Hi, in the Fall of 2025 my 2016 Mercedes Benz C300 4 Matic, started giving off smelly fumes while my car was idling/ warming up. I registered a complaint with the Corporate Mercedes Benz Office USA, LLC in April 2026 @ 800‑367‑6372, after the dealership would not correct the issue free of charge. 1. Hose Clamp Replacement problems. 2. The raw fuel leakage produces strong gasoline odors inside the cabin- via the air filter, risk of car stalling and the smell could be leathal. 3. The problem was confirmed in a lawsuit. 4. The dealership would not repair the issue. 5. There were no warning lamps or messages on the dash board, the only essential issue were the smells, fumes, odors and lawsuit.
2016 Mercedes-Benz C300: fuel leak
18 of the 291 complaints about the 2016 Mercedes-Benz C300 describe fuel leak.
- owner complaints
- 18
- of this car's complaints
- 6%
- typical mileage
- 60,000
- recalls
- 1
Is there a fix? There is 1 recall and 4 service bulletins for this area of the car. See below
Fuel leak by model year
What owners say
fuel lines/ clamps defective causing a fuel leak. vehicle could catch on fire and fumes are extremely strong inside the cabin. issue confirmed by Mercedes dealer, mentioned there is an extended warranty up to 120,000 miles. rejected mine because i was at 120,300 miles. had to pay out of pocket. no warning lights or anything just the really strong smell of fuel and fuel range dropping. this is a very common issue thats known and should be a recall.
The contact owns a 2016 Mercedes-Benz C300. The contact stated that whenever the fuel tank was full, there was a fuel-burning odor coming from the engine and entered the vehicle through the A/C vents. In addition, when the vehicle was cold, the odor was entering the vehicle through the A/C vents. No warning lights were illuminated. The vehicle was taken to a collision center specializing in foreign vehicles, where it was diagnosed that the fuel rail and injectors had a fuel leak. The vehicle was not repaired. The contact stated that the failure persisted. Upon further investigation, the contact related the failure to the federal safety agency Campaign Number: 21V961000 (FUEL SYSTEM, GASOLINE). However, the VIN was not included. The contact stated that his mother owned the vehicle in the past and gave the vehicle to the contact two years ago. The contact's mother remembered receiving a recall letter; however, the contact's mother was unsure if the vehicle had been repaired in the past. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 60,000.
An independent service center diagnosed my car as having a fuel leak stemming from the fuel rail and fuel injectors. This is a fire hazard due to a gas leak. There is a gas smell in the interior cabin that I noticed approximately one month ago. I believe this pertains to the federal safety agency ID #21V961, and I would like the federal safety agency to consider including my VIN in this recall.
The contact owns a 2016 Mercedes-Benz C300. The contact stated that there was an abnormal fuel odor inside the vehicle when the heater was activated. The contact stated that the cabin air filter was replaced; however, the odor was lingering inside of the vehicle. There was no warning light illuminated. The vehicle was taken to an independent mechanic to be diagnosed and the contact was informed that there was gas leaking onto the transmission and that the fuel rail, fuel hose, and fuel injectors needed to be replaced. The contact referenced the federal safety agency Campaign Number: 21V961000 (FUEL SYSTEM, GASOLINE); as a possible cause for the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 53,000.
Fuel is leaking inside cabin whenever I turn on my heat
I have noticed a recurring issue during the colder months where there is a strong gas smell inside the cabin, and I have also observed fuel dripping into the engine compartment. This issue seems to occur primarily in winter conditions. I was surprised to find that there has been no official recall or service bulletin addressing this concern, especially given the potential safety implications.
There is a fuel leak in the engine area and as well.as.undermeath the vehicle and Mercedes only covers a extended warranty which is not fully fixing the issues gas is a dangerous thing and I would.wjy haven't there been a recall on this know.issue with these w205 Mercedes
Mercedes Benz Selma, Texas Dearlership refuses to service known issue with fuel system leaks on C300 because they cannot reproduce problem. Problem is that don't have the correct environment to test for this know problem. “There is a short rubber fuel line/hose in the engine compartment that is attached with compression clamps; the hose connects the fuel line from the gas tank to the high pressure fuel pump. When it gets cold outside (below ~40 degrees Fahrenheit) the clamps loosen a bit and the hose will leak gas. This is what you will smell in the cabin. Once it gets warmer outside or the engine bay warms up, the smell will tend to go away. No clue how they've gone all this time without a safety recall, but I did make a report to the NHTSB last month when it started happening to me.” The fix is to have the rubber line w/clamps replaced. If you still have warranty the dealer can take care of it. (Provided they are configured to test for this defect properly which they are not. Bottom line, fuel leaks in garages like mine with a gas water heater are a BIG issue. I alerted the dealership that they and MB would be liable if something were to happen since they refused to repair vehicle.
This auto has approximately 45,000 miles on it and was found to have a fuel leakage issue on a high pressure pump and a fuel hose. Gas smell was very bad and upon inspection, gas was leaking at the hose / pump connection directly onto the engine. I had the defect repaired for a total of $1288.57 and tried to submit the claim to Mercedes. I found out that this issue has been a problem for Mercedes and they have published an extended warranty rather than issue a recall. Mercedes has now declined the complaint and because this seems to be a major issue I wanted to press this with your agency. Please let me know if you would like any additional documentation regarding this matter. Thank you - [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
The contact owns a 2016 Mercedes-Benz C300. The contact stated he noticed an abnormal fume odor entering through the air vents of the vehicle. The contact self-diagnosed the vehicle as having a fuel leak from the fuel pump. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 83,000.
Horrible fuel smell coming through Air conditioning vents on cold start up. This presents a safety hazard as there is an obvious fuel leak on a still late model vehicle with no safety recall in sight.
Service bulletins that may apply
Related recalls
Fuel system, gasoline: fuel injection system: fuel rail
- What is wrong
- Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2019 AMG G63, C300, E300, G550, AMG GT63, AMG GT53, 2019-2020 A220, GLA250, GLC300, 2016 C300, 2020 AMG A35, AMG C43, AMG C63, CLA250, E350, E450, GLB250, GLE450, GLS450, GLS580, S560, and SL550 vehicles equipped with a gasoline engine. During the manufacturing process, particles may have been trapped between the fuel rail and injectors, which can cause a fuel leak.
- Risk
- A fuel leak in the presence of an ignition source, such as hot engine or exhaust components, can increase the risk of a fire.
- Remedy
- Dealers will replace the fuel rail and fuel injectors, free of charge. Owner notification letters were mailed April 22, 2022. Owners may contact MBUSA customer service at 1‑800‑367‑6372. MBUSA's number for the recall is 2022030003.
Recall number 21V961000 · Recall details
Questions about the 2016 Mercedes-Benz C300 fuel leak
Is fuel leak a common problem on the 2016 Mercedes-Benz C300?
18 of 291 owner complaints about the 2016 Mercedes-Benz C300 (6%) mention fuel leak. The model year with the most reports is 2016.
Is there a recall or service bulletin for this on the 2016 Mercedes-Benz C300?
There is 1 recall and 4 service bulletins for the same area of the car. Check them below with your VIN.
Other symptoms on the 2016 Mercedes-Benz C300
Check engine light 60Fuel smell 46Stalling 10Sunroof shattered 10Engine failure 7Fuel pump 7Loss of power 7Fire or smoke 6
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Mercedes-Benz C300?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history