2011 Mercedes-Benz C300 fuel system problems

Filed May 24, 2026 · Fuel system · NJ

Strong fu Smell after filling tank recently. Checked under the passenger side rear seat and there is some fuel on the top of tank. Local mechanic confirmed and mentioned not to fill tank more than half. Requires replacement of fuel tank to fix it

Filed Aug 25, 2025 · Electrical, Fuel system · TN

The electronic steering wheel lock went out causing the car to not start. Upon checking the Internet to see if anyone else was having this problem I found that it was a problem many Mercedes Benz owners have had and it's an expensive one. It's not just with my particular model and it's not limited to older models of the brand either.

Filed Oct 23, 2024 · Acceleration, Airbags · TN

1.What component or system failed or malfunctioned, and is it available for inspection upon request? The fuel system failure is a highly critical safety concern, and my life is at risk. It causes malfunctions with the vehicle, for example, the OBD-based emissions test has flagged a lot of (codes P219A, P0300, P0304, P0410, P0305, P0303, P0171, P0301) 5 of the cylinder misfire codes with the check engine light on, as well affecting other parts in the vehicle function properly, acceleration issues, car stalling as though it’s going to shut off. This is a serious matter and Mercedes-Benz is failing to prioritize customer safety, over cost especially when known faults in the vehicle can lead to potentially life-threatening incidents such as fuel leaks and fire hazards. Yes, the vehicle is available for further inspection upon request immediately each day my life is at risk. 2.How was your safety or the safety of others put at risk? My safety and other's safety are put at risk every time I get out on the road to drive my car it's putting me and other' live in serious danger (especially with the extreme increase in car accidents in the local Nashville, TN area). Despite the vehicle now being 3,000 miles over the 150,000-mile extended warranty threshold. I recently purchased the car on [XXX] and was not made aware of Mercedes Benz having any extended warranty coverage for the faulty fuel system that Mercedes-Benz had placed on this model. I can only assume the previous owner the car was reposed from was also unaware of this as well. I believe Mercedes-Benz should still cover the cost of this repair. The fuel system failure is a critical safety concern, and Mercedes-Benz should prioritize customer safety, especially knowing there were faults of poor quality that they discovered with their vehicles and can lead to potentially life-threatening incidents such as fuel leaks and fire hazards. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 30, 2023 · Fuel system · WA

The contact owns a 2011 Mercedes-Benz C300. The contact stated after adding more than 3 gallons of fuel to the vehicle, there was a strong fuel odor inside the cabin of the vehicle. The contact stated that the failure had been recurring and was making him unwell. The vehicle was taken to the dealer, where it was diagnosed and determined that the failure was related to the federal safety agency Campaign Number: 12V557000 (Fuel System, Gasoline). The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was unknown.

Filed Sep 7, 2023 · Fuel system · CA

On 8/3/2023 we could smell a strong gasoline smell inside and outside our 2011 Mercedes C300. We towed the car to a Mercedes specialty repair shop for inspection. The found that the passenger side fuel pump cover (which is a large cylinder assembly actually) was leaking due to cracked plastic. Gas vapors could be detected outside the car, in the trunk, and in the car as the gas tank is right under the back seat. Our mechanic said he had just fixed another Mercedes with the exact same problem. Apparently this is a well known defect and I understand that Mercedes has an extended warranty for later models. We believe the extended warranty should be extended to our 2011 C300 which has only 55,000 miles.

Filed Jul 21, 2023 · Engine, Fuel system · VA

There is a crack in the flange causing a fuel leak in my C300 2011 Mercedes-Benz built March 2011. A strong gas smell fills the car. This situation is extremely dangerous and should be included in the recall that was approved for vehicles C300 manufactured from April 2011-July 2011. Please include my vehicle in this recall. There is only a one month difference.

Filed Jul 21, 2023 · Fuel system · SC

I suspect a failure in the fuel tank / system seal, which is allowing gas fumes into the cabin. There is a strong smell of gasoline inside the cabin especially after a full tank refill. This issue was also a problem for my 2008 Mercedes Benz E350. It has not been inspected but since my E350 had a similar extended warranty repair, I assume this would be similar. The strong fumes and odor in the cabin is a health risk of breathing the fumes or explosion. There are no warning lamp to indicate this failure. No recalls or extended warranty currently to fix this problem.

Filed Jul 21, 2023 · Fuel system · VA

Each time I filled my gas tank, there was an overpowering odor of gasoline inside the car and outside on the passenger side. Once the tank would get down below 3/4 of a tank, the odor would dissipate until down to a 1/4 of a tank it would go away completely.

Filed Jun 21, 2023 · Fuel system · KY

My check engine light came on approximately one month ago. Once tested it indicated a fuel vapor leak. I pulled out of a driveway and a large stream of fuel spilled all over the roadway. Approximately 7 feet in length about 5 inches in width was on the road. I took it to a Mercedes repair shop and they informed me I had a fuel leak and that it was not safe to drive. There was corrosion and rust forming on the tank which seems very odd since the car is garage kept and we don't get much snow in Kentucky. My daughter rides in this car with me and they told me it is very dangerous and needs repaired. If I was to drive over a cigarette we could essentially blow up. I had a second shop look at it and they also informed me I had a fuel leak and would need to replace the fuel tank. I was told there was a recall on some models of Mercedes for this issue but can't seem to find one on my year make and model. Please help with this matter so my daughter and I can remain safe as well as others around us. Seems like we are in a ticking time bomb.

Filed Oct 5, 2022 · Fuel system · PA

When fuel tank is greater than approximately 3/4 full there is a strong fuel odor that seems to emanate from the rear passenger side of the vehicle; at lesser fuel quantities the odor is not noticeable. On one occasion I detected what appeared to be fuel dripping from underneath the vehicle. Took vehicle to dealership for troubleshooting and was informed "fuel leaks at the fuel pump" and it was recommended that the fuel pump and fuel sender be replaced. Additionally, the leak apparently damaged the electrical wiring harness to the fuel pump and that also needs to be repaired. There were no warning lamps or messages displayed that alerted me to this problem. Obviously, this is a hazard to safety.