Transmission 1st/2nd gear synchromesh went out 5 times, finally mazda admitted something was wrong with engine,3x was under warranty, last 2x I paid all costs. Judge ruled against mazda in small claims court.
The worst 2002 Mazda B-Series Truck problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Airbags6
- Engine6
- Transmission6
- Acceleration3
- Brakes2
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Airbags6
- Engine6
- Transmission6
- Acceleration3
- Brakes2
- Seat belts2
- Seats2
- Tires2
- Driver assistance1
- Lights1
Trouble codes owners of the 2002 Mazda B-Series Truck mention
B3000 4
Recalls 2
Vehicle speed control: cruise control
- What is wrong
- Mazda is recalling model year 1995 through 1997 and model year 2001 through 2003 trucks equipped with texas instruments speed control deactivation switch (scds) and/or anti-lock brake system (ABS) and manufactured on or before december 5, 2002. A component of the cruise control deactivation switch may deteriorate over time and develop a leak. This occurrence could cause the switch to overheat, smoke or burn which could result in an under hood fire.
- Risk
- A vehicle fire could occur with or without the engine running.
- Remedy
- Mazda will notify owners that dealers will install a universal fused jumper harness on the cruise control deactivation switch free of charge. The safety recall began on december 11, 2009. Owners may contact mazda at 1‑800‑222‑5500 option #6.
Recall number 09V414000 · Recall details
Vehicle speed control
- What is wrong
- On certain trucks equipped with a speed control system, the speed control deactivation switch may, under certain conditions, leak internally and then overheat, smoke, or burn.
- Risk
- This could result in an underhood fire.
- Remedy
- Dealers will install a fused wiring harness. An interim notice was sent to owners on september 7, 2007, directing them to have the speed deactivation control switch disconnected temporarily. A second notification letter to owners was in february 2008 advising them to return to dealers for installation of the repair part. Owners of affected vehicles who did not receive a phase 2 notice and have not had the recall completed will be notified beginning august 6, 2008. Owners may contact mazda at 1‑800‑222‑5500.
Recall number 07V347000 · Recall details
Technical service bulletins for the 2002 Mazda B-Series Truck 123
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- This bulletin supersedes the previously issued bulletin(s) listed below
- Product Quality Information (PQI) DESCRIPTION Service Information MT-041/12 is no longer valid
- This Service Alert supersedes the previously issued SA listed below: The changes are noted in Red....
- In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer
- Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems
- Speedometer replacement procedure
- Some customers may complain of signs of oil on the struts or shock absorbers
- Some customers may experience a squeaking noise may be heard from the exhaust manifold when the idle speed...
- In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer.
- This service bulletin provides testing and charging procedures in order to promote proper battery...
What 2002 Mazda B-Series Truck owners say
Most recent owner complaints, unedited.
Dealer confirms this recall was completed nov 1, 2007 I called today to confirm, and gave my new address: 4133 224th lane se, unit #101, issaquah, wa 98029-5203. How do I get this recall removed - important for potential future sale... Dealer is lee johnson chev /mazda of kirkland wa. Updated 02/08/17*lj
Can not get the local mazda dealer (skyland automotive)(888‑231‑1092) to make an appointment to have the safety recall 4707h repaired. Can you help.
I was driving in the high way and braked for there was traffic ahead and as soon as my RPM went low my truck suddenly hesitated deeply and turned off.
Engine cooling system had internal corrosion which caused heating failure (thermostat). In new hampshire when the temperature is at or below zero, the risk of freezing to death because the car will not heat properly could have its consequences. In order to correct the problem, the engine had to be replaced (used engine) at a cost of $3000.00 the problem was caused, most likely by incorrect antifreeze installed in the engine. This was done either at the factory or the new car dealership when the car was preped for sale.
Tl*the contact owns a 2002 mazda b3000. While the contact was seated in the parked vehicle, the driver's seat back rest failed. He currently has a box behind the back rest to keep it erect. The dealer wants to keep the vehicle overnight and charge for a diagnostic. The contact does not want to leave his vehicle overnight or pay for the diagnostic. He feels that it is mazda's responsibility to correct the failure for free. The contact plans to take the vehicle to an independent body shop. The current mileage was 72,000 and failure mileage was 55,000.
Since I purchased the vehicle there has been noticeable play in the rear differential. I ignored it for a long time and then after the warranty had expired I took it to a repair shop in the area that has a very good reputation for repairing and setting up differentials. After examining the gears in the rear end he told me the play was caused by a part that was machined incorrectly at the factory. He said it was a hole that was drilled too large for the pin that is installed in it to hold the axle gears in place. He assured me that it was not caused by wear because this pin is not a moving part. I have continued to drive the truck without any repair being made, it does not seem to be getting any worse, but who knows how long until it fails?
Passenger low beam headlight does not work fuse is ok fuse slot has power lamp was replaced still does not work.
Factory recall we were notified to have our cruise control on our 2002 mazda 4wd-b400 pu disconnected because of a factory recall. We did this in october 2007. To date we have heard nothing about the repairs. Our dealers keeps telling us that they are waiting for parts. Where in the world are these parts manufactured that they can't get them by now? Since then we are getting an "engine light on" which indicates that we either have a short circuit condition or the dpfe/egr valve pressure sensor has failed. I want to know if this is due to their disconnecting the cruise control? Please let me know soon!
Tl*the contact owns a 2002 mazda b3000. The contact received a safety recall notice and took her vehicle to the mazda dealer on september 26, 2007. The dealer deactivated the cruise control switch, however, the ABS light illuminated the same day. The vehicle was returned to the dealer on september 27, 2007. Mazda reconnected the cruise control switch and informed her that the safety recall did not apply to her VIN. She stated that the ABS light was not illuminated when she brought the vehicle in for the recall repair. The purchase date and recall number were unknown. The current and failure mileages were 28,000.
Compare the 2002 Mazda B-Series Truck
Other model years
19901991199219931994199519961997199819992000200120022003200420052006200720082009
Questions about the 2002 Mazda B-Series Truck
Is the 2002 Mazda B-Series Truck reliable?
Owners have filed 28 complaints about the 2002 Mazda B-Series Truck, 1.3 times a typical B-Series Truck model year.
What is the 2002 Mazda B-Series Truck year score?
The 2002 Mazda B-Series Truck scores 60 out of 100 (average). The score compares it with the other model years of the Mazda B-Series Truck: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2002 Mazda B-Series Truck?
Airbags, with 6 complaints. Next is engine (6).
How many recalls does the 2002 Mazda B-Series Truck have?
2 recalls, covering vehicle speed control.
What year does the Mazda B-Series Truck have bad airbags?
The Mazda B-Series Truck model years with the most airbags complaints are 2007 (36 complaints), 2004 (20 complaints) and 2005 (16 complaints).
VIN decoder
See the problems and recalls for an exact car
Buying a used 2002 Mazda B-Series Truck?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history