Driving down [XXX] between Hulbert, Ok and Wagoner, Ok. And the crankshaft broke in two. Common issue on these trucks! But it left me stranded on a narrow two lane road! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
2016 Nissan Titan XD engine complaints
Page 3 of 6: complaints 41 to 70 of 135, newest first, as owners wrote them.
Without warning I had a loss of power while driving followed moments later by the engine completely shutting down and failure to restart causing vehicle to stop in the middle of the road because I had no power steering or breaking. Using an OBD2 scanner I was able to recover the following code "P0087 Fuel Rail Pressure/System -Too Low Bank ". Upon trying to restart the vehicle to no avail it gave this code "P00C6 Fuel Rail Pressure Too Low - Engine Cranking Bank 1". Using an Auto Agent EZ Lynk I was able to see the fuel pump was putting out 125PSI but the Injector pump has a desired output 4.5kPSI but was only putting out 0.3kPSI and wouldn't increase pressure during cranking. After talking to my local Nissan dealership service department I was told it appeared that either the injector pump or the motor had failed. The oil and filter was change on [XXX] and fuel filters were changed on [XXX]. And has always been changed at ORR Nissan in Searcy Arkansas. If this had happened as I was going down a major highway or interstate it could have resulted in a major accident with possible injury or death due to the loss of steering. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Broken crankshaft
I was cruising on highway at 65 miles per hour when engine start making noises and stop running engine will not start again i was lucky to make it out alive as truck steering wheel was not responsive had to tow it at mechanic to find out that truck had catastrophic engine failure broken crankshaft out of the blue
Went to pull out onto main road and the truck refused to accelerate instead it started to miss and lose power then the check engine light came on and the Reduce Engine Power warning was displayed. Shortly after that the truck died and will not start. A scan of the engine codes reveled a P0087 Fuel Rail/System pressure Too Low Bank 1 code. It appears that the Bosch CP4 Fuel Injector pump failed. Right before the engine died there was loud noises coming from the drivers side of the truck which sounded like it was coming from the engine compartment.
Engine suddenly shut off while on a short run with no load and couldn’t restart. Took it to the dealership and metal shaving's in the oil pan
While driving my 2016 Nissan Titan XD Cummins (86,000 miles) on the highway, the engine started making a loud clacking noise, followed by a loud breaking or displacement sound. The check engine light did not come on, and the truck did not go into limp mode. Possible issues might be crankshaft or bearing failure, piston or connecting rod damage, or a valve train problem. The vehicle is available for inspection upon request. There were no prior warning lamps, messages, or other symptoms before this failure. The problem has not yet been inspected or confirmed by a dealer or service center.
The contact owns a 2016 Nissan Titan. The contact stated that the vehicle was idling rough while being started. While driving at 5 MPH, the vehicle shut off unintendedly. The vehicle failed to restart. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed that the wiring harness and engine needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and opened a case. The manufacturer offered to assist with the cost of the repair. The failure mileage was approximately 85,000.
Driving on the intersate with no warning lights engine began to run rough, pulled over and shut engine off. Trailered it to a local shop, they found lots of metal in the oil. I tried to start it to drive it on the trailer but the engine had sized due to catastrophic engine failure. It has 89900 miles.
The Crankshaft snapped in at only 66k miles.
hi, i was driving on the free way to work hauling a small 10ft. trailer and my engine started knocking Badly! i get off free way start to head home and slowly take off and rpms take off and Boom. engine done.. so spun bearings/boken crank i havnt taken engine out to inspect yet because you cant buy a new engine and used engines are 10-12k. come to find out this engine has broken crank problems. not only could i have wrecked if it had blew on free way. but now im out of a truck that insurance wont pay. and still owe 24k to the bank.. thanks. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine failure -I was driving about 45-50 mph and as I was approaching a four way intersection with a stop sign approaching in my direction of travel. As I came to a stop, the engine locked up and could not be restarted. Leaving my truck dead in the middle of the road. After having it towed to a friend's shop I removed the oil pan, only to find a alot of copper colored metal shavings all throughout. I have an obd2 scan tool with live monitoring called a BlueDriver which connects via Bluetooth to my phone and allows me to monitor different sensors and checks for any trouble codes that the truck may currently have. I had this app open and was monitoring about 6 different sensors at the time. The truck never showed any signs of anything unusual or out of the ordinary. I also never had any warnings or the check engine light come on. After joining a few Facebook groups and online fourms, and I realized this was not a very rear occurrence and that many others have experienced similar engine failures as well.
