2005 Pierce Quantum problems

What is wrong

Pierce Manufacturing (Pierce) is recalling certain 2004-2018 Arrow XT, Dash, Enforcer, Impel, Quantum and Velocity aerial vehicles. The aerial device may unexpectedly rotate to the right when the ladder is being extended.

Risk

If the aerial device moves in an unexpected direction, the ladder may contact an object, such as a building or an electrical wire, increasing the risk of injury.

Remedy

Pierce will notify owners, and dealers will reprogram the aerial control module, free of charge. The recall began February 28, 2019. Owners may contact Pierce customer service at 1‑888‑974‑3723. Pierce's number for this recall is 74B295.

Recall number 19V022000 · Recall details

What is wrong

Pierce Manufacturing (Pierce) is recalling certain 1999-2013 Arrow XT, Dash, Enforcer, Quantum and Velocity fire trucks equipped with the electric All-steer rear steering option. The affected vehicles have rear steer axle shafts that were not properly heat treated.

Risk

Axle shafts that are not properly heat treated may break and potentially disable the vehicle, increasing the risk of a crash.

Remedy

Pierce will notify owners, and dealers will replace the rear steer axle shafts, free of charge. An interim notice was mailed on July 24, 2017. The recall began June 3, 2020. Owners may contact Pierce customer service at 1‑888‑974‑3723.

Recall number 17V348000 · Recall details

What is wrong

Pierce manufacturing (pierce) is recalling certain model year 2005, 2008-2011 arrow xt, custom contender, dash, enforcer, impel, quantum, saber, and velocity 75 foot hal (heavy aluminum ladder) fire apparatus bodies vehicles manufactured from may 17,2005, through october 13, 2011, that may be equipped with dual scba cylinder storage compartments. These compartments extend inboard horizontally from the side of the rear body. The scba compartment door latch orientation may have been manufactured incorrectly, allowing the door to accidentally open while the vehicle is in motion. The door may open without warning and without knowledge to the driver.

Risk

If the door opens, the scba cylinders may fall out of the compartment and onto the roadway, increasing the risk of a crash or injury to pedestrians.

Remedy

Pierce dealers will notify owners, and will install a flat reinforcement plate that spans the length of the scba door. This service will be performed free of charge. The safety recall began on december 5, 2011. Owners may contact pierce at 1‑920‑832‑3000.

Recall number 11V551000 · Recall details

What is wrong

On certain fire trucks, interference may occur between the aerial front axle interlock sensor bracket and the front air brake hose. This condition occurs during full turn steering and full suspension jounce compression.

Risk

This interference may cause chafing leading to a potential front air brake hose failure. In the event of a front brake hose failure, loss of front braking will occur, increasing the risk of a crash.

Remedy

Dealers will remove the existing front axle interlock sensor bracket and install a new bracket in a new location avoiding the front axle brake hose. The recall began on october 13, 2005. Owners may contact pierce at 920‑832‑3249.

Recall number 05V355000 · Recall details

What is wrong

Certain fire trucks equipped with holland/neway air suspension systems, a transverse beam castings may fracture under normal loads. If a casting breaks when the vehicle is traveling on a roadway there is the potential for pieces of the casting to become projectiles and the suspension?s transverse beam may drop down low enough to contact the road surface.

Risk

This will cause sparks that could potentially ignite and cause a fire.

Remedy

Holland is handling the owner notification and remedy for this campaign. Dealers will inspect and replace the defective transverse beam assemblies free of charge. Owners may contact holland at 616‑396‑6501 or pierce at 1‑888‑974‑3723.

Recall number 05V220000 · Recall details