2019 Mazda CX-5: sudden loss of power

Filed Aug 28, 2026 · Engine, Fuel system · NJ

2019 Mazda CX-5 developed P0192-00 fuel-pressure-related fault and significant loss of acceleration/limp mode. Mazda dealership diagnosed fuel rail/injector-seal issue and performed approximately $2,836 in repairs. The condition was not corrected. Dealer now diagnoses a high-pressure fuel-pump failure and is requesting an additional $1,459. Vehicle has experienced loss of power while driving. There is an existing Mazda fuel-pump recall affecting some 2018–2019 CX-5 vehicles, but Mazda says my VIN is outside the recall population. I am concerned about a potential fuel-system safety defect.

Filed Jun 9, 2026 · Engine · CA

On May 11th I was driving my 2019 Mazda CX-5 with approximately 35,000 miles when my cabin filled with the smell of gasoline. The smell became overwhelming within minutes, causing concern for my safety and the safety of other drivers. I immediately drove to the closest auto repair/body shop for an emergency inspection. Upon inspection, the technicians discovered there was a "crack at rear cylinder head and leaking oil excessively. Oil is leaking on to hot exhaust manifold....car is not safe to drive since oil leak is excessive". I was advised that this must be a manufacturer defect as you should not see this issue at such low mileage. The vehicle was then towed to the nearest Mazda dealership/service center, where a cracked rear cylinder head was diagnosed and confirmed. I was informed that continued operation of the vehicle could have resulted in catastrophic engine failure, engine seizure, fire risk from leaking oil contacting hot engine components, or sudden loss of power while driving, creating an extremely dangerous driving situation. Prior to the failure, there were no major warning indicators other than the sudden strong fuel/oil smell. The issue occurred unexpectedly despite the vehicle being properly maintained and having low mileage for a major engine failure. I have been the sole owner. The vehicle is currently available for inspection upon request.

Filed Feb 25, 2026 · Engine · SD

The engine cylinder head cracked and is leaking engine oil. This component is available for inspection at Liberty Mazda or by an independent certified mechanic upon request. The cracked cylinder head caused significant engine oil leakage, which created the following safety risks: Sudden loss of engine power or stalling while driving Smoke emission from the engine bay Potential fire hazard if leaking oil contacted hot engine components These conditions placed both the driver, passengers, and others on the road at risk. The cracked cylinder head and associated oil leak were diagnosed and confirmed by Liberty Mazda, the authorized dealership that performed prior repairs on this vehicle. The dealership documented the issue and provided a repair estimate of approximately $5,400. No independent service center has inspected the vehicle at this time. The vehicle and cylinder head have only been inspected by Liberty Mazda. Mazda Corporate has not physically inspected the vehicle, but all service records and documentation of prior repairs have been submitted to them during the warranty dispute process. There has been no inspection by police, insurance representatives, or other third parties May 2025: The vehicle intermittently struggled to accelerate. At that time, no dashboard warning lamps illuminated, and the dealership initially reported no issues. June 2025: Following the timing cover repair, the vehicle experienced engine oil leakage due to incorrect sealant installation, which was documented. February 10, 2026: The dealership repaired the oil pan seal and replaced the sealant, refilling engine oil. February 14–15, 2026: Approximately four to five days after the February 10 service, the cylinder head cracked, causing a significant oil leak. All symptoms and related service events are documented in Liberty Mazda’s service records.

Filed Dec 9, 2025 · Engine · FL

While driving a short distance, my engine overheated and there was a strong burning smell. The cylinder head was cracked, causing a significant oil leak. The car is currently at the dealership but is available for inspection upon request. The defective cylinder head is leaking engine oil directly onto hot exhaust components. This creates an immediate risk of engine fire and causes smoke to enter the vehicle cabin, impairing visibility and driver health. The vehicle was diagnosed by an authorized Mazda dealership. They confirmed the cylinder head is cracked and requires replacement. My mechanic advised this type of leak could lead to engine overheating, sudden power loss, or potential fire risk and should not be driven. Mazda has issued prior Technical Service Bulletins and warranty extensions for similar cylinder head/manifold cracking issues on the 2.5L turbo engine, but no program exists for the non-turbo engine, despite identical problems. Mazda should be held responsible for this safety issue. Mazda is aware of this manufacturing defect but has not recalled these engines to be repaired or replaced if they are outside of their warranty period, placing costly repairs and potentially life-threatening situations on their customers. The repair is replacement of the cylinder head/sleeve or replacement of the engine block, which has since been modified by Mazda to resolve this issue. Mazda’s refusal to extend reimbursement to non-turbo owners is unfair and leaves affected customers with no support for a known manufacturing flaw. I urge the federal safety agency to investigate this recurring engine defect in non-turbo 2019–2020 Mazda CX-5 models and encourage Mazda to offer equal reimbursement.