The engine crankshaft failed and broke in half while driving. I was driving on the New Jersey turnpike on cruise control with a trailer and a mower and all of a sudden the motor is making [XXX] noises and I lose engine power completely. This is a huge defective part and one of the main components of a motor that should not fail and break in half like it did. It’s a major catastrophic failure that should be resolved with a recall. The danger and risk that involves this issue is ridiculous and it should be resolved immediately. I have kept up on my services like I should the truck has been well taken care of. After research I have seen there has been alot of people with the same issue with very low miles. Even with higher miles this issue should not happen. The cost of this repair is outrageous no vehicle owner should pay that on their own specially when they still owe a lot of money on the vehicle. There were no fatalities in my incident but there could have been and it could have been bad. The manufacturer needs to take responsibility with this issue and fix it and prevent future incidents and hopefully save a life if it occurs. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
I purchased this vehicle in 2022 with 62000 miles on it for $45000, cash first newer vehicle ever paid for in cash, 1st day i drove it, check engine light for turbo failure came on, i normally put 80-100k miles on a vehicle per year, ive owned over 200 diesel vehicles in last 25 years, never have i had one stay in the shop more than driving it. Not only does it stay in the shop, but you have to locate a shop that still has a diesel technician employed. Two turbo actuator replacements, lift pump replacement, 18 shop visits for check engine lights, 5 times in a row at buford ga nissan, drove away and light came back on before making it home. [XXX] my family and I was driving to florida , doing 55mph, No check engine lights, no noises, no warnings, motor shut down in 21 degree weather, side of [XXX] in tucker georgia for 4 hours waiting for a tow truck, only thing on screen was DEF error see dealer immediately, $550 to tow vehicle back to my house because closest dealership did NOT have a diesel tech, spent two months to find a company that would tow my truck 55 miles from gainesville georgia to roswell georgia to regal nissan, the girl called me and said it needed a starter for $900plus dollars, i laughed and said there's no way in hell a starter caused this motor to die, i informed her that if starter did Not work i was not paying, two days later she calls me back up and informs me the motor is locked up, does not know why, but pay them $178 diagnosis fee, and for $1300-$2000 they could tell me exactly what failed, if u read online, trucks like mine fail between 50000-100000 miles with no warning no nothing! i am now stuck with another $330 tow bill to pick vehicle up and store it at my shop and pray that your organization can hold NIssan accountable, Nissans recommendation was for $30000 to put the exact same unmodified garbage of a motor back in this truck, please somebody hold this company accountable!!!!!! thanks INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Bad crankshaft reported by dealership Only 70000 miles and well kept maintenance No warning lamps prior to failure
I was traveling on the freeway at 75 miles per hour, the truck began to bog down for a few seconds then started to shake violently as if a tire was falling off, a few seconds later the engine shut off at maybe 60 miles per hour. I was unable to steer or brake properly and had very little control of where I was able to pull over. I had no power at all and the truck would not start. I was stuck on [XXX] in central Utah with drivers side tires of the truck in traffic on the right lane unable to pull over more or move the truck to a safe location. My wife and daughter were in the vehicle and I made them exit the vehicle and find a somewhat safe place to sit on the side of the freeway. It failed completely without and check engine light, the engine temperature never spiked until after it failed. The vehicle was obstructing traffic for 45 minute to an hour while I waited for a small town mechanic to come and tow it. This incident occurred the end of May 2023 and the truck is still not functioning as I cannot afford the $18-22,000 engine replacement for a broken crankshaft. The vehicle has 77,000 miles on it. It failed without any warning signs and definitely put my life, my families life, and 1000's of passing motorists at risk for an hour straight as the vehicle was incapacitated and obstructing traffic. I have read 100's of forum posts an articles concerning this same issue with zero concern from Nissan. The local dealerships claim they have never heard of this issue, but it is a known issue and could cause a fatal or catastrophic accident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crank shaft failure premature 113,000 miles
Crankshaft broke while driving
Was driving at highway speed when truck started to misfire and run rough. I pulled over immediately to avoid any further damage. Truck was towed to local dealership and was diagnosed as an internal engine failure related to crankshaft or bearings.
