2016 Mazda CX-9: fire, smoke or burning smell

Filed Sep 16, 2025 · Engine · 148,000 miles · FL

The contact owns a 2016 Mazda CX-9. The contact stated that while driving approximately 45-50 MPH, the vehicle suddenly lost motive power with white smoke coming from the front of the vehicle. The contact was able to get to the side of the road to inspect the vehicle and became aware that there was coolant splattered all over the engine compartment. The failure had occurred twice. The “WRENCH” symbol was displayed with the “Service Vehicle” message displayed. The vehicle was taken to the dealer, who diagnosed that the coolant pump and water pump were leaking, and the radiator needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The manufacturer opened for the failure. The failure mileage was approximately 148,000.

Filed Nov 13, 2024 · Engine · NV

While my wife was driving her 2016 Mazda Cx-9 Grand Touring on the freeway, many of the dashboard indicator lights came on warning her the engine was over heating and to pull over immediately. While she was attempting to move over to the shoulder, smoke appeared from underneath the engine hood which made it difficult to safely move over to the shoulder. She believed the car was on fire so immediately exited the vehicle along with her sister whom was pregnant. I arrived within minutes and noticed the engine compartment was smoking and coolant/engine oil leaking underneath the car. The car was towed to my local Mazda dealership where I was advised days later the engine needed to be replaced due to blown head gaskets. They advised the vehicle over heated causing oil and coolant leaking from cylinder head that is warped. This repair would cost $11, 179.29. Mazda service advisor also mentioned the radiator and lower/upper radiator hoses needed to be replaced. This repair would cost $2691.28. This incident could've resulted in serious injuries or death from a known issue with these engines by Mazda. It's only a matter of time before this failed engine turns into a fatality. Do the right thing Mazda and fix these engines. Your reputation is on the line.

Filed Apr 12, 2024 · Electrical, Seats · MA · fire

My seat warmer caught fire and burnt a hole through the seat.

Filed Jul 15, 2022 · Driver assistance, Engine · TN

On 04/21/22, I took my car to the dealer after noticing antifreeze on our garage floor and a burning smell. NO check engine lights had illuminated. They proceeded to tell me that there was a coolant leak from head/block and cavity leak (something about channel pressure). They also stated this was a casting flaw during manufacturing of the engine. They told me I needed a whole new engine for $8,479.97! Mazda corporate refused to replace the engine at their cost because I had 64,575 miles on it and it was out of powertrain warranty. I called them and asked to speak to a supervisor and never heard from them. I called on 4/26, 4/27, 4/28, 5/4, 5/5 (5 times), 6/9, & 6/20. I finally gave up agreed to pay $7,479.97 (the dealer gave me $1,000 off). I received the car back on 05/20 and it would not start later that day. They towed it back to Mazda and they replaced the crankshaft sensor that was damaged upon install of the new engine. I received it back again on 05/31 and later in the day, the check engine light came on and the automatic braking system engaged while I was driving (thankfully only 40 mph). I managed to pull over in a turn lane before the engine died. I was so thankful I did not make it onto the interstate I was about to enter! Mazda came and picked me up and later got my car. They could not figure out why it was dying and finally got it to recreate it. They replaced another engine sensor and then drove it a lot to make sure it was truly fixed. I finally received my vehicle back on 07/07. I am afraid to take my car out of town and it makes me nervous it will die and automatically start braking again. They KNOW this is a manufacturer issue and they refuse to take responsibility. I am so disappointed in them. This is a huge safety issue. I am also lucky I didn't blow a head gasket before I took it into the shop the first time.

Filed Sep 30, 2019 · Electrical, Engine · 17,061 miles · LA

11/16/18 towed for inoperabilty. Stuck fuel injector/ ruined engine. All panel lights came on. Kept car for 57 days. Fuel injector # 1 failed. We were driving onto interstate. While working on car, exhaust stud broke off into turbo charger housing. Drilled out and rethreaded took back to mazda dealer to c/o about swooshing noise in r dash said they did not hear. This occurring with acceleration 2/7/19 while driving out of state on interstate , swooshing noise r dash lost acceleration while passing. St peters , mo dealership had to put back on the turbo hose & clamp 5/6/19 back home and again heard the swoosh noise on acceleration. Dealership replaced gasket to turbo charger / air leak with smoke test 9/14/19 again became inoperative while driving out of state immediately after passing large truck, lost acceleration with pedal to carpet. Was told in limp mode smelled something in car compartment. Stuck on narrow county road. Limped to turn off. On inspection by tow truck person, stated was pouring gasoline from front of car. 'this could have caught fire due to 90+ degree temp in tex. Fuel injector # 4 exploded mechanic on inspection told serv mgr this car was put back together in a shoddy manner. The hose to fuel injector had previously been routed wrong when engine replaced. Now waiting on malfunction of fuel injector 2&3. Scared to drive car. C/o to mazda customer rep. His response well u have warranty until 4/2024. That is b/c we took extended warranty. Hollingsworth mazda in baton rouge, la closed reason unknown. *tr consumer stated error to vehicle speed instead of 10-15 MPH.

Filed Jan 7, 2019 · Brakes · 41,000 miles · NC

I was driving on the interstate and the TPMS warning came on. I pull off the interstate and park. There is smoke coming from the right rear wheel and the center of the wheel is extremely hot, too hot to touch. I can feel the heat from about a foot away. There is metal pining and groaning as it cools down, the tire is warm, but not as hot as the center a the wheel. The left rear wheel is cool to the touch, as are the front wheels. I toggle the electronic parking brake a few times and after the wheel has cooled down I drive on. The problem did not occur again in the last 60 miles, however, the right rear wheel now makes a noise when brakes are being applied consistent with the rotation of the wheel.