Tl* the contact owns a 2002 mercedes-benz s430. The contact stated that illumination of the instrument cluster was inadequate to see the gauges. Fletcher jones imports (7300 w sahara ave, las vegas, nv 89117, (702) 364-2700) was contacted and informed the contact that the vehicle warranty expired in 2012. The contact was informed that a diagnostic test needed to be performed. The manufacturer was notified of the failure and referred the contact to take the vehicle to the dealer to be diagnosed. The contact mentioned the federal safety agency campaign number: 06v028000 (interior lighting) as a possible solution to the failure however, the VIN was not included. The failure mileage was approximately 209,000.
The worst 2002 Mercedes Benz S430 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Electrical20
- Lights8
- Suspension8
- Transmission2
- Acceleration1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Electrical20
- Lights8
- Suspension8
- Transmission2
- Acceleration1
- Body1
- Driver assistance1
- Visibility1
Recalls
No recalls on record for this model year.
Technical service bulletins for the 2002 Mercedes Benz S430 38
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Repeat workshop visit for vehicle vibration while braking from 60MPH. NOTE: Although the symptom is...
- Clanking noise from the area of the speakers in the doors
- Single throttle lift-off clunking noise from the side shaft when moving off (audible at the outboard end)
- There are several types of complaint about noises or poor windshield wiper wiping performance: A: Wiper...
- Headlamp, front fog lamp leaky or fogged
- Headlamp, front fog lamp leaky or fogged
- Single throttle lift-off clunking noise from the side shaft when moving off (audible at the outboard end)
- Headlamp, front fog lamp leaky or fogged
- Headlamps leaking or fogged
- Vehicle with atypical reduced heat output
2002 Mercedes Benz S430 fuel economy
Official EPA estimates in miles per gallon (MPGe for electric). Ranges cover trims that share the same engine.
| Engine | Drive | City | Highway | Combined |
|---|---|---|---|---|
| 4.3L 8‑cyl | RWD | 15 | 22 | 18 |
What 2002 Mercedes Benz S430 owners say
Most recent owner complaints, unedited.
I have approximately 104,000 miles, I cannot see it anymore because while driving home at night from the airport on the expressway doing 65 miles per hour, it went black. All the gauges were found stuck in their location the next morning at what they were at when the cluster went black. The cluster has never recovered and I have to drive with no idea of speed, signals operation, fuel level, or water temp. The information display is also blank so I don’t know what my mileage is or if the vehicle has any other information to give me. I had to drive home 60 miles in the dark. My headlights go on all by itself whenever I start my car now. My climate control also remains lit and causes a battery drain over a period of time. I was very lucky to make it home but now I can only drive during the daytime until I can get my instrument cluster repaired. My comfort level driving this vehicle has diminished greatly, this vehicle is my family vehicle, does mercedes benz not care anymore. If one of their family members were to perish in an accident as a result of this problem I’m pretty sure they would immediately find a solution to fix it.
Instrument lights went out, can't see speed or other dash information such as fuel. Rear suspension looses air, car sits to low to drive, body sits on rear tires. Happened while driving city street, tires smoked and are pitted.
The battery located in the trunk of the vehicle is situated next to the gas tank. There are no covers on the metal parts on the top of the battery located in the trunk of the vehicle, and the mat that comes with the vehicle does not sufficiently cover these metal poles, leaving them vulnerable to catch flame when metal items are in the back of the vehicle. The rear battery caught flame, while stationary, due to a metal rod used for furniture assembly touching the exposed portion of the battery.
While driving on 12/10/2016, the instrument cluster panel went very dark. At night there was no illumination either. Also the speedometer was fluctuating wildly from high to low and back. I could only see this with my interior light on, as the dash panel was dark. I realized I could not read any of the other the gauges including the safety warning display panel, nor did the turn signals inside the vehicle work or the volume control on the steering wheel. The vehicle was in motion at the time. The vehicle was included in the federal safety agency campaign number: 06v028000 (interior lighting). On 12/15/16 the manufacturer was notified of my failure. The manufacturer informed me that it was not a recall but a "voluntary extended warranty issue". The manufacturer explained to me that my car was part of it, but I was "out of time" with my request for repair or replacement. At the time the car had approximately 195,000 on it. This is the 5th mercedes I have owned, reading from the blogs this is a very common problem, hence the federal safety agency involvement. Mine is a documented failed case under mercedes recognized program, but they fail to follow-up with their extended warranty coverage because it is out of time. Whether it is in time or out of time a safety failure is a safety failure. One would think that a company like mercedes benz would want to keep alive a 5 time owner of mercedes and put brand loyalty over profit. I have three children now entering their car owning years. They have grown up with mercedes but I guess it is now time to show them another car brand so they can be a customer for life to another automobile company, one that will place their life ahead of the profit on an instrument cluster. I ask the federal safety agency to force mercedes to recall these safety prone cars such they cannot hide behind their "out of time" excuse.
Tl* the contact owns a 2002 mercedes-benz s430. While driving 25 MPH, the instrument cluster became inoperable and the vehicle lost power. The vehicle was able to be driven to the contact's residence. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was 108,000. The VIN was unavailable.
While driving during daylight hours on friday, 6/17/2016, I noticed the instrument cluster panel was very dark. The car was not driven again until dusk, on saturday, 6/18/2016 and I realized all of the instrument panel lights were out, the gauges were not working nor did the turn signals inside the vehicle or the automatic locks, work or the volume control on the steering wheel. The vehicle was in motion at the time of this discovery
Tl* the contact owns a 2002 mercedes-benz s430. While driving 60 MPH, the instrument panel failed to illuminate without warning. The vehicle was taken to an independent mechanic where it was diagnosed that the instrument panel cluster failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 60,500.
I purchased my vehicle new in 2002. It has about 48500 miles. I work close to home. I have already replaced the suspension air bags once and my vehicle is dropping again. I have read that this is a common problem with my vehicle year, make and model. What can I do? My vehicle is very well taken care of and I find it outrageous that mercedes benz being fully aware of this issue, refuses to take responsibility. Especially with the original price of the vehicle.
After owning my used car insurance had to replace the cluster. Found out later it was on a recall list.
Compare the 2002 Mercedes Benz S430
Other model years
Questions about the 2002 Mercedes Benz S430
Is the 2002 Mercedes Benz S430 reliable?
Owners have filed 31 complaints about the 2002 Mercedes Benz S430, 1.2 times a typical S430 model year.
What is the 2002 Mercedes Benz S430 year score?
The 2002 Mercedes Benz S430 scores 69 out of 100 (average). The score compares it with the other model years of the Mercedes Benz S430: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2002 Mercedes Benz S430?
Electrical system, with 20 complaints, typically around 111,500 miles. Next is lights (8).
How many recalls does the 2002 Mercedes Benz S430 have?
No recalls on record.
What year does the Mercedes Benz S430 have the most electrical problems?
The Mercedes Benz S430 model years with the most electrical complaints are 2001 (37 complaints), 2002 (20 complaints) and 2000 (14 complaints).
What gas mileage does the 2002 Mercedes Benz S430 get?
Official estimates for the 2002 Mercedes Benz S430 range from 18 mpg combined. The most efficient version (4.3L 8-cyl, RWD) gets 15 city and 22 highway.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2002 Mercedes Benz S430?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history