2008 Mercedes-Benz E350: won't start

Filed Apr 17, 2020 · Fuel system · 162,443 miles · WA

I have a 2008 mercedes e350 pzev model and the issue I came across is a major one. These models in particular have a big reputation on failing fuel pumps, and to make things worse on the pzev versions it can not be fixed unless the whole fuel tanked is swapped with a new one. The fuel pump is located inside the gas tank and its sealed just so there's no way of fixing the issue, on the other hand the non-pzev models have a replaceable pump which reduces the work and money to fix the issue. Mercedes has an applied extended factory warranty for the model w211 which covers this issue until 15years / unlimited miles for non-pzev models and 15years / 150k miles for pzev models. I see this very wrong because the pzev models are super expensive to fix and many people are over the 150k mile mark. This term should have been applied to the pzev models. I purchased this vehicle for $3,200 but to fix this problem it is over than $3,500. I am requesting mercedes to help me on this situation as these cars are well know to fail in that department. As it stands this car is unsafe to drive, it releases lots of raw gas smell and sometimes it will not start. I want mercedes to take full responsibility of this matter because this issue could have been a couple hundred dollar fix if the design after tank wasn't so bad. There are thousands of people complaining about the same issue with the pzev models and most of them are over the 150k mile limit which is not enough considering the age of the vehicles.

Filed Apr 22, 2018 · Fuel system · MI

Drove the car 20 minutes started to notice smell out of the back seat gasoline 5 min later it stalled 2 streets from my house. . Tryed starting the cranking over but no start. The next day shop called told me that both of the fuel pumps in the gas tank are bad. 1.500.00 dollar repair. Is that safe for fuel pumps do do that

Filed Jul 12, 2017 · Fuel system · 109,000 miles · GA

Tl* the contact owns a 2008 mercedes-benz e350. The contact stated that when operating the vehicle with a full tank of fuel, a fuel odor was present inside the vehicle. In addition, the vehicle would not start and was towed to the mercedes-benz of augusta, georgia dealer where it was diagnosed that the fuel pump was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and no assistance was offered. The failure mileage was 109,000. Updated 10/24/17*lj the consumer stated the vehicle was repaired. The fuel pump was replaced.

Filed Jul 27, 2015 · Fuel system · 142,307 miles · GA

The crankshaft sensor failed due to separation of bond wires from the lead frame in the sensor. This results in an interruption in the electrical connection in the chip housing of the sensor. The electrical fuel pump is not receiving a crash signal that is required for the fuel pump to disconnect and prevent future fuel delivery as designed. * my vehicle is experiencing the same issue as the recalled 2008 e350 models. The car will not turn over or start. There's a faint gas smell coming from the back seat. The fuel pump is not sending a signal to the my vehicle is currently with an authorized mb servicer, however, mbusa dos not want to pay for the recall issues.

Filed May 18, 2015 · Engine · 91,000 miles · AL

Vehicle crank but will not start took to shop diagnostic revealed a bad crank sensor and bad sprocket/ cam shaft.

Filed May 18, 2015 · Engine · 91,000 miles · AL

With reference to previous email shop called and stated that the balance shaft on the car is bad. Engine light did not come on . Parked car in the garage tried to start next morning car crank but will not start.