There is a known issue by Nissan regarding many issues with the XD Diesel platform trucks. Mine is a castrophic engine failure at 76,237 miles. There was a recall previously on turbos for many 2016s & 2017s. One is not showing up for mine and as I bought the truck used can not confirm or deny my truck was one effected by this recall. I was driving and heard a light thump and had just had my tires rotated. It sounds like a tool or piece of rubber was inside the tire. I got out and made sure tires were on tight. Got back in the truck and got an engine loss of power warning and then the "oil pressure low stop vehicle" warning. I immediately pulled over and called insurance company for a tow. My truck now sits at the dealership needing a new motor and 2 turbos to the estimated cost of $39,850.
2016 Nissan Titan XD engine complaints
Page 2 of 6: complaints 11 to 40 of 135, newest first, as owners wrote them.
Dear Sir/Madam Masked Oil Pressure Warning in 2016 Nissan Titan XD (5.0L) I am writing to report a concerning and potentially dangerous defect observed in a 2016 Nissan Titan XD equipped with the 5.0L Cummins V8 diesel engine. As a Nissan Master Technician with extensive experience in vehicle diagnostics and repair, I believe this specific defect could be a contributing factor to the well-documented crankshaft breaking condition prevalent in these vehicles, which the federal safety agency is currently investigating. The specific issue I have identified and thoroughly documented on my own 2016 Nissan Titan XD is as follows: Observed Defect: The engine oil pressure gauge consistently reads "normal" (approximately 1/2 scale) at all times, including with the Key On, Engine Off (KOEO). Crucially, the corresponding oil pressure warning light does NOT illuminate during the normal Key On, Engine Off bulb check or at any other time, despite the engine not running. Diagnostic Findings (Summary): Preliminary diagnostics, including unplugging the oil pressure sensor, indicate a likely fault with the oil pressure sending unit itself, causing it to send a false "normal pressure" signal. This specific sensor defect fundamentally compromises the vehicle's critical oil pressure monitoring system. ( the engine is running ok, no other symptoms) Potential Safety Implications and Link to Crankshaft Failure: This defect creates an immediate and severe safety risk because it completely masks any actual low oil pressure condition that the engine may develop. Documentation: I have well-documented photographic evidence of the current occurrence described condition (gauge reading, non-illuminated warning light KOEO) which I can provide upon request to support this report. I urge the NTSB to include this specific oil pressure sensor/warning system defect in its ongoing investigation into the 2016 Nissan Titan XD 5.0L Cummins engine failures Sincerely, [XXX] Nissan Master Technician ASE-1104-7529 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION
My vehicle spun a bearing, or broke the crankshaft in two, there is tons of metal in my oil, oil pan, and oil filter. The shop that is diagnosing it, and quoting me a new motor, said they have replaced AT LEAST 7 titan xd Cummins motors, and every single forum and person online that owns one reports the crank shaft breaking. Nissan or Cummins needs to be held responsible for this. And the federal safety agency needs to put their foot down and actually protect American consumers. They sold these trucks for at minimum 40k and the motors all blow up around 100k miles? Absolutely disgusting that they can get away with this. What do expect in America I guess
Engine made a loud popping noise, shuttered and stalled in heavy traffic, I came within inches of being rear-ended. Required a tow truck. Repair shop informed me that the crankshaft is broken and this is a common problem. Being repaired at this time, I am informed this will cost about twenty thousand dollars. Thank you Nissan!
During cruising at 70mph on the interstate, vehicle started making some noise from the engine and 5 miles later locked up completely leaving me stranded. This is a known issue with the 5.0 Cummins. My safety and the safety of others was put at risk through the vehicle being disabled on the side of the highway all of the sudden during rush hour traffic. Problem was confirmed at a dealer. No warning lamps or messages prior to complete engine failure, just some slight noise from the engine a few minutes before.
The contact owns a 2016 Nissan Titan. The contact stated while driving 35 MPH, the vehicle stalled. The contact was able to pull into a nearby parking lot. The check engine warning light was illuminated. The vehicle was able to restart and was driven to the residence. The vehicle was taken to the dealer, where it was diagnosed that the turbocharger had failed and needed to be replaced. The dealer informed the contact, that the dealer was not certified to repair the vehicle. The vehicle was not repaired and was towed to Lorenzo Nissan (30501 S Dixie Hwy, Homestead, FL 33030); where the same assessment was provided. The dealer informed the contact that the manufacturer had denied the Extended Warranty coverage. The vehicle was repaired at the owner's expense. The manufacturer was notified of the failure. The failure mileage was approximately 34,859. The VIN was not available.
Crankshaft failure, it broke Driving down the interstate and it died Mechanic came to my house and diagnosed problem No, it has not been inspected by a manufacturer or anyone else No, there was not any warning lights or any kind of warning whatsoever
The contact owns a 2016 Nissan Titan XD. The contact stated that while driving at 80 MPH, the engine was seized. There were no warning lights illuminated. There was an abnormal grumbling sound from the engine. The vehicle coasted and came to an abrupt stop. The contact stated that he experienced a catastrophic engine failure. The contact sustained a seatbelt rash and whiplash, but medical attention was not provided. The crankshaft had snapped. The driver was stranded for two hours in the desert. The vehicle was towed to his residence. The local dealer was contacted, who recommended an engine replacement. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 180,000.
The Crank snapped at 180k miles.
5.0l Cummins engine. Was driving fine then the crank shaft snapped and ruined the engine.
The crankshaft snapped and locked up the motor. My safety was at risk as well as oncoming traffic because it could have caused an accident when locking up the motor. It has been confirmed by a local diesel mechanic. There was no warning at all, I was driving down the highway at 75 and as I started to go up an incline the truck had to downshift and it started to knock loud and then froze up and the truck came to a fast stop.
While driving at about 55 mph truck suddenly lost power engine shaking and making a lot of noise pulled over to check under the hood couldn’t see anything obvious so I tried to make it home which was about 2.5 miles away truck would not make it so I pulled it into an empty parking lot a walked home.
What component or system failed or malfunctioned, and is it available for inspection upon request? Fuel system/oil system catastrophic engine failure. Yes it is How was your safety or the safety of others put at risk? Truck shut down on highway at 70 mph with a child and wife in the truck Has the problem been reproduced or confirmed by a dealer or independent service center? Truck needs a complete motor. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Inspection was through a well know ase diesel technician Were there any warning lamps, messages or other symptoms of the problem prior to the failure, no there was not and when did they first appear? N/A
Engine crankshaft broke, was cruising down the highway doing 70 in the fast lane, lost power steering then realized the truck was not running any longer, thankfully it was at night and the highway wasn't busy and was able to coast back to the right side of the highway to an exit ramp, but could have been a lot worse. Had no warning truck was running perfectly fine before hand, it did restart a couple hours later but has a loud knocking and low oil pressure light comes on it shuts down. Had to get towed. Vehicle is able to be inspected any time, I still owe on it and dealership is quoting 25k to 30k to repair and truck is not worth that. Have been told by multiply shops that this is becoming and issue with these trucks. The component has not been inspected by anybody mention above in your questions. No warning lights and no signs that it was going to shut off.
Loud rattle/knocking from engine while driving. Truck shut down with no advanced warning and would not start or turn over. Got off road and had vehicle towed. 2 different diesel mechanics suspect broken crankshaft.
.Crank shaft and bearing failure - metal in oil pan. .Stranded on side of interstate towing a boat 7 hours from home .Confirmed by dealer .No .No warnings or symptoms
Crankshaft failure.
Engines blown. Needs new engine.
The contact owns a 2016 Nissan Titan. The contact stated while driving at an undisclosed speed, the vehicle lost motive power. There was no warning light illuminated. The vehicle was towed to the dealer where it was diagnosed that the crankshaft had failed, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 90,000. The VIN was not available.
Driving down the road, truck lost all power and shut down, towed to the local nissan dealership, needs a new engine, Truck has 89k miles on it
Driving down highway lost power, pulled over halfway off road, attempted to restart. Was able to start and move ten feet, then shut off and would not restart. There was no warning before hand. Took to independent mechanic and disassembled the engine. Crankshaft was broken in three places. Contacted dealership and was no longer warrantied. Mechanic could not find reason for failure, he thought it might be harmonic based failure. Purchased and installed a used engine. Disappointed in parts availability from Nissan.
Driving down the interstate on cruise control at 75mph and the Crankshaft snapped.
Was driving down the road on January 1, 2022 headed home and truck seized accelerating and once I pulled over the road. Truck shut down, wouldn’t turn on. Took it to a diesel shop and they told me the crankshaft had seized. Paid over $14k to get it rebuilt at ONLY 67k miles on my 2016 Nissan Titan XD. Almost caught on fire as I tried turning on since I did not know what the issue was at first.
What I believe is the engine over boosted and snapped the crankshaft. Cost around $23,000 to replace.
Was driving down the highway and I heard a loud banging out of nowhere from my engine. Whole truck shut off in the middle of the highway I pulled it over to side of road and called a tow truck. They took it to a dealer ship and I was told my crank was broken and they wanted 20,000 to replace whole motor. There was no warning lights nothing it just happened out of nowhere at 101,000 miles so I missed my warranty by 1,000 miles and had to pay 20,000 dollars to fix a truck that’s not even worth 20,000 any more.
Broken crank @ 147291 miles. Pretty much the same as all the other complaints.
The crankshaft broke. The truck was operating normally and is regularly driven. A loud banging noise was heard and the truck lost power while running. Smoke came from the tailpipe and the check engine light came on. The truck was operating normally until this incident. If this had occurred on the interstate it would have posed a significant safety risk to the occupants and other vehicles.
Failure with injectors lead to broken crankshaft. Pics attached of broken crankshaft. I was driving at 70 mph and extreme vibration began to which i had to immediately pulled off the road. Luckily no other vehicles were around me. This is a known defect from Nissan that they refuse to acknowledge. No warning lights or engine malfunctions preceded this, very dangerous.
Driving down the highway at around 70mph. Suddenly the engine started making a loud clattering noise and shut off, leaving me without power steering and I could barely control the vehicle to get off the highway safely. When I finally came to a stop I tried to start the truck and it wouldn’t start. I had it towed to my house where it has sat for the last 7 months.
I was driving the truck it started knocking extremely bad and shut off while driving and will not do anything now.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Nissan Titan XD?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history