The contact owns a 2016 Nissan Titan XD. The contact stated that there was an abnormally strong fuel odor coming from the vehicle and there was an abnormal sound coming from the engine while idling. The contact stated that while driving 55-60 MPH, the vehicle went into LIMP Mode, and the driver had to pull over and wait for approximately 10 minutes before resuming driving. The check engine warning light was constantly illuminated. The messages "DEF System Severely Impacted" and "Reduced Engine Power - See Dealer" were displayed during the failure. The vehicle was taken to the dealer; however, the dealer declined to perform repairs under TSB Number: NTB19-017 associated with the failure because the required trouble code was not retrieved. The contact, who was an independent mechanic, retrieved the required DTC through a diagnostic scan. The contact stated that the dealer denied repairs due to a lack of warranty extension coverage. After the contact provided proof of warranty extension coverage, the vehicle was taken to the dealer twice, where an actuator was replaced; however, the failure persisted. The vehicle was taken to Route 9 Nissan (273 Turnpike Rd, Westborough, MA 01581), where the contact was informed that the vehicle was not covered under the warranty extension and did not produce the required code. The manufacturer was notified of the failure, and two cases were filed. The manufacturer initially denied the warranty extension coverage but later informed the contact that the vehicle required another dealer diagnosis before coverage or field technician inspection could be considered. The contact stated that the manufacturer’s national history record for the vehicle listed the fuel type as gasoline instead of diesel. The failure mileage was approximately 135,899.
2016 Nissan Titan XD engine problems
135 complaints (68% of all complaints for this car). Typical mileage when it fails: 25,500. 2 crashes reported.
- owner complaints
- 135
- of this car's complaints
- 68%
- typical mileage
- 25,500
- crashes
- 2
- recalls
- 0
Which part fails
- Exhaust system: emission control1
- Exhaust system1
- Engine: gasoline: turbo/supercharger1
At what mileage
Complaints by mileage at the time of the problem.
Specific symptoms reported on the 2016 Nissan Titan XD engine
Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.
Engine failure 34Loss of power 28Check engine light 23Knocking 11Stalling 11Won't start 7
Related recalls
No recalls on record for this model year.
Related investigations
Loss of motive power due to broken crankshaft with no ability to restart.
On November 15, 2023, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE23020 to investigate allegations of loss of motive power in model year (MY) 2016 through 2019 Nissan Titan XD trucks equipped with 5.0L Cummins diesel engines.  The complaints allege the condition was due to a failure of the engine crankshaft.  The purpose of the investigation was to understand the scope, frequency, and safety related consequence of the alleged defect. During the investigation, it was found that the subject vehicles can experience a loss of motive power due to a failure of the crankshaft main bearings which can lead to a fractured crankshaft. This resulted in a loss of motive power and an inability to restart. An analysis of all complaint sources shows many vehicles exhibit knocking, vibration, malfunction indicator lamp (MIL) warnings, and/or poor engine performance prior to a total failure.  Some consumers report driving their truck in for repairs only to be diagnosed with a failed crankshaft.  ODI has not identified any injuries or fires attributable to this failure. ODI is aware of one complaint alleging a non-injury crash involving a curb strike. ODI is also aware of complaints of overheating starter motors and melted starter motor wiring occurring after prolonged attempts to start engines that have suffered a broken crankshaft. In its response to ODI's January 26, 2024 information request letter, Nissan provided information detailing several material and process changes involved in the production of the subject vehicleâs engine.These changes appear to coincide with incremental improvements in failure rates but there is no indication that a single factor was the primary cause of the failures. Analysis of ODI consumer complaints and manufacturer provided data found that failure rates decreased progressively for each model year. Review of failure mileage found that 50% of the failures occurred by 60,000 miles with a significant decrease in failures after 80,000 miles. Assuming average yearly mileage driven, the newest model year trucks (2019) would be near or past peak failure mileage. Given the low failure rate, the observable warnings available to the driver, and much of the fleet being past peak failure mileage, ODI is closing this Preliminary Evaluation with no further action. The closing of the investigation does not constitute a finding by the federal safety agency that a defect does not exist, and the federal safety agency will take further action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to
PE23020
What 2016 Nissan Titan XD owners say
Most recent owner complaints, unedited.
Crankshaft broke.
Engine failed unexpectedly and without warning. After doing research there is a widespread problem with the 2016 diesel engine.
Truck died while traveling at 60MPH, once safely pulled over saw it shutdown due to low oil pressure. Checked the oil level and found correct level on dipstick. Attempted to start, no start. Towed to shop, they drained the oil and verified correct oil quantity cam out. Pulled the oil pan and found metal in the oil pan. Told I need a replacement engine. Engine has 95k miles with proper maintenance performed per the owners manual.
I was driving down the freeway on cruise,when all of a sudden,the vehicle started vibrating and shaking violently.This happened in the middle of a downpour,and the tires broke loose momentarily,but I was able to gain control,and safely pull on to the shoulder.After searching the internet,this incident sounds very much like a broken crankshaft,as described in the many,many reports of this type of failure,especialy in the 2016 model years,like mine.
emission can not get a state inspection because of a bad catalytic system Nissan will not warrantee it 2016 Nissan Titan XD 67k on it 6000k to fix not right
The contact owns a 2016 Nissan Titan. The contact received notification of Manufacturer Recall Number: PD128; however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Was driving to work and engine had hiccup and almost shutoff in middle of roadway. Was able to limp truck to my destination. Engine was running rough. No fault codes or dash lights to indicate any issues. Took truck to shop and they could not figure it out. Had service shop drain oil and inspect oil filter. Metal debris was found in oil and oil filter. Had engine removed from truck and found 3 spun main bearings, crankshaft possibly broken.
Driving down the road and engine lost power and shut off. Took it to a shop and they said my crankshaft broke.
The contact owns a 2016 Nissan Titan. The contact stated that the low fuel pressure message was displayed, and the vehicle failed to start after several attempts. The contact stated that the failure was related to Emissions Recall: PD128. The contact stated that the vehicle was towed to the local dealer, where the engine was replaced, but the failure recurred. The dealer informed the contact about additional diagnostic testing. The manufacturer was contacted, who opened a case, but no additional assistance was provided. The approximate failure mileage was 83,000.
Questions about the 2016 Nissan Titan XD engine
Does the 2016 Nissan Titan XD have engine problems?
Owners have filed 135 complaints about the engine of the 2016 Nissan Titan XD, 68% of all its complaints, more than any other problem.
At what mileage do 2016 Nissan Titan XD engine problems start?
The typical (median) mileage in owner complaints is 25,500 miles.
Was there a recall on the 2016 Nissan Titan XD engine?
There is no recall for this problem on this model year.
Other 2016 Nissan Titan XD problems
Transmission 42Fuel system 31Electrical 23Acceleration 9Steering 8Body 7Brakes 5Driver assistance 5Airbags 3Lights 2Seats 2Seat belts 1Tires 1Wheels 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Nissan Titan XD?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history