2011 Mercury Milan brakes problems

Filed May 22, 2025 · Brakes · WV

The contact owns a 2011 Mercury Milan. The contact stated that while the vehicle was at the dealer for servicing, the contact was informed that the electronic brake control module had failed. The contact was informed that the electronic brake control module needed to be replaced. The vehicle was being repaired. The manufacturer was made aware of the failure, but no assistance was provided. The contact was advised to contact the federal safety agency Hotline to report the failure. The failure mileage was unknown.

Filed Sep 1, 2021 · Brakes · 126,077 miles · AR

The contact owns a 2011 Mercury Milan. The contact stated that while his great-nephew was driving at an unknown speed, the brakes failed. The contact stated that the brake warning light was illuminated. The driver pumped on the brake pedal until the vehicle stopped. The contact took the vehicle to the local dealer, where it was diagnosed with needing the brake master cylinder, hydraulic module, and brake filler cap to be replaced. The vehicle was repaired. The manufacturer had been informed of the failure. The failure mileage was 126,077.

Filed Feb 6, 2019 · Brakes · 105,000 miles · OH

During a wintery morning I had to apply the brakes and the ABS light came on for a few seconds and then went off. Braking was only normal not urgent or anything like that. Afterwards the break pedal travel has increased significantly and have become spongy. Braking distance has increased dramatically. Safety is a big issue here because after doing a little research I've learned that this is actually becoming a typical issue for anyone who owns this car or a ford fusion. My local repair shop told me that it is probably the hydraulic control module which is part of the ABS system and sure enough I believe they are correct. I called the dealer I purchased the car from and parts and labor come to about $1,700.00!!! This part should not fail and if it does a recall needs to be issued because I know I'm not the only one with this complaint.

Filed Dec 5, 2018 · Brakes · 136,000 miles · NC

Soft brake pedal. When braking, pedal descends approximately 75% before pedal pressure becomes firm. This occurs whether the vehicle is in motion or not. The master cylinder was replaced but did not solve the soft brake pedal issue. The vehicle cannot be safely driven in it's present condition. Ford diagnosis was to replace the ABS control module and ABS pump. The total cost for this repair is $3,000.00. I understand there are multiple complaints involving ford and ABS system repairs.

Filed Aug 16, 2015 · Brakes · 70,600 miles · IL

Both brake lights when out, and went in for replacement bulbs after waiting in the dealership for 7 hours I was told that the LED brake lights were defective and it would be well over 1,000 to fix. I purchased an extended warranty that they say covers nothing!!!! (currently have a broken d riverside door handle). I purchased the car used last may, within 3 weeks I had transmission issues which were covered by the warranty, then the door handle, now brake lights. I feel these lights should be part of a recall becuz who has over 1,000 dollars to replace LED brake lights??? I'm very upset and disappointed....also broke and can't afford this repair......please help!!!!!!!

Filed Jul 30, 2015 · Brakes, Lights · 93,000 miles · WI

The driver's side brake light began flickering after the car was parked. I was also informed after this was noticed that it flickers (gets brighter) while driving. The passenger brake light also stayed brightly illuminated last year, and I was told it would be over $500 to replace the light assembly. Fortunately, my vehicle sustained an accident and the passenger light was damaged further and replaced. Now a defect is occurring on the driver's side.

Filed Mar 2, 2015 · Brakes · 36,231 miles · MA

Brought the car for state safety inspection. Inspection failed because brake lights would not increase brightness when brakes applied and headlamps on. Lights appear ok when headlamps not on. Car is unsafe to drive when headlights are required. Ford says not covered under warranty or under extended warranty. Could cost nearly $1000.00 to repair. Online forums seem to indicate it is a common problem. Afraid to drive the car for fear it will happen again and I won't know until someone runs into me.

Filed Nov 8, 2014 · Brakes, Electrical · 46,125 miles · FL

The left rear brake light is not functioning. This light is not a normal incandescent bulb. It is an LED that is not owner-serviceable. The only fix is that the entire taillight assembly needs to be replaced by the dealer at a cost of approximately $400. Any buyer's expectation is that when a light bulb burns out, we should be able to replace it ourselves for fifty cents. Since this 50-cent item is now unexpectedly $400, the net effect is that all owners will continue to drive around with two of three, one of three or no brake lights at all. This should be an immediate safety recall. *tr

Filed Sep 17, 2014 · Brakes, Electrical · 31,000 miles · NY

I was made aware of my tail light not functioning when I applied the brakes. When I tried to replace the bulb, I soon learned that the brake light is LED and a sealed unit, making it virtually impossible to repair. The replacement unit is astronomically expensive, prices between $150-$350 used. If the unit had a replaceable bulb, then I wouldn't even be writing this. I understand that nothing will most likely be done about this, but it is worth noting that this is a safety concern that needs to be addressed.

Filed Aug 22, 2014 · Brakes, Lights · 34,667 miles · IA

The LED tail lamp assembly began flickering and after a short period of time it now does not light at all. I have noted other milan vehicles in my area having similar problems. I attempted to obtain parts to repair my vehicle online and also through my ford dealer and was told that there is a shortage of parts because this defect is well known. This could certainly cause an accident at any time! I cannot park my vehicle as I need to get back and forth to work. If I receive a fix-it ticket for this I would like to bill it to ford. If a recall can be forced to issue then I hope that you initiate one.