Filed Nov 24, 2025 · Engine, Transmission · PA

What component or system failed: The cylinder head failed due to cracking around the exhaust manifold, resulting in exhaust and coolant leakage. My independent mechanic and the Mazda dealer both confirmed this was the source of the burning smell and engine risk. The failed parts are currently in the possession of the Mazda dealership and available for inspection upon request. Safety risk: The failure created a strong burning rubber smell inside and outside the vehicle while driving. My mechanic advised this type of leak could lead to engine overheating, sudden power loss, or potential fire risk if not caught early. I frequently transport children in the vehicle, and the unexpected engine damage posed a significant safety concern. Has the problem been reproduced or confirmed: Yes. The issue was first diagnosed by an independent, certified mechanic and then confirmed by the Mazda dealership, who determined the cylinder head had to be replaced due to premature cracking and leakage. Has the vehicle/component been inspected: Yes. The vehicle has been fully inspected by an independent mechanic and the Mazda dealership service department. The dealership stated the failed cylinder head will be sent to Mazda for engineering review. Were there any warning lamps or symptoms before failure: There were no warning lights or error messages prior to the failure - which is alarming. The only initial symptom was a strong burning rubber smell that began shortly before the diagnosis. No overheating warnings appeared on the dash before the problem was confirmed. Additional context: The vehicle has 40,000 miles, has been fully maintained according to schedule, and is garage-kept. The Mazda service department acknowledged this failure is unusual and premature. Mazda has issued prior Technical Service Bulletins and warranty extensions for similar cylinder head/manifold cracking issues on the 2.5L turbo engine, but no program exists for the non-turbo engine, despite identical symptoms.

Filed Jul 24, 2025 · Driver assistance, Electrical · KS

When accelerating, the transmission feels jerky/stutters. The check engine light and traction control light are illuminated and on the instrument cluster the messages: "Forward Smart City Brake Support Malfunction", "Smart Brake System Malfunction" and "Front Radar Sensor System Malfunction" appear. The vehicle acts like it doesn't know which gear it should be in, it'll buck pretty hard and then it refuses to accelerate...it feels like it's in a "limp mode". A previous driver of the vehicle complained and said that it actually stalled in traffic on the highway and was of course difficult to steer due to loss of power. I took it to a dealership and they came up with a laundry list of things to fix...most of which wouldn't have any bearing on this issue. I did have the serpentine belt replaced and the belt tensioner replaced due to wear on the belt and loose tension. On 7/16/25, I scanned the vehicle with a code reader, the codes P0301 and P0506 appeared. P0301 is a generic "Cylinder 1 Misfire Detected" message and P0506 is a generic "IAC system RPM Lower Than Expected. The vehicle was taken to a shop where the spark plugs and the cylinder 1 coil was replaces and the IAC cleaned. On 7/24/25 the same vehicle behaviors were observed and the same warning lights and messages were activated. I scanned the vehicle and got "p0300 Random/Multiple Cylinder Misfire Detected and P0304 Cylinder 4 Misfire detected. There was a recall on this particular vehicle make, model and year and my vehicle was out of the VIN# range. I firmly believe that the recall needs to be expanded to include a larger number of vehicles...you can google about this vehicle and see many others with similar issues. Usually, the cure is a PCM reflashing/software update that seems to take care of the issue. Please expand the recall before someone dies in an accident because of this problem.

Filed Mar 4, 2025 · Engine · PA

The cylinder head on my 2019 Mazda CX-5 failed prematurely due to a known defect. The vehicle is currently at Fred Beans Mazda in Mechanicsburg, PA, where the issue has been diagnosed and confirmed. The defective component is available for inspection upon request. This failure created a serious safety risk due to an oil leak, which led to smoking from the engine bay and a potential fire hazard. If the oil had ignited, this could have caused severe vehicle damage or injury. Additionally, the failure could lead to a sudden loss of power while driving, increasing the risk of an accident. The problem has been reproduced and confirmed by the dealership, and Mazda has been contacted regarding assistance. They have acknowledged the issue but have not provided full coverage for the repair. Prior to the failure, there were no warning lights or messages. The only symptom was an oil leak, which led to smoke coming from the engine. This issue appears to be a common problem with this model, and Mazda should take responsibility for addressing it properly before it causes serious harm.

Filed Dec 25, 2021 · Electrical, Engine · CA

I was driving on the highway, at about 65 mph. The engine lost power and the car began to slow down. It did not respond to the accelerator, but the power was still on. I was lucky enough to be able to pull over to the shoulder without colliding, but it was extremely fortunate that no cars were obstructing me at the time. I put the car into park once stopped and turned the engine off. I tried to restart but the engine did not turn over and several warning signs came up on the dash and the car emitted irregular dinging/beeping noises before going silent (I do not recall specifically, but I believe the check engine and/or battery indicator lights came on) The hazards worked, also the interior lights. But I was stranded in a remote area in complete darkness on a very narrow shoulder with large trucks whizzing by. A CHP officer appeared eventually and expedited a tow truck, which brought me to the nearest Mazda dealership 100 miles away. It was midnight by the time we arrived. Both the tow truck driver and the technician (the next morning) were both unable to jumpstart the car. Engine would not turn over at all. The technician opened up the engine and sent reports to Mazda. We are waiting to hear back but they would not give me a loaner vehicle without knowing the cause of the failure. Very relieved I was not hurt but also very upset at the chance I could have been.

Filed Jun 15, 2021 · Electrical, Engine · CA

Driving on highway, cruise control ser to 82, no cars in front. The car suddenly jolted twice, engine light and battery light comes, lost of power. Pulled over to shoulder in the middle of nowhere in Nevada. Tried to start the car, engine won't turn on, starter just kept cycling. Veh temp was just below 210 with a 1/4 tank of gas. Called dealership and service person asked is to use key to turn on car, no change and provided no other solution other than to take to dealership with the closest one being over 300 miles away. We decided to unhook and rebook the positive side of battery. Car restarted and currently driving it home as I write this complaint. 600 miles overdue for maintenance (by date due on July 26, 2021) and was scheduled upon return from trip which at the time should be approx 1000 miles over due.