough idle and can stall. Ford says engine has coolant intrusion and needs a new engine. The repair will cost between 8500 and 10000 dollars.

Filed Jul 30, 2026 · Engine, Fuel system · IL · fire · 1 injury

I am reporting a catastrophic engine failure and engine-compartment fire involving my 2017 Lincoln MKZ Select, equipped with a 2.0L EcoBoost engine, VIN [XXX]. The vehicle had approximately 99,864 miles when the final failure occurred. Shortly after I purchased the vehicle, the original engine developed severe overheating, loss of cabin heat, white exhaust smoke, misfiring, and coolant intrusion. On December 16, 2024, at approximately 95,354 miles, the vehicle was taken to Murgado Ford Lincoln of Chicago. The dealership documented diagnostic codes P0303 and P0316 and determined that coolant was entering cylinder No. 3. Pursuant to Ford Technical Service Bulletin 22-2229, the dealership replaced the long-block engine and related one-time-use components. The replacement service-engine assembly was identified on the repair invoice as part No. J2GZ-6006-E. The vehicle was returned to me on approximately January 30, 2025. After the engine replacement, the vehicle continued to experience serious problems. Within days, it stalled in an intersection, produced white smoke, lost cabin heat, and had to be returned to the dealership. The vehicle later continued to exhibit hesitation, harsh shifting, loss of power, and other abnormal drivability symptoms. On September 4, 2025, while I was operating the vehicle under normal driving conditions in Chicago, I heard a sudden loud metallic grinding or mechanical noise coming from the engine area. Gray smoke then began coming from the vehicle and quickly progressed into heavy dark smoke. A fire developed in the engine compartment, forcing me to stop and exit the vehicle. The fire rapidly intensified and was followed by an explosion or explosive sound. There was no collision that initiated this incident. The vehicle sustained catastrophic fire damage and was rendered a total loss. The failure occurred only approximately seven months after the replacement long-block engine was installed and after I had repeatedly experien INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION

Filed Mar 9, 2026 · Transmission · OH

I drive a 2017 Lincoln MKZ equip with an Ecoboost 2.0L engine. A very widely known design flaw in the Engine Long block has caused coolant intrusion into the #1 cylinder. This can cause overheating issues and ultimately cause a fire and/or stall the car in a critical moment (i.e. highway) and cause an accident. I took the vehicle into my local dealership and they confirmed this issue and is consistent with TSB 22-2229 and needing a replacement of the Engine Long block. I called Lincoln Customer Support and they are refusing to assist at all with this repair, costing me over $10k. Also noting my car only has 61,000 miles.. as well as the dealership confirming this is not something that I could have prevented. I haven't noticed any issues other than the check engine light coming on, which is what initially led me to taking it into the dealership.

Filed Aug 7, 2023 · Engine · MI

While driving my 2017 Lincoln MKZ 3.0L in March 2023, I experienced a loss of power and then engine stalled, fortunately I was at a stop and was able to re-start the vehicle and limp home, (which was nearby). If this loss of power and then stall would have happened while I was moving in traffic the failure could have lead to a catastrophic outcome including loss of life. It was determined via OBDII analysis conducted by the Lincoln Service department that DTC P0302 was triggered. Upon further inspection by the service department it was revealed that the issue was related to TSB 19-2243, which reads "2.7L/3.0L - Oil Consumption With DTC P0524 And/Or P06DD, Rough Idle, Misfire And/Or White Or Blue Exhaust Smoke - Built On 1-Apr-2016 And Through 1-Jan-2017". Unfortunately, my vehicle was built during this known defect time frame. And the remedy required new cylinder head. The new cylinder head and subsequent parts and labor cost me $3,126.58. This was extremely unfair as my only because my vehicle did not fall within the warranty period or mileage. The vehicle was over 6 years old with 36,934 miles. This very serious failure mode could have resulted in a loss of life if experienced while driving on a highway or any other situation in which the vehicle was mobile and experienced a sudden loss of power in traffic. Further disappointing is that I would estimate that there were many vehicles that experienced the defect noted in the TSB but these were not reported publicly because they were "lucky enough" to fail during the warranty period. My costs should be reimbursed by Lincoln given this was a known defect during the build time frame. And at minimum there should be a safety recall for the vehicles built during the time period noted in the TSB. I will personally never purchase another Lincoln not to mention a Ford, of which I currently have 3 Ford/Lincoln.

Filed Jul 10, 2019 · Engine, Fuel system · 77,500 miles · MN

Vehicle stalls/loses power once fuel reaches below half tank of gas. Ford has issued tsb's on this very issue on many of their other engines, but I've been unable to find a tsb for this issue for my vehicle specifically. Here is the tsb for ford focus's with this issue: ford motor company (ford) is recalling certain 2012-2018 ford focus vehicles with a 2.0l gdi or 2.0l gtdi engine. The canister purge valve (cpv) may malfunction, possibly causing excessive vacuum in fuel vapor management system. Tsb # 18s32. When pressure is being released from the gas tank via the fuel door opening, gas sprays out of the opening and goers stuck/hardened to exterior of car.

Filed Feb 1, 2018 · Acceleration, Engine · 7,800 miles · GA

While driving in heavy traffic on the interstate attempted to change lanes and accelerate, car suddenly lost power and the "see manual" light illuminated with tool - fortunately was able to coast car off exit ramp safely and pull over, at which point the engine chugged and stalled. First restart "see manual" light still on, sputtered and stalled. Turned off vehicle. 2nd attempt same as 1st. 3rd came on and ran without engine light and seemed to rev up higher than normal, then came back down. No other indications appeared other than "no use of auto brake available"

Filed Jan 9, 2018 · Brakes, Fuel system · 3,000 miles · NJ

1-car stalled and died turning from parking lot onto street. Barely avoiding collision. 1/6/2018. Defect in fuel delivery. Still in shop. 2- odd noise and smell while backing up due to cracks in brake pad . 1/17/17 replaced 01/17/17 ( have repair invoice, not sure how to upload)