Driving down the interstate at roughly 80mph. Truck started to shake violently almost causing me to loose control of truck and an enclosed trailer. Truck then shut down. No check engine lights or warnings. I coasted to a stop to find small fire in the engine bay. Got it towed to a mechanic, he drained the oil and found the oil pan was full of metal fragments. Suspected crank failure.
Broken crank issue. This is ridiculous. The truck only has 140,000 miles on it.
My crankshaft broke on me in the middle of a major highway and nissan would not do anything tried to give me a 42000 dollar bill that I can’t pay which is a complete rip off because this is happening to a lot of people that I have talked too
While driving to work on hwy 19 in new port richey fl. Motor started shaking and knocking really bad. Towed home and parked almost two months trying to get someone who could work on it. Dealership said needs new engine that cost as much as the truck is worth. Finally found a deisel mechanic that took it apart and said crankshaft was broken. It’s still at the shop til I can afford to repair/replace motor
Cam shaft and bearings failure Can not find a replacement Nissan estimate for new engine 32000
While traveling home from work, at approx. 35mph my truck engine stopped working. I tried to restart it several times, with no success. I had the truck towed home, and was informed by my mobile mechanic that the crankshaft In my engine was broken. This incident placed me in danger of being hit by other vehicles, and stranded for a couple of hours. My truck only has 105330 miles on it.
I was driving at 45mph when the truck came to a stop and mechanic diagnosed as a bad engine truck would crank but wouldnt start
Multiple Occasions of Driving on Road and the Engine shuts off. I have had to safely coast the truck off the road, after several minutes the truck starts again and drives fine. This is occurring Regularly. I may go a week with the Truck driving fine, then all of a sudden it powers down and shuts off.
While driving at 70 mph the engine stalled and bound up causing my vehicle to almost crash upon bringing it the dealership and after diagnosis they discovered the crank shaft and the bearings had exploded inside the engine causing it too cease also this dstroyed both turbos, the repairs to fix the vehicle are between 28-30k dollars and vehicle only had 88k on it and was babied and meticulous service records, nissan wanted to assume no responsibility for the failure at all and come to find out this is happening to alot of 5.0 Diesel nissan truck, there is word out there of a class action law suit and this needs to happend i could have been in a serious accident nissan is well aware of this terrible motor they put in the trucks so much they stopped production for diesel trucks, the parts are obsolete and they are not made any more so even the repairs are tough to come by they shouls atleast buy the vehicles off us or pay to get us out, many customers still had loans and the truck is no good
Engine has went out 2times in 6k miles first one made it just over 100k miles
1. The Crankshaft failed. The vehicle is available for inspection. Nissan has confirmed Crankshaft and engine to be unrepairable. 2. Event happened on a weekend late afternoon on a busy highway bridge. The titan was driving in the far left lane at 65-70 mph. Had to maneuver 2 lanes over down the bridge with no power to the engine. Safety for myself and many others on the highway bridge were put into danger as they had to maneuver out of my way while also driving around 65-70mph. Tow truck company also put in danger due to the busy nature of the highway when picking up vehicle. 3. Yes the problem cannot be reproduced because the vehicle is un-drivable. It has been confirmed by a dealer. 4. Yes the vehicle has been inspected at the local Nissan dealership. They stated the Crank shaft failed which led to the engine becoming unrepairable. 5. There were zero warning signs. I did not receive a single warning lamp, message or symptom. The vehicle experienced violent shaking followed by complete loss of power on the highway bridge, causing the engine to shut down. The titan had received all routine maintenance at the local Nissan dealership.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Nissan Titan XD?